2019 HYUNDAI KONA

ENGINE

Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Elantra, 2019-2021 Kona and Veloster vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which could result in engine damage.

While stopped our 2019 Kona EV at a traffic light with my foot on the brake, the car spontaneously accelerated and crashed into the car also sitting at the light about eight feet in front of us. If there wasn't a car in front of us, we would have gone through a busy intersection at very high speed. The front end of the car was destroyed and both airbags deployed. The car was towed to a collision center and is considered: "Totaled" . We tried to get it inspected for the computer system to confirm what happened, but there was no interest by any party. There was no pre-warning or issues with the vehicle before this happened. The incident happened about ten miles from our house, and we had been driving it for about 15 minutes. The temperature outside was extremely cold at about 5 degrees Fahrenheit.

While stopped our 2019 Kona EV at a traffic light with my foot on the brake, the car spontaneously accelerated and crashed into the car also sitting at the light about eight feet in front of us. If there wasn't a car in front of us, we would have gone through a busy intersection at very high speed. The front end of the car was destroyed and both airbags deployed. The car was towed to a collision center and is considered: "Totaled" . We tried to get it inspected for the computer system to confirm what happened, but there was no interest by any party. There was no pre-warning or issues with the vehicle before this happened. The incident happened about ten miles from our house, and we had been driving it for about 15 minutes. The temperature outside was extremely cold at about 5 degrees Fahrenheit.

While stopped our 2019 Kona EV at a traffic light with my foot on the brake, the car spontaneously accelerated and crashed into the car also sitting at the light about eight feet in front of us. If there wasn't a car in front of us, we would have gone through a busy intersection at very high speed. The front end of the car was destroyed and both airbags deployed. The car was towed to a collision center and is considered: "Totaled" . We tried to get it inspected for the computer system to confirm what happened, but there was no interest by any party. There was no pre-warning or issues with the vehicle before this happened. The incident happened about ten miles from our house, and we had been driving it for about 15 minutes. The temperature outside was extremely cold at about 5 degrees Fahrenheit.

The contact owns a 2019 Hyundai Kona. The contact stated that while driving at an undisclosed speed, there was a burning odor coming from the vehicle, with the low engine oil warning light illuminated. The contact stated that while checking the dipstick, the contact became aware that the engine oil level was low. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 150,000.

Mileage: 150,000

Car idles down and dies while driving, unable to restart, no codes showing

Vehicle started to stall at low RPMs. While idling at red lights, engine would stall and go into limp mode. All safety features, such as forward collision would stop working. Car would need to be turned off and restarted for a temporary fix. No engine lights would come on. Car inspected by dealership and cannot figure out what the cause is. VIN comes up saying that my car is not part of the recall.

The contact owns a 2019 Hyundai Kona. The contact stated that while driving at an undisclosed speed, the engine was shutting down while on the way to work, with a knocking sound coming from the engine. The vehicle was towed to the dealer. The contact associated the failure with NHTSA Campaign Number: 21V301000 (ENGINE); however, the dealer refused to perform the recall repair, because there were other failures with the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 100,902.

Mileage: 100,902

Attempted to sound horn when driver ahead of me crossed lanes at roundabout. Horn did not work. No warning messages appear on dashboard indicating an issue. Inspected the horn fuse in engine compartment and found it to be functional. Vehicle has not yet been taken for repair.

The contact owns a 2019 Hyundai Kona. The contact stated that while operating the vehicle, the check engine warning light illuminated, with a knocking sound coming from the engine compartment. The contact stated that the vehicle shutoff while idling. The vehicle was taken to the local mechanic who was unable to determine the cause of the failure. Later, while idling at a stoplight, the vehicle stalled and failed to restart. The vehicle was eventually towed to the local dealer, who confirmed that the connecting rods had failed and punctured a hole in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was informed that the VIN was not included in NHTSA Campaign Number: 21V301000 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 94,000.

Mileage: 94,000

I was traveling on the interstate when my car began to slow down and the RPMs kept going up. I pulled over on the side of the highway and turned the motor off. I waited 10 minutes and started the car again thinking it was just a misfire. The motor began making weird noises and shaking. My engine like came on the dashboard display reported major malfunction get help. I was told by my mechanic that I was lucky the car did not catch on fire. He determined that pistons 1 and 3 were misfiring. He said it was being flooded with fuel. I have complained about the excessive burning of oil and that there must be an issue. Several have been recalled but not specific car.

The car's engine stuttered after pressing on gas pedal when engine is cold. When pressing on gas pedal from idle position at STOP sign, engine does not switch from 1st -> 2nd gear.

