Total Complaints
70 filings
GMC YUKON DENALI XL · model year
2004 GMC YUKON DENALI XL
70 NHTSA complaints, 3 crash reports for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2004GMCYUKON DENALI XL carries 70 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 3 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2004 YUKON DENALI XL is electrical system with 15 filings, followed by service brakes (15) and electronic stability control (esc) (9). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability.
NHTSA currently has 2 investigation files overlapping the 2004 YUKON DENALI XL. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
70
Complaints
3
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
3 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ELECTRICAL SYSTEM | 15 |
| SERVICE BRAKES | 15 |
| ELECTRONIC STABILITY CONTROL (ESC) | 9 |
| SERVICE BRAKES, HYDRAULIC | 4 |
| ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | 4 |
| STEERING | 4 |
| ENGINE | 4 |
| VEHICLE SPEED CONTROL | 2 |
| POWER TRAIN | 2 |
| SUSPENSION | 2 |
| PARKING BRAKE | 1 |
| ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| ENGINE AND ENGINE COOLING | 1 |
| FUEL SYSTEM, GASOLINE | 1 |
| SEATS | 1 |
Recent Complaints
20190120ELECTRICAL SYSTEM
STABILITY CONTROL DISABLED COMES ON WITH ENGINE POWER REDUCED. THIS HAPPENED AS I AS DRIVING IN THE HIGHWAY. SPEED DRASTICALLY REDUCED FORM 65 TO 10 MPH. I COULD HAVE BEEN KILLED. GM IS AWARE OF THIS PROBLEM AND WILL NOT ACT UNTIL THERE'S A FATALITY BECAUSE OF THIS ISSUE. I AM AFRAID TO DRIVE THIS VEHICLE. NHTSA HAS RECEIVED NUMEROUS COMPLAINTS REGARDING THIS ISSUE AND HAS NOT ACTED. THE ELECTRICAL SYSTEM IS NOT CORRECT -THIS IS VERY DANGEROUS
Mileage: 190,000
20190120UNKNOWN OR OTHER
STABILITY CONTROL DISABLED COMES ON WITH ENGINE POWER REDUCED. THIS HAPPENED AS I AS DRIVING IN THE HIGHWAY. SPEED DRASTICALLY REDUCED FORM 65 TO 10 MPH. I COULD HAVE BEEN KILLED. GM IS AWARE OF THIS PROBLEM AND WILL NOT ACT UNTIL THERE'S A FATALITY BECAUSE OF THIS ISSUE. I AM AFRAID TO DRIVE THIS VEHICLE. NHTSA HAS RECEIVED NUMEROUS COMPLAINTS REGARDING THIS ISSUE AND HAS NOT ACTED. THE ELECTRICAL SYSTEM IS NOT CORRECT -THIS IS VERY DANGEROUS
Mileage: 190,000
20180924ELECTRICAL SYSTEM
THE INSTRUMENT CLUSTER IS FAULTY DO TO BATTERY DRAIN. THIS PROBLEM PERSISTS WITH A MAJORITY OF TRUCKS AND SUV'S OF THE SAME GENERATION AS MY 2004 GMC YUKON DENALI XL. THE COST FROM THE DEALER TO REPLACE THIS PART IS APPROXIMATELY $2000. THERE ARE AFTERMARKET INSTRUMENT CLUSTER TO REPLACE THIS PART AT A COST OF ALL MOST $600. THIS REQUIRES PROGRAMMING BY THE DEALER FOR A COST OF ANOTHER $500+ ONLY TO HAVE THE SAME ISSUE REPEAT IT SELF AT LATER DATE.
Mileage: 240,000
20180204SERVICE BRAKES
WITHOUT WARNING THE BRAKES FAILED. VEHICLE WAS IN MOTION AT TIME OF FAILURE, VEHICLE COULD NOT BE STOPPED AND AT 30 MPH RAN THROUGH THE RED TRAFFIC LIGHT AT A BUSY CITY INTERSECTION. FORTUNATELY, NO ACCIDENT OCCURRED. VEHICLE HAD TO BE TOWED TO DEALERSHIP. DEALER REPAIRED VEHICLE. INVOICE STATED: "BRAKE LINE WORE THROUGH FROM STEERING COLUMN RUBBING ON FLEXIBLE SECTION."
