2002 GMC SIERRA 3500

EQUIPMENT ADAPTIVE/MOBILITY

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

INTERIOR LIGHTING

VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT ILLUMINATE WHEN THE BRAKE FLUID IS LOW. I

FUEL SYSTEM, GASOLINE

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE

TL* THE CONTACT OWNS A 2002 GMC SIERRA 3500. WHILE OPERATING THE VEHICLE, THE ODOR OF FUEL WAS NOTICEABLE INSIDE THE CABIN. UPON INSPECTION, THE CONTACT DISCOVERED FUEL HAD LEAKED FROM THE VEHICLE ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

THIS TRUCK HAS THE SAME PROBLEMS AS THE 2007 MODEL. THE IGNITION SWITCH, PARKING BRAKE, AND FUEL LINES ALL HAVE ISSUES AS SIMILARLY DESCRIBED FOR THE 2007 MODEL. THE FUEL LINES ACTUALLY BROKE THROUGH CAUSING A LEAK OF THE DIESEL FUEL. THIS HAPPENED AFTER THE VEHICLE WAS DRIVEN A SHORT DISTANCE OF 15 MILES.

Mileage: 101,000

THIS TRUCK HAS THE SAME PROBLEMS AS THE 2007 MODEL. THE IGNITION SWITCH, PARKING BRAKE, AND FUEL LINES ALL HAVE ISSUES AS SIMILARLY DESCRIBED FOR THE 2007 MODEL. THE FUEL LINES ACTUALLY BROKE THROUGH CAUSING A LEAK OF THE DIESEL FUEL. THIS HAPPENED AFTER THE VEHICLE WAS DRIVEN A SHORT DISTANCE OF 15 MILES.

Mileage: 101,000

THIS TRUCK HAS THE SAME PROBLEMS AS THE 2007 MODEL. THE IGNITION SWITCH, PARKING BRAKE, AND FUEL LINES ALL HAVE ISSUES AS SIMILARLY DESCRIBED FOR THE 2007 MODEL. THE FUEL LINES ACTUALLY BROKE THROUGH CAUSING A LEAK OF THE DIESEL FUEL. THIS HAPPENED AFTER THE VEHICLE WAS DRIVEN A SHORT DISTANCE OF 15 MILES.

Mileage: 101,000

WHILE DRIVING DOWN A VERY BUSY STREET, THE ENGINE DIED. I LOST ALL MY POWER STEERING AND BRAKE. I WAS VERY LUCKY THAT I WAS NOT ON A VERY BUSY HIGHWAY. I HAD IT TOWED TO HEDRICK'S CHEVROLET IN CLOVIS CA. IT TOOK 2 DAYS FOR THEM TO CHECK IT OUT. THEY SAID WHEN THEY WENT TO BRING IT IN TO THE SHOP IT STARTED UP AND THEY COULD NOT FIND ANYTHING WRONG WITH IT. I PICKED THE TRUCK UP AND THE NEXT DAY IT DID THE SAME THING AGAIN. I CALLED THE DEALER AND THEY TOLD ME TO PRESS THE PUMP ON THE TOP OF THE FILTER HOUSING UNTIL I COULD NO LONGER PRESS IT. I DID THAT AND IT STARTED UP. BE CAME VERY OBVIOUS THAT THEY WERE AWARE THAT THE FUEL FILTER HOUSING WAS CAUSING THE INJECTION SYSTEM TO LOSE SUCTION I TOOK IT BACK TO THE DEALER AND THEY REPLACED THE FUEL FILTER HOUSING. I HAVE SINCE FOUND OUT THAT THIS FAILURE IS A COMMON FAILURE. EVIDENTLY THERE IS AN O RING IN THE HOUSING AND IT FAILS AND BASED ON FACT THAT THEIR SERVICE PERSON WAS ABLE TO TELL ME HOW TO START THE TRUCK, THEY NEW O

Mileage: 85,118

SLOWING DOWN TO A RED TRAFFIC LIGHT AND BRAKE PEDAL WENT TO THE FLOOR. TRIED TO PUMP BRAKE PEDAL TO GET MORE PRESSURE BUT DID NOT WORK. DROVE OFF ONTO SHOULDER AND GOT IT SLOWED DOWN . DRIVE VERY SLOW WITH HAZARD LIGHTS ON TO GET IT BACK TO MY HOUSE. I WAS ONLY ABOUT A MILE AWAY. GOT HOME AND LOOKED UNDERNEATH TO FIND BRAKE FLUID ALL OVER LEFT REAR WHEELS, FUEL TANK, LEFT REAR SHOCK AND DRIVE AXLE. CONTINUED TO LOOK AT ALL BRAKE LINES AND ALL OF THEM WERE CORRODED BAD. GETTING PRICES ON HAVING ALL BRAKE LINES REPLACED. *TR

Mileage: 137,000

SLOWING DOWN TO A RED TRAFFIC LIGHT AND