2020 HYUNDAI SANTA FE

VISIBILITY:WINDSHIELD

Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.

TRAILER HITCHES

Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water acc

The roof of my car between the sunroof and the windshield (called panoramic sunroof) shattered as I was driving down the highway. It was about 10:00 pm on a weeknight and there were no cars within sight distance in front of me. When it happened it sounded like a gun shot going off at point blank range and I immediately pulled over and checked for bullet holes. Since it was dark I could not see any damage. Today I took the car and had a small chip fixed in my windshield down by the windshield wipers and the service tech pointed out to me that the roof was shattered. He told me that this happens a lot with this vehicle. So I got online and searched and found a lot of vehicles have reported the exact problem. Down to the sounds of gunshots. So I stopped at my local Hyundai dealership and recorded the conversation. He told me that theres no recalls on this car and It probably shattered by a rock or debris. I told him that when this happened it was late night and no cars within sight in fro

On the morning of December 10, 2025, I left my home for an appointment. I traveled for about 15 minutes before entering onto the highway. As I entered the highway, I traveled about half a mile and was scared by a very loud explosion! I pulled over to assess my vehicle and the surrounding area. The sunroof had SHATTERED to pieces, fortunately I didn’t have it open at the time. It was just a miracle I didn’t have an accident from being startled, or receive any cuts or injuries due to this unforeseen event. As I was driving, there was very little to no traffic and I never heard anything like hit the car or window or anything. I called my insurance company and filed a claim. They eventually had me to take it to a Collision Center 12/22/2025. They removed all glass from sunroof, and determined that there was an issue with the glass rack, and it would end up being very costly. My Insurance Provider contacted me to say they would not be able to provide coverage due to the cost and finding

While driving, the engine catastrophically failed without warning, causing an immediate loss of power-assisted braking and steering. The failure occurred while traveling downhill. I was unable to slow or control the vehicle properly and was forced to proceed through a school bus’s flashing lights to avoid a potentially catastrophic collision, resulting in a traffic citation. My son was in the vehicle at the time. A sudden loss of engine power, braking assist, and steering assist while driving presents a serious safety defect. Vehicle was towed to Fred Beans Hyundai in Doylestown where it has been confirmed engine failure. This failure happened immediately and without warning.

While driving, the engine catastrophically failed without warning, causing an immediate loss of power-assisted braking and steering. The failure occurred while traveling downhill. I was unable to slow or control the vehicle properly and was forced to proceed through a school bus’s flashing lights to avoid a potentially catastrophic collision, resulting in a traffic citation. My son was in the vehicle at the time. A sudden loss of engine power, braking assist, and steering assist while driving presents a serious safety defect. Vehicle was towed to Fred Beans Hyundai in Doylestown where it has been confirmed engine failure. This failure happened immediately and without warning.

While driving, the engine catastrophically failed without warning, causing an immediate loss of power-assisted braking and steering. The failure occurred while traveling downhill. I was unable to slow or control the vehicle properly and was forced to proceed through a school bus’s flashing lights to avoid a potentially catastrophic collision, resulting in a traffic citation. My son was in the vehicle at the time. A sudden loss of engine power, braking assist, and steering assist while driving presents a serious safety defect. Vehicle was towed to Fred Beans Hyundai in Doylestown where it has been confirmed engine failure. This failure happened immediately and without warning.

Excessive oil burn off. Oil is getting into the cylinder, causing scorching. This causing engine failure.

Oil drain plug seal leaking, can’t tighten the bolt with the required torque setting to keep it from leaking.

After 110,000, the engine started using oil and it began to knock. According to the history of these engines, it will lead to engine failure. They have a record of being a lemon engine and there is not a engine of this type that this does not happen. The engine needs to recalled and replaced, They are the Theda II GDI series of 2.0L and 2.4L four-cylinder engines from Hyundai/Kia.

I have a 2020 Hyundai Santa Fe, 2.0T. I recently experienced the following issues; gasoline fumes coming into the car at low speeds, difficulty starting the car when it is cold and hesitation when trying to accelerate quickly. The check engine light came on and the dealer diagnosed a faulty fuel pump and high pressure hoses......on a car with only 49100 miles! The repair cars are estimated at over $1800. This is totally unacceptable and there should be a manufacturer issued recall on the car where Hyundai covers the cost of the repairs.

