HYUNDAI SONATA · model year

2005 HYUNDAI SONATA

217 NHTSA complaints, 44 crash reports, and 1 active recall for this specific cohort.

NHTSA overall rating

Not crash-tested

New Car Assessment Program

The 2005HYUNDAISONATA carries 217 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 44 crashes, 6 fires, 36 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.

Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2005 SONATA is air bags with 45 filings, followed by suspension (25) and structure:body (22). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.

NHTSA currently has 37 investigation files overlapping the 2005 SONATA, and 1 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.

217
Complaints
44
Crashes
6
Fires
36
Injuries
0
Deaths

Total Complaints

217 filings

Crashes Reported

44 reports

Source

NHTSA ODI

Federal complaints database

Complaints vs. fleet median (215)

Above median complaint volume, review patterns below.

Complaints by Component

ComponentCount
AIR BAGS45
SUSPENSION25
STRUCTURE:BODY22
ELECTRICAL SYSTEM14
EXTERIOR LIGHTING11
AIR BAGS:FRONTAL10
VEHICLE SPEED CONTROL6
SERVICE BRAKES6
ENGINE6
UNKNOWN OR OTHER6
SERVICE BRAKES, HYDRAULIC5
FUEL SYSTEM, GASOLINE4
EXTERIOR LIGHTING:BRAKE LIGHTS4
STRUCTURE3
POWER TRAIN3

Recalls (1)

09V28000021/07/2009

EXTERIOR LIGHTING

HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEAS

Recent Complaints

20250601AIR BAGS

Air Bag light stays on and cannot pass stare inspection without repair. NHSTA site has 54 reports of this issue and dealer cannot figure out how to repair. What can be done?

20231219SUSPENSION

My car's engine cradle, cross member or subframe is rusted out and the OEM replacement for my VIN number won't fit it correctly I'm getting really upset because this could be dangerous for me and my two young kids. I've already paid the mechanic $600 for the replacement part when it really only costs $450 at the most and the two he has ordered before have both been either too big and it says that it is the correct replacement part. What is going on?!!! If something isn't fixed soon and something happens to me or my kids there is going to be a lawsuit.

20231219ENGINE

My car's engine cradle, cross member or subframe is rusted out and the OEM replacement for my VIN number won't fit it correctly I'm getting really upset because this could be dangerous for me and my two young kids. I've already paid the mechanic $600 for the replacement part when it really only costs $450 at the most and the two he has ordered before have both been either too big and it says that it is the correct replacement part. What is going on?!!! If something isn't fixed soon and something happens to me or my kids there is going to be a lawsuit.

20231030STRUCTURE:BODY

I took my car to the mechanic for a “once over” before driving from New Jersey to North Carolina. This car has only 41,000 original miles on it as we bought it new in 2005. Upon inspection, the mechanic came back with certain repairs that are needed due to age; but he was extremely concerned about a severe safety issue that the subframe had rotted out and needed to be replaced. This is a known corrosion issue with other years of manufacture for this model. There was a class action suit for this specific issue for 1999 to 2004 Sonatas. The subframe threatens to collapse from rust at any time and is an extreme hazard to the driver, passengers, and others on the road. There was absolutely no warning of this issue prior to this inspection, making it even more dangerous as it affects many drivers who are unaware of the issue.

20230807STRUCTURE:BODY

Severely rusted out and corroded front subframe, only noticed it on accident very recently, and my car is the last year of a generation that was recalled for this very issue within the Salt Belt- I live right at the bottom outskirts of the Salt Belt in NKY, and my car is the only year not recalled for subframe corrosion. It's bad and I'm freaked out and can't afford it unless I figure out how to do it myself without prematurely dying due to a dropped engine or something similar (premature because if I don't get it fixed soon I reckon that fate isn't too far off)

20230807SUSPENSION

Severely rusted out and corroded front subframe, only noticed it on accident very recently, and my car is the last year of a generation that was recalled for this very issue within the Salt Belt- I live right at the bottom outskirts of the Salt Belt in NKY, and my car is the only year not recalled for subframe corrosion. It's bad and I'm freaked out and can't afford it unless I figure out how to do it myself without prematurely dying due to a dropped engine or something similar (premature because if I don't get it fixed soon I reckon that fate isn't too far off)

20230315UNKNOWN OR OTHER

Clunking sound when turning corners, took to mechanic, sub frame rotted through. Unsafe to drive.

