2014 HYUNDAI SONATA HYBRID

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock B

SEAT BELTS:FRONT:ANCHORAGE

Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

SEAT BELTS:PRETENSIONER

Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

Hybrid system warning. Safely drop don’t drive. It comes and goes for all hybrids it has the issue

The contact owns a 2014 Hyundai Sonata Hybrid. The contact stated while driving 60 MPH, there was a knocking sound coming from the engine compartment, after which the vehicle lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle stalled and failed to restart. Several unknow warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the rod bearings and observed metal shavings inside the short block. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V226000 (Engine and Engine Cooling) however, the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 134,000.

Mileage: 134,000

The contact owns a 2014 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to start the vehicle the brake pedal went to the floorboard. The contact replaced the brake pads; however, the failure persisted. The dealer was made aware of the failure and confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 172,453. Parts distribution disconnect.

Mileage: 172,453

The contact owns a 2014 Hyundai Sonata Hybrid. The contact received notification NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was made aware of the issue and confirmed that parts were not available. The manufacturer was not notified of the issue. The contact had not experienced a failure. VIN tool showed no open recalls.

The contact owns a 2014 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The contact stated that while driving approximately 30 MPH, the vehicle stalled. The vehicle was not able to be restarted. The vehicle was towed to an independent dealer where it was diagnosed and determined that the battery fuse needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

Mileage: 60,000

The contact owns a 2014 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2014 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2014 Hyundai Sonata Hybrid. The contact stated that while operating the vehicle, the message "Brake System Malfunction - Vehicle Will Turn Off for Safety" was displayed on the instrument panel and the vehicle turned off. The vehicle was towed to the local dealer who determined that the ABS module was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was included in the NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the remedy was not yet available and did not include replacement of the ABS module. The failure mileage was 160,000.

Mileage: 160,000

The contact owns a 2014 Hyundai Sonata Hybrid. The contact stated while driving onto an on-ramp at an unknown speed, an abnormal knocking noise was heard. The vehicle was able to accelerate to approximately 40 MPH. The contact stated there was no warning light illuminated. The vehicle was driven home and then to a dealer. While at the dealer, the failure was diagnosed as a piston failure. The contact referenced NHTSA Campaign Number: 20V746000 (Engine), and the VIN was included in the recall. The contact stated that the vehicle was not repaired under the recall. The contact stated that the dealer provided the test results to the manufacturer. The contact stated that the recall repairs were denied by the manufacturer due to negligent maintenance. The contact stated that he had owned the vehicle for 3-weeks. The manufacturer was not notified of the failure. The approximate failure mileage was 116,000.

Mileage: 116,000

I WAS DRIVING 20 MPH STRAIGHT DOWN A FLAT RESIDENTAL STREET. A LOUD DASH ALARM SOUNDED IN MY 2014 HYUNDAI SONADA HYBRID. THE DASH DISPLAYED "HYBRID SYSTEM WARNING, SAFELY STOP AND DO NOT DRIVE" . BELOW THE WARNING A YELLOW CAUTION TRIANGLE DISPLAYED. I ATTEMPTED TO GIVE THE VEHICLE GAS, SO I COULD PULL TO THE SIDE OF THE ROAD, BUT THE ENGINE ACTED LIKE IT HAD NO POWER. A BLINKING GREEN "READY" LIGHT WAS DISPLAYED. THE ECO GUIDE DISPLAY WAS MOVING UP AND DOWN FROM THE TOP TO BOTTOM. I TOOK MY FOOT OFF THE GAS PEDAL AND BEGAN BRAKING. THE BRAKES FELT MUSHY AND THE VEHICLE WAS NOT STOPPING. WITHIN A FEW SECONDS THE VEHICLE SHOOK AND WAS THE ENGINE WAS REVVING UP AND DOWN BUT LIKE IT WAS OUT OF GEAR. AFTER APPROXIMATELY 10-15 SECONDS, I LOST THE POWER STEERING AND THE IT WAS ALMOST IMPOSSIBLE TO TURN THE STEERING WHEEL. I AGAIN TRIED BRAKING BUT THE BRAKES JUST FELT MUSHY AND WERE NOT STOPPING THE VEHICLE. I CONTINUED COASTING DOWN THE ROAD AND EVENTUALLY USED THE EMERGENCY BRAKE TO S