Vehicle Safety Complaint Narrative On Saturday, December 6, 2025, I brought my 2019 Hyundai Kona to Millennium Hyundai in Hempstead, New York, the dealership where the vehicle was purchased, for evaluation due to engine safety concerns. While driving the vehicle, we heard a knocking sound coming from the engine. One week earlier, on November 29, 2025, we brought the vehicle to our local mechanic after noticing the noise. The mechanic advised that the engine oil level was low and refilled the oil. Despite this, the knocking sound continued. Due to ongoing concerns about potential engine failure and because the vehicle is still under warranty, we scheduled an appointment with Millennium Hyundai for further diagnosis. The knocking noise raised serious safety concerns. On December 6th, we contacted the service manager, who advised us that the pistons were bad and they would need to replace the engine. On Monday, December 8th, we called the dealer and they then told us, that before any w

I believe that I’m leaking oil somewhere and that it’s due to the recall with the piston oil rings that’s on my car

I am reporting a recurring safety issue involving engine stalling in active traffic due to excessive oil loss and internal component failure. This has occurred three times within approximately 12,000 miles and has created dangerous conditions for my family, including my 2.5 year old child who rides in the vehicle. Summary of incidents: • May 15, 2025 – 61,736 miles: Vehicle stalled in traffic and lost acceleration. Dealership confirmed abnormal noise and low oil, but no oil consumption test was ordered. • Fall 2025 – 66,448 miles: Vehicle stalled and died on the highway. Diagnosis showed broken camshaft timing components. Service invoice states the engine oil system was too low and caused internal failures. Major timing components replaced. • October 30, 2025 – 69,175 miles: Vehicle stalled in traffic again. Oil was low after only 2,727 miles since previous repair. Dealer advised oil consumption test after another 1,000 miles, but I do not feel the vehicle is safe to driv

I am reporting a recurring safety issue involving engine stalling in active traffic due to excessive oil loss and internal component failure. This has occurred three times within approximately 12,000 miles and has created dangerous conditions for my family, including my 2.5 year old child who rides in the vehicle. Summary of incidents: • May 15, 2025 – 61,736 miles: Vehicle stalled in traffic and lost acceleration. Dealership confirmed abnormal noise and low oil, but no oil consumption test was ordered. • Fall 2025 – 66,448 miles: Vehicle stalled and died on the highway. Diagnosis showed broken camshaft timing components. Service invoice states the engine oil system was too low and caused internal failures. Major timing components replaced. • October 30, 2025 – 69,175 miles: Vehicle stalled in traffic again. Oil was low after only 2,727 miles since previous repair. Dealer advised oil consumption test after another 1,000 miles, but I do not feel the vehicle is safe to driv

I'm the owner of a 2019 Hyundai Kona (US spec) imported to Poland. The VIN is included in recall 21V-301 (fire risk). The engine showed symptoms consistent with this defect and failed at 44,000 miles. Photos confirm cylinder damage. Following Hyundai Motor America (HMA) instructions, I completed diagnostics at an authorized Hyundai service center in Poland. Results: error P0366, compression 2–3 bar. HMA refused to accept these documents, demanding a specific “Repair Order” format, which European dealers cannot issue. No real coordination with regional offices occurred, making compliance impossible. HMA then issued a warranty-related denial (not requested), citing salvage status, although it is irrelevant to the mandatory recall remedy. HMA also stated diagnostics must be done in the USA, which is impossible for a non-operational vehicle located in Poland. At the same time, Hyundai Motor Poland provided incorrect information (claiming two total-loss incidents instead of one) an

My Kona has been stalling/hesitating when accelerating. It has been happening for a little over a year. It got very bad and the check engine light came on. I had it towed to Hyundai dealership and they said it was the fuel injectors so I paid to have those replaced, they said my warranty didn’t cover it. Replacing the fuel injectors made the car drivable but it was still stalling/hesitating but Hyundai said it was working properly. So I took it home. I have been driving it and it just keeps stalling and hesitating more and more. It is stalling and hesitating and has lack of power when I try to accelerate. I am afraid one day I’ll stall in traffic and get hit or cause an accident. I have also just realized my Kona has been using excessive oil. I just had an oil change mid August and today had to add at least 3 quarts. Even when I had my oil changed, the shop said I barely had maybe a quart in there, when it was just changed in May. We do not see any oil leaking out from anywhere. I

My Kona has been stalling/hesitating when accelerating. It has been happening for a little over a year. It got very bad and the check engine light came on. I had it towed to Hyundai dealership and they said it was the fuel injectors so I paid to have those replaced, they said my warranty didn’t cover it. Replacing the fuel injectors made the car drivable but it was still stalling/hesitating but Hyundai said it was working properly. So I took it home. I have been driving it and it just keeps stalling and hesitating more and more. It is stalling and hesitating and has lack of power when I try to accelerate. I am afraid one day I’ll stall in traffic and get hit or cause an accident. I have also just realized my Kona has been using excessive oil. I just had an oil change mid August and today had to add at least 3 quarts. Even when I had my oil changed, the shop said I barely had maybe a quart in there, when it was just changed in May. We do not see any oil leaking out from anywhere. I

The fuel system appears to have a small leak from either a bad seal or a problem fuel line.

Burning oil faster than normal