20220127SUSPENSION

The contact owns a 2005 Hyundai Sonata. The contact stated that while her daughter was driving at 45 MPH, the vehicle rode over a pothole which caused a fracture in the subframe. The contact had taken the vehicle to several independent mechanics and was informed that the failure was caused by severe salt corrosion. The dealer and the manufacturer were notified of the failure and informed her that there were no recalls associated with the VIN. The vehicle was not repaired. The failure mileage was approximately 134,000. Consumer stated part# FC112 is used for 2003, 2004 AND 2005. 2003 AND 2004 of the same make and model are already recalled for the same issue with the subframe having rust due to excessive salt exposure, but SOMEHOW the 2005 which is EXACTLY the same part and problem has not been recalled.

Mileage: 134,000

20211023SUSPENSION

My mechanic just took a picture of the subframe of the car which is almost completely rusted through. He said that this is extremely dangerous and that if it was to break while driving the car, I would loose control. I have seen numerous complaints about this on the 2005 Hyundai Sonata on the internet which makes me think this is a common issue.

20211013SUSPENSION

Upon inspecting the undercarriage of my vehicle found the right side of Front Subframe Cradle Suspension rotted almost completely through. When researching for issues pertaining to this model found a TSA was issued , after a lawsuit in California, for the years prior and after my vehicle. The damage is concurrent with the TSA bulletin but excluded. How does a manufacturer whom obviously is aware of an ongoing issue allow so many people, families and children, drive and risk their lives on our public roadways. Is their a subclass recall that will aid those like myself take corrective action.

20211013STRUCTURE:BODY

Upon inspecting the undercarriage of my vehicle found the right side of Front Subframe Cradle Suspension rotted almost completely through. When researching for issues pertaining to this model found a TSA was issued , after a lawsuit in California, for the years prior and after my vehicle. The damage is concurrent with the TSA bulletin but excluded. How does a manufacturer whom obviously is aware of an ongoing issue allow so many people, families and children, drive and risk their lives on our public roadways. Is their a subclass recall that will aid those like myself take corrective action.

20210827SUSPENSION

The contact owns a 2005 Hyundai Sonata. The contact stated while having a state inspection performed, the inspector informed the contact that the sub-frame was completely rusted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 09V124000 (Suspension) however, the VIN was not included. The manufacturer was informed of the failure and informed the contact that the vehicle was not included in a recall. The failure mileage was approximately 129,000.

Mileage: 129,000

20210609SUSPENSION

I had taken my 2005 Hundai Sonata to my local mechanic for a tire alignment, and it is then when I was told that the front subframe was rusted from the inside. There was no indicator of this beforehand, and had it been let be, I could have lost control of the car while driving and been in an accident.

20201013STRUCTURE:BODY

BOTH THE REAR AND FRONT SUBFRAME HAVE HOLES FROM RUST WHICH HAS STARTED TO CAUSE NUMEROUS OTHER ISSUES SUCH HAS BALL JOINTS TIE ROD ENDS

Mileage: 169,000

20201013SUSPENSION

BOTH THE REAR AND FRONT SUBFRAME HAVE HOLES FROM RUST WHICH HAS STARTED TO CAUSE NUMEROUS OTHER ISSUES SUCH HAS BALL JOINTS TIE ROD ENDS

Mileage: 169,000

20201011AIR BAGS

THE AIR BAG LIGHT IS ON AND IT WON'T GO OFF. THIS IS ALL THE TIME WHEN THE CAR IS STATIONARY, OR MOVING. WHEN YOU TURN THE CAR ON AND OFF, IT'S STILL ON.

