2023 HYUNDAI IONIQ 6

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a lo

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2024 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a lo

ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:PORT

Hyundai Motor America (Hyundai) is recalling certain 2023-2025 IONIQ 6 electric vehicles. The charging port door panel may detach.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Hyundai Motor America (Hyundai) is recalling certain 2023 IONIQ 5, IONIQ 6, and Genesis GV60 vehicles. The rear inner driveshaft may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.

A failure of the ICCU resulted in a maximum speed of about 25 mph and eventually a total loss of power.

A failure of the ICCU resulted in a maximum speed of about 25 mph and eventually a total loss of power.

January 28, 2026 The vehicle has stopped in the middle Of the street with sign «loss of power, check your battery» or something like that and after few attempts to turn it off and on it went to Accessory mode. After 15-20 minutes it completely died. So unsafe with kids in the car during extreme cold temperatures. Free Hyundai road assistance- quoted me 3 hours or so, i had to pay for towing elsewhere. No doubts its iccu, since tow truck driver attempted to jump start and from dead it went to accessory mode and died again almost instantly. I read on the Facebook about iccu problem of Hyundai, if this is engineering defect it should be remedied.

Horn fuse has blown 4 times in 5000 miles leaving the vehicle unsafe to operate. Problem is reproduced and confirmed. First started in November 2025 and 4th fuse was placed January 2026.

ICCU failure, vehicle disabled while driving leaving me stranded.

ICCU failure, vehicle disabled while driving leaving me stranded.

Iccu 12 v battery failed

The vehicle popped up a screen that said check power source. Then within 30 seconds went into limp mode said power was limited and couldn't drive faster the. 25mph in the middle of a highway. By the time I pulled over to the side of the road my car was dead. Ive been trying to get Hyundai and the dealership to dignose the issue. Based on the error codes I was given it appears to be a dead iccu and 12v battery. I am in a ioniq group on Facebook and over the last week of being in it I've counted over 50 dead iccu on this group alone. All in one week.

The vehicle popped up a screen that said check power source. Then within 30 seconds went into limp mode said power was limited and couldn't drive faster the. 25mph in the middle of a highway. By the time I pulled over to the side of the road my car was dead. Ive been trying to get Hyundai and the dealership to dignose the issue. Based on the error codes I was given it appears to be a dead iccu and 12v battery. I am in a ioniq group on Facebook and over the last week of being in it I've counted over 50 dead iccu on this group alone. All in one week.

I was driving, there was a loud pop, then warnings popped up on the dash and I lost power. I was able to limp the car back to my house, because I had just left. I assume it is the ICCU. I’m reporting this because it is a known issue that Hyundai has not seemingly been able to repair. With the pedal to the floor, I got up to 25 mph. Luckily, I was near home and not on a highway.

The iccu failed. The car went into check power mode the. Into slow mode then died on the highway. Hard to ah e it jumped to take it to the dealership only to find out the 12v and iccu died

The iccu failed. The car went into check power mode the. Into slow mode then died on the highway. Hard to ah e it jumped to take it to the dealership only to find out the 12v and iccu died

The contact owns a 2023 Hyundai Ioniq 6. The contact had received a notice of NHTSA Campaign Number: 24V868000 (Electrical System), and the vehicle was taken to the dealer, where the Integrated Charging Control Unit (ICCU) software update was completed. The contact stated that while driving 50 MPH on the highway, the vehicle stalled. The contact was able to pull over to the shoulder of the road. It was unknown whether a warning light had illuminated. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the Integrated Charging Control Unit (ICCU), and the 12-Volt battery had failed and needed to be replaced. The dealer ordered the parts. The contact stated that the recall remedy had failed to correct the safety issue. The vehicle was not yet repaired. The manufacturer was notified of the failure and informed the contact that parts would be shipped to the dealer for repair. The failure mileage was approximately 14,000.

Mileage: 14,000

The horn from my car has stopped working entirely. By having this system fail it endangers me from other clueless drivers on the road.

The contact owns a 2023 Hyundai Ioniq 6. The contact received notification of NHTSA Campaign Number: 24V868000 (Electrical System), and the vehicle was taken to the dealer, where a software update was performed. The contact stated that the vehicle was charged at the residence, and the contact received notification through the Mobile App that the big battery charge was 80 percent. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, where it was determined that the 12-Volt battery was completely drained and needed to be replaced. The contact stated that the recall remedy was intended to ensure that the big battery charged the 12-Volt battery during a charging session, but the recall remedy had failed to correct the issue as intended. The dealer informed the contact that the battery needed to be replaced prior to another attempt to perform the recall repair. The vehicle was not repaired. The contact stated that t

Mileage: 55,000

The ICCU on my 2023 Hyundai Ioniq 6 failed on December 5, 2025 after 19,616 miles. Luckily, the car was parked in my driveway when this occurred. If the car was in motion when the ICCU failure occurred it would have been very dangerous. The car cannot be driven. The car's system shows Hyundai Diagnostic Trouble Code (DTC) P1A906. The problem has been confirmed by a dealer. A new ICCU has been ordered. The car is under warranty and the dealer provided a loaner car while my car is being repaired.

The ICCU on my 2023 Hyundai Ioniq 6 failed on December 5, 2025 after 19,616 miles. Luckily, the car was parked in my driveway when this occurred. If the car was in motion when the ICCU failure occurred it would have been very dangerous. The car cannot be driven. The car's system shows Hyundai Diagnostic Trouble Code (DTC) P1A906. The problem has been confirmed by a dealer. A new ICCU has been ordered. The car is under warranty and the dealer provided a loaner car while my car is being repaired.

Subject: Safety Complaint – Sharp Upper Door Edge Causing Facial Injury (Hyundai IONIQ 6, 2023) Message: To whom it may concern, I would like to submit a safety complaint regarding my 2023 Hyundai IONIQ 6 (VIN: [XXX] ). On October 14, 2024, my wife suffered a facial injury caused by an extremely sharp upper edge of the front door. This occurred in our driveway at [XXX] . The injury happened when the front door stopped at its mid-detent position and the sharp, exposed upper edge made forceful contact with her forehead and the area next to her eye. She avoided a direct eye injury only due to quick reflex. This design presents a serious risk to passengers, especially those of shorter stature. I have photographic documentation showing the sharp door edge and the injury mechanism. Hyundai Motor America was informed, but they dismissed the case and advised us simply to “be more careful.” They offered a $150 virtual compensation card, which I did not use, because accepting it could be i

Honk not working fuses are fine second time taking it to dealer to repairs honk at 33k miles

The contact owns a 2023 Hyundai Ioniq6. The contact stated that while driving approximately 20-30 MPH and attempting to use the horn, the contact discovered that the horn was inoperable. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was determined that the horn needed to be replaced. The vehicle was repaired, but the failure recurred. The dealer failed to pre-order the part for the repair. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 12,500.

Mileage: 12,500