Mileage: 240,000
20160619ELECTRONIC STABILITY CONTROL (ESC)
STABILITY CONTROL DISABLED COMES ON WITH ENGINE POWER REDUCED. THIS HAPPENED AS I AS DRIVING IN THE HIGHWAY. SPEED DRASTICALLY REDUCED FORM 65 TO 10 MPH. I COULD HAVE BEEN KILLED. GM IS AWARE OF THIS PROBLEM AND WILL NOT ACT UNTIL THERE'S A FATALITY BECAUSE OF THIS ISSUE. THIS IS CRIMINAL. NHTSA HAS RECEIVED NUMEROUS COMPLAINTS REGARDING THIS ISSUE AND HAS NOT ACTED.
Mileage: 177,000
20160619ENGINE
STABILITY CONTROL DISABLED COMES ON WITH ENGINE POWER REDUCED. THIS HAPPENED AS I AS DRIVING IN THE HIGHWAY. SPEED DRASTICALLY REDUCED FORM 65 TO 10 MPH. I COULD HAVE BEEN KILLED. GM IS AWARE OF THIS PROBLEM AND WILL NOT ACT UNTIL THERE'S A FATALITY BECAUSE OF THIS ISSUE. THIS IS CRIMINAL. NHTSA HAS RECEIVED NUMEROUS COMPLAINTS REGARDING THIS ISSUE AND HAS NOT ACTED.
Mileage: 177,000
20160619VEHICLE SPEED CONTROL
STABILITY CONTROL DISABLED COMES ON WITH ENGINE POWER REDUCED. THIS HAPPENED AS I AS DRIVING IN THE HIGHWAY. SPEED DRASTICALLY REDUCED FORM 65 TO 10 MPH. I COULD HAVE BEEN KILLED. GM IS AWARE OF THIS PROBLEM AND WILL NOT ACT UNTIL THERE'S A FATALITY BECAUSE OF THIS ISSUE. THIS IS CRIMINAL. NHTSA HAS RECEIVED NUMEROUS COMPLAINTS REGARDING THIS ISSUE AND HAS NOT ACTED.
Mileage: 177,000
20151103ELECTRONIC STABILITY CONTROL (ESC)
I GET THIS (COMFORT RIDE CONTROL) WHEN I TURN THE KEY OFF AND BACK ON IT THERE AGAIN. WHEN I START IT UP.
Mileage: 162,500
20151103SUSPENSION
I GET THIS (COMFORT RIDE CONTROL) WHEN I TURN THE KEY OFF AND BACK ON IT THERE AGAIN. WHEN I START IT UP.
Mileage: 162,500
20150930SERVICE BRAKES
STEEL BRAKE LINES HAVE RUSTED THROUGH, CAUSING LEAKAGE AND TOTAL BRAKE FAILURE DURING APPLICATION. CALIPERS AND BLEEDER VALVES ALSO RUSTED, PREVENTING NEW BRAKE LINES FROM BEING RE-ATTACHED.
Mileage: 82,700
20150930ELECTRONIC STABILITY CONTROL (ESC)
02/09/2012-RECEIVED WARNING IN MESSAGE CENTER ADVISING TO CHECK RIDE CONTROL. LOCATED BROKEN RIGHT FRONT HEIGHT SENSOR ACTUATOR FOR BROKEN CONTROL ARM LINKAGE. SENSOR REPLACED (MILEAGE 63,031). ON 09/27/2015, THE LEFT SENSOR BROKE, ALSO REQUIRING REPLACEMENT (MILEAGE 82,700).