20200706SUSPENSION

2005 HYUNDAI SONATA FRONT SUB-FRAME FAILURE. THE SUB FRAME HAS RUSTED THROUGH AND WHILE DRIVING IT BROKE. THIS COULD HAVE CAUSED A TERRIBLE ACCIDENT. HYUNDAI WAS SUED IN A CLASS ACTION LAWSUIT FOR MODEL YEARS 1999-2004 IN UNITED STATES DISTRICT COURT OF CALIFORNIA. MY MODEL YEAR WAS NOT INCLUDED IN THIS LAWSUIT. HOWEVER, MY SONATA HAS THE SAME ISSUE. I HAVE MADE SEVERAL ATTEMPTS TO CONTACT HYUNDAI ASKING THAT THEY REPAIR MY VEHICLE. LISTED BELOW IS A PARTIAL LIST OF MY CORRESPONDENCE WITH THEM. 1/29/2020 CALLED HYUNDAI TALKED TO DANIELLE TO FILE INITIAL COMPLAINT, SHE INSTRUCTED ME TO TAKE THE VEHICLE TO MY LOCAL DEALER ( MIKE MILLER OF PEORIA, IL ) FOR AND INSPECTION. 2/3/2020 ' P.A. DENIED [XX] FROM HYUNDAI SAID THEY WILL DO A ONE TIME EXTENDED WARRANTY TO FIX THE DEFECT. BUT THEY DID NOT FIX THE VEHICLE. 2/5/2020 ' REQUEST THAT HYUNDAI CONSUMER AFFAIRS CALL ME. 2/6/2020 ' [XXX] (FROM THE WARRANTY TEAM) SAYS IT WILL COST $2,019 TO FIX 2/10/2020 ' FILED A COMPLAINT WITH THE BBB 2/1

Mileage: 101,780

20191209STRUCTURE:BODY

TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT THE SUBFRAME WAS COMPLETELY RUSTED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 147,000. *LN*JB

Mileage: 147,000

20191207SUSPENSION

RUST HOLES THROUGH ENGINE CRADLE OR SUB FRAME. THIS CAR HAS ONLY 39,900 MILES ON IT AND WAS WELL MAINTAINED. WHILE GETTING OIL CHANGED THE MECHANIC SHOWED ME THE PROBLEM AND TOLD ME TO CONTACT THE HYUNDAI DEALER AND TELL THEM ABOUT IT. I CALLED AND THEY TOLD ME THERE WAS NOTHING THEY WOULD DO, I HAD TO PAY FOR THE REPAIRS.

20190902STRUCTURE:BODY

WHILE CHANGING MY OIL ON THE WEEKEND, I NOTICED SEVERE CORROSION FAILURES WITH THE FRONT SUBFRAME ON THE RIGHT SIDE OF MY CAR. (SEE ATTACHED PHOTOS). ONE AREA WAS IN FRONT OF THE LOWER CONTROL ARM AND ANOTHER AREA IS BEHIND THE CONTROL ARM. IT LOOKS LIKE THE SUBFRAME WILL FAIL AT ANY MOMENT AND THE CONTROL ARM WOULD BE FREE TO MOVE ANYWHERE. THIS WOULD SIGNIFICANTLY AFFECT CONTROL OF THE VEHICLE AND BE A SERIOUS SAFETY CONCERN. I SEE THIS PART HAS ALREADY HAD A RECALL FOR 2001 TO 2004 HYUNDAI SONATAS WHICH IS THE SAME BODY AND FRAME STYLE AS THE 2005 VEHICLE. RECALL #09V124000.

Mileage: 122,034

Compare 2005HYUNDAISONATA to Similar Vehicles

NHTSA Investigations 1 Open

View all investigations

Frequently Asked Questions

How many complaints does the 2005 HYUNDAI SONATA have?
The 2005 HYUNDAI SONATA has 217 NHTSA complaints, 44 crashes, 6 fires, 36 injuries, and 0 deaths reported.
Are there any recalls for the 2005 HYUNDAI SONATA?
Yes, the 2005 HYUNDAI SONATA has 1 recall(s). The most common affected component is EXTERIOR LIGHTING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2005 HYUNDAI SONATA?
The most-complained component for the 2005 HYUNDAI SONATA is AIR BAGS with 45 complaints. Other frequently reported areas include SUSPENSION and STRUCTURE:BODY.
Is the 2005 HYUNDAI SONATA safe to buy?
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.

Vehicle Safety Guides

Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.