Transmission issues with DTC light coming on, dealership did software update which did not resolve the problem. Transmission has rough shift and shuddering. Dealership is recommending complete transmission replacement.

2020 SantaFe Limited AWD with ~81200 miles. This is the 3rd or 4th time the P07410 code pops up with the Engine Check light. Hyundai said they found no issues and cleared the code, again. There was once when the code came up and it cleared itself after 50 miles. Not sure exactly what the cause is and Hyundai is saying "there is nothing wrong". Most recent occurrence Sept.4.2025.

2020 SantaFe Limited AWD with ~81200 miles. This is the 3rd or 4th time the P07410 code pops up with the Engine Check light. Hyundai said they found no issues and cleared the code, again. There was once when the code came up and it cleared itself after 50 miles. Not sure exactly what the cause is and Hyundai is saying "there is nothing wrong". Most recent occurrence Sept.4.2025.

2020 Hyundai SantaFe Limited AWD ... burning excessive oil. This only was noticed because the low oil light intermittently started coming on, and has only started happening in the last few months. low oil indicator flashing - 4QT low, went for an immediate oil change 78788 miles - oil changed 80252 miles - low oil - added 1QT 80628 miles - low oil - added 1QT 81376 miles - oil changed 81999 miles - low oil - added 1QT 82755 miles - low oil - added 2QT These are the most recent events since we started logging it.

Excessive oil consumption under warranty, . Hyundai says its normal consumption within 1,000 miles. engine its doing stalls now.

Excessive oil consumption under warranty, . Hyundai says its normal consumption within 1,000 miles. engine its doing stalls now.

My engine has been sucking up oil since the day I bought it. Once I hit 100k miles it started sucking up oil faster than the recommended oil changes. I was driving home two weeks ago. I went to get in a major highway and she would not go past 35 mph. I went to trade it in and was told it needs a new engine and a new turbo. This is a known problem and Hyundai will not fix it. This car is not even 4 years old. I got it in April 2021

I had been driving about 1.5 hours when I exited the Interstate and the car engine shut off at a traffic light. When I shifted the car into park and tried to restart the car, smoke filled the cabin. Unbeknownst to me, an oil leak occurred while driving. No warning lights or other indicators that anything was awry. I had the vehicle towed to the nearest Hyundai dealer. Though the suv is under warranty, they say the oil leak was caused by improper oil plug installation at the last oil change. The oil leak caused the motor to seize and the resulting damage is in excess of $10,000. Hyundai says the warranty won't cover this as it is a service issue. Jiffy Lube says their technician did nothing incorrect and they won't take responsibility for the repairs.

I had been driving about 1.5 hours when I exited the Interstate and the car engine shut off at a traffic light. When I shifted the car into park and tried to restart the car, smoke filled the cabin. Unbeknownst to me, an oil leak occurred while driving. No warning lights or other indicators that anything was awry. I had the vehicle towed to the nearest Hyundai dealer. Though the suv is under warranty, they say the oil leak was caused by improper oil plug installation at the last oil change. The oil leak caused the motor to seize and the resulting damage is in excess of $10,000. Hyundai says the warranty won't cover this as it is a service issue. Jiffy Lube says their technician did nothing incorrect and they won't take responsibility for the repairs.

Excessive oil consumption. Mechanic who changed oil said oil level was too low and he could find no leaks. He said this is a known Hyundai problem. The dealer acknowledged this. There was no warning light saying the oil was low. It was discovered during a routine oil change.

I had my oil changed at a reputable service center November 19, 2025 and the mechanic said my oil drip pan and plug needed to be replaced in the next few months because they were showing wear and could fail. He asked if I knew about a pending lawsuit against Hyundai concerning these items causing major issues. I said I was unaware, so I researched it. It seems to be legit. During my research there were multiple reports that many had oil leaking problems and some owners reported that the vehicle completely stopped running. That is especially dangerous driving on an Interstate. I was quoted about $350.00 to replace the pan and plug but I was told to contact the local dealership to see if they would replace it. They wanted $215.00 for a diagnostic plus parts and labor. That is quite a chunk of money for a drip pan and plug.