Mileage: 63,031
20150923ENGINE
TL* THE CONTACT OWNS A 2004 GMC YUKON DENALI XL. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED. AFTER SEVERAL ATTEMPTS, THE VEHICLE RESTARTED. THE FAILURE RECURRED NUMEROUS TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC REPLACED THE TAC MODULE AND ELECTRONIC THROTTLE BODY, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Mileage: 120,000
20150923POWER TRAIN
TL* THE CONTACT OWNS A 2004 GMC YUKON DENALI XL. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED. AFTER SEVERAL ATTEMPTS, THE VEHICLE RESTARTED. THE FAILURE RECURRED NUMEROUS TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC REPLACED THE TAC MODULE AND ELECTRONIC THROTTLE BODY, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Mileage: 120,000
20150708ELECTRICAL SYSTEM
VEHICLE STARTED FINE, THEN AS I WAS DRIVING IN NEIGHBORHOOD ENGINE SHUT OFF AND I LOST ALL POWER, COULD NOT TURN CAR WITHOUT STEERING AND CRASHED INTO CURB UP THE STREET, CAR WOULD NOT START, HAD AAA COME TOW TO OUR HOME. HAD A NEW BATTERY, AND WOULD ONLY TAKE A CHARGE WHEN BYPASSING BATTERY DIRECTLY INTO ENGINE. NOW SOMETHING IS DRAINING BATTERY AND IF I DON'T START AND RUN EVERY TWO DAYS , BATTERY DEAD. ELECTRICAL CLUSTER ALSO GOING BAD AND INSTRUMENTS NOT WORKING, AIR CONDITIONING ELECTRICAL PROBLEM , WILL BLOW COLD OUT OF ALL BUT TWO VENTS, WHERE IT BLOWS 90 DEGREES. BACK WINDOW WIPER STOPPED WORKING, ALL ELECTRICAL RELATED. DEALER SAID NO ERROR CODES TEST DROVE FOR A WEEK TO GET TO REPRODUCE STALL DRIVING, RETURNED TO ME SAYING CAN'T DIAGNOSE. SO FRUSTRATING AND DANGEROUS.
Mileage: 123,000
20150708ENGINE
VEHICLE STARTED FINE, THEN AS I WAS DRIVING IN NEIGHBORHOOD ENGINE SHUT OFF AND I LOST ALL POWER, COULD NOT TURN CAR WITHOUT STEERING AND CRASHED INTO CURB UP THE STREET, CAR WOULD NOT START, HAD AAA COME TOW TO OUR HOME. HAD A NEW BATTERY, AND WOULD ONLY TAKE A CHARGE WHEN BYPASSING BATTERY DIRECTLY INTO ENGINE. NOW SOMETHING IS DRAINING BATTERY AND IF I DON'T START AND RUN EVERY TWO DAYS , BATTERY DEAD. ELECTRICAL CLUSTER ALSO GOING BAD AND INSTRUMENTS NOT WORKING, AIR CONDITIONING ELECTRICAL PROBLEM , WILL BLOW COLD OUT OF ALL BUT TWO VENTS, WHERE IT BLOWS 90 DEGREES. BACK WINDOW WIPER STOPPED WORKING, ALL ELECTRICAL RELATED. DEALER SAID NO ERROR CODES TEST DROVE FOR A WEEK TO GET TO REPRODUCE STALL DRIVING, RETURNED TO ME SAYING CAN'T DIAGNOSE. SO FRUSTRATING AND DANGEROUS.