Mileage: 79,684

I WAS DRIVING 20 MPH STRAIGHT DOWN A FLAT RESIDENTAL STREET. A LOUD DASH ALARM SOUNDED IN MY 2014 HYUNDAI SONADA HYBRID. THE DASH DISPLAYED "HYBRID SYSTEM WARNING, SAFELY STOP AND DO NOT DRIVE" . BELOW THE WARNING A YELLOW CAUTION TRIANGLE DISPLAYED. I ATTEMPTED TO GIVE THE VEHICLE GAS, SO I COULD PULL TO THE SIDE OF THE ROAD, BUT THE ENGINE ACTED LIKE IT HAD NO POWER. A BLINKING GREEN "READY" LIGHT WAS DISPLAYED. THE ECO GUIDE DISPLAY WAS MOVING UP AND DOWN FROM THE TOP TO BOTTOM. I TOOK MY FOOT OFF THE GAS PEDAL AND BEGAN BRAKING. THE BRAKES FELT MUSHY AND THE VEHICLE WAS NOT STOPPING. WITHIN A FEW SECONDS THE VEHICLE SHOOK AND WAS THE ENGINE WAS REVVING UP AND DOWN BUT LIKE IT WAS OUT OF GEAR. AFTER APPROXIMATELY 10-15 SECONDS, I LOST THE POWER STEERING AND THE IT WAS ALMOST IMPOSSIBLE TO TURN THE STEERING WHEEL. I AGAIN TRIED BRAKING BUT THE BRAKES JUST FELT MUSHY AND WERE NOT STOPPING THE VEHICLE. I CONTINUED COASTING DOWN THE ROAD AND EVENTUALLY USED THE EMERGENCY BRAKE TO S

Mileage: 79,684

I WAS DRIVING 20 MPH STRAIGHT DOWN A FLAT RESIDENTAL STREET. A LOUD DASH ALARM SOUNDED IN MY 2014 HYUNDAI SONADA HYBRID. THE DASH DISPLAYED "HYBRID SYSTEM WARNING, SAFELY STOP AND DO NOT DRIVE" . BELOW THE WARNING A YELLOW CAUTION TRIANGLE DISPLAYED. I ATTEMPTED TO GIVE THE VEHICLE GAS, SO I COULD PULL TO THE SIDE OF THE ROAD, BUT THE ENGINE ACTED LIKE IT HAD NO POWER. A BLINKING GREEN "READY" LIGHT WAS DISPLAYED. THE ECO GUIDE DISPLAY WAS MOVING UP AND DOWN FROM THE TOP TO BOTTOM. I TOOK MY FOOT OFF THE GAS PEDAL AND BEGAN BRAKING. THE BRAKES FELT MUSHY AND THE VEHICLE WAS NOT STOPPING. WITHIN A FEW SECONDS THE VEHICLE SHOOK AND WAS THE ENGINE WAS REVVING UP AND DOWN BUT LIKE IT WAS OUT OF GEAR. AFTER APPROXIMATELY 10-15 SECONDS, I LOST THE POWER STEERING AND THE IT WAS ALMOST IMPOSSIBLE TO TURN THE STEERING WHEEL. I AGAIN TRIED BRAKING BUT THE BRAKES JUST FELT MUSHY AND WERE NOT STOPPING THE VEHICLE. I CONTINUED COASTING DOWN THE ROAD AND EVENTUALLY USED THE EMERGENCY BRAKE TO S

Mileage: 79,684

WHILE IN MOTION GOING 60MPH, VEHICLE SPUTTERED AND THEN AN ALARM SOUNDED ALONG WITH A WARNING DISPLAYED ON THE DRIVERS SIDE SCREEN STATING "HYBRID SAFETY WARNING. PULL OVER AND DO NOT DRIVE." THE CAR WOULD NO LONGER ACCELERATE AND CAME TO A STOP. HAD TO RESTART THE CAR. THE SAME WARNING HAPPENED AGAIN THE FOLLOWING DAY WHILE IN MOTION GOING 50MPH. HAD TO GET OUT OF THE ROADWAY AND RESTART THE CAR. HYUNDAI REPLACED THE ENTIRE ENGINE UNDER MANUFACTURER WARRANTY (TOOK ABOUT 5 MONTHS). UPON RECEIVING VEHICLE BACK, THE SAME ISSUE HAPPENED IN THE FIRST 10 MINS OF DRIVING IT (ISSUE NOT FIXED). IT IS BACK AT THE HYUNDAI SERVICE CENTER AWAITING REPAIR.

Mileage: 56,500

WHILE VEHICLE IN MOTION, CAR JUST STOP OVERSUDAN WITH A SPOKEN MESSAGE: " HYBRID CELLS VEHICLE IS IN DANGER. CAR WILL STOP"AND AFTER THIS MESSGAE, CAR STALLS WITH NO CONTROL ON THE BREAKS AND STERINGWHEEL.