Mileage: 123,000
20150708STEERING
VEHICLE STARTED FINE, THEN AS I WAS DRIVING IN NEIGHBORHOOD ENGINE SHUT OFF AND I LOST ALL POWER, COULD NOT TURN CAR WITHOUT STEERING AND CRASHED INTO CURB UP THE STREET, CAR WOULD NOT START, HAD AAA COME TOW TO OUR HOME. HAD A NEW BATTERY, AND WOULD ONLY TAKE A CHARGE WHEN BYPASSING BATTERY DIRECTLY INTO ENGINE. NOW SOMETHING IS DRAINING BATTERY AND IF I DON'T START AND RUN EVERY TWO DAYS , BATTERY DEAD. ELECTRICAL CLUSTER ALSO GOING BAD AND INSTRUMENTS NOT WORKING, AIR CONDITIONING ELECTRICAL PROBLEM , WILL BLOW COLD OUT OF ALL BUT TWO VENTS, WHERE IT BLOWS 90 DEGREES. BACK WINDOW WIPER STOPPED WORKING, ALL ELECTRICAL RELATED. DEALER SAID NO ERROR CODES TEST DROVE FOR A WEEK TO GET TO REPRODUCE STALL DRIVING, RETURNED TO ME SAYING CAN'T DIAGNOSE. SO FRUSTRATING AND DANGEROUS.
Mileage: 123,000
20150521SERVICE BRAKES
WHILE OPERATING THE VEHICLE ON A HIGHWAY I PRESSED THE BRAKE PEDAL AND SUDDENLY THE BRAKE PEDAL SUNK AND I LOST BRAKES. I NEARLY LOST CONTROL OF THE VEHICLE AND ALMOST DROVE INTO A GUARD RAIL. AFTER FURTHER INSPECTION I OBSERVE THE FRONT DRIVERS SIDE BRAKE WAS CORRODED CAUSING IT TO BREAK. THIS APPEARS TO BE AN ISSUE WITH GMC AND THE COMPANY SHOULD BE REQUIRED TO RECTIFY THE SITUATION. USING STAINLESS WOULD PREVENT INCIDENTS LIKE THESE AND POSSIBLE INJURIES OR DEATHS.
Mileage: 178,700
20150420SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 GMC YUKON DENALI XL. THE CONTACT STATED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED DURING ACCELERATION, THE VEHICLE HESITATED AND THE TRACTION ACTIVE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR FILTER FAILED AND NEEDED TO BE REPLACED, THE BG FUEL INDUCTION SERVICED NEEDED TO BE DONE, THE FRONT BRAKE PADS AND ROTORS FAILED AND NEEDED TO BE REPLACED, AND THE REAR DIFFERENTIAL SERVICE NEEDED TO BE DONE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Mileage: 40,000
20150420ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 GMC YUKON DENALI XL. THE CONTACT STATED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED DURING ACCELERATION, THE VEHICLE HESITATED AND THE TRACTION ACTIVE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR FILTER FAILED AND NEEDED TO BE REPLACED, THE BG FUEL INDUCTION SERVICED NEEDED TO BE DONE, THE FRONT BRAKE PADS AND ROTORS FAILED AND NEEDED TO BE REPLACED, AND THE REAR DIFFERENTIAL SERVICE NEEDED TO BE DONE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Mileage: 40,000
20150420ELECTRONIC STABILITY CONTROL (ESC)
TL* THE CONTACT OWNS A 2004 GMC YUKON DENALI XL. THE CONTACT STATED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED DURING ACCELERATION, THE VEHICLE HESITATED AND THE TRACTION ACTIVE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR FILTER FAILED AND NEEDED TO BE REPLACED, THE BG FUEL INDUCTION SERVICED NEEDED TO BE DONE, THE FRONT BRAKE PADS AND ROTORS FAILED AND NEEDED TO BE REPLACED, AND THE REAR DIFFERENTIAL SERVICE NEEDED TO BE DONE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Mileage: 40,000
Compare 2004GMCYUKON DENALI XL to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2004 GMC YUKON DENALI XL have?▼
The 2004 GMC YUKON DENALI XL has 70 NHTSA complaints, 3 crashes, 0 fires, 0 injuries, and 0 deaths reported.
What are the most common problems with the 2004 GMC YUKON DENALI XL?▼
The most-complained component for the 2004 GMC YUKON DENALI XL is ELECTRICAL SYSTEM with 15 complaints. Other frequently reported areas include SERVICE BRAKES and ELECTRONIC STABILITY CONTROL (ESC).
Is the 2004 GMC YUKON DENALI XL safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.