Mileage: 100,000

WHILE VEHICLE IN MOTION, CAR JUST STOP OVERSUDAN WITH A SPOKEN MESSAGE: " HYBRID CELLS VEHICLE IS IN DANGER. CAR WILL STOP"AND AFTER THIS MESSGAE, CAR STALLS WITH NO CONTROL ON THE BREAKS AND STERINGWHEEL.

Mileage: 100,000

WHILE VEHICLE IN MOTION, CAR JUST STOP OVERSUDAN WITH A SPOKEN MESSAGE: " HYBRID CELLS VEHICLE IS IN DANGER. CAR WILL STOP"AND AFTER THIS MESSGAE, CAR STALLS WITH NO CONTROL ON THE BREAKS AND STERINGWHEEL.

Mileage: 100,000

SEATBELT POPS OUT OF THE SEATBELT RECEIVER AND MOST OF THE TIME, SEATBELT DOES NOT ATTACH TO RECEIVER AT ALL. DOES NOT ATTACH PROPERLY. THIS IS HAPPENING FOR LONG TIME BUT I DID NOT KNOW ABOUT THIS SITE THAT WE CAN FILE A SAFETY ISSUES ON CARS.

Mileage: 88,000

2 TIMES THE ENGINE STALLED IN THE MIDDLE OF AN INTERSECTION DUE TO HYBRID SYSTEM FAILURE. A SIMPLE FUSE FOR THE HYBRID SYSTEM WENT OUT AND TURNED OFF ALL POWER. THE MAIN ISSUE IS THAT THIS IS A VERY DANGEROUS DESIGN FLAW. OTHER HYBRID VEHICLES HAVE A SAFETY FEATURE THAT WHEN THE HYBRID SYSTEM IS NOT WORKING THE GASOLINE ENGINE WILL STILL BE IN FULL OPERATION. EVERYTIME THE ENGINE LIGHT GOES ON IT KILLS THE WHOLE CAR. I GOT STUCK ON AN EXPRESSWAY AND WAS PUT IN A DANGEROUS SITUATION WHEN THIS DID NOT HAVE TO HAPPEN BECAUSE THEY DON'T HAVE TO MAKE THE 2 MOTORS COMPLETELY DEPENDENT ON EACH OTHER. HAVING THE GASOLINE ENGINE CONTINUE TO RUN AND BE ABLE TO POWER THE CAR IN A HYBRID SYSTEM FAILURE WILL SAVE SOMEONE'S LIFE. I AM NOT SURE WHY THIS IS NOT A REQUIREMENT BY LAW TO HAVE THIS SAFETY FEATURE

Mileage: 99,000

2 TIMES THE ENGINE STALLED IN THE MIDDLE OF AN INTERSECTION DUE TO HYBRID SYSTEM FAILURE. A SIMPLE FUSE FOR THE HYBRID SYSTEM WENT OUT AND TURNED OFF ALL POWER. THE MAIN ISSUE IS THAT THIS IS A VERY DANGEROUS DESIGN FLAW. OTHER HYBRID VEHICLES HAVE A SAFETY FEATURE THAT WHEN THE HYBRID SYSTEM IS NOT WORKING THE GASOLINE ENGINE WILL STILL BE IN FULL OPERATION. EVERYTIME THE ENGINE LIGHT GOES ON IT KILLS THE WHOLE CAR. I GOT STUCK ON AN EXPRESSWAY AND WAS PUT IN A DANGEROUS SITUATION WHEN THIS DID NOT HAVE TO HAPPEN BECAUSE THEY DON'T HAVE TO MAKE THE 2 MOTORS COMPLETELY DEPENDENT ON EACH OTHER. HAVING THE GASOLINE ENGINE CONTINUE TO RUN AND BE ABLE TO POWER THE CAR IN A HYBRID SYSTEM FAILURE WILL SAVE SOMEONE'S LIFE. I AM NOT SURE WHY THIS IS NOT A REQUIREMENT BY LAW TO HAVE THIS SAFETY FEATURE

Mileage: 99,000

WHILE DRIVING CAR SYSTEM WARNING CAME ON TO" SAFELY STOP AND DO NOT DRIVE". WAS ABLE TO PULL OVER AND STOP CAR. COULD NOT RESTART IT. HAD IT TOWED THEN CHANGED BATTERY WHICH WAS LOW. TRIED TO RESTART AND DID NOT TURN ON UNTIL 3RD TIME STARTING. LET ENGINE RUN FOR ABOUT 10 MIN AND WARNING CAME BACK ON.

Mileage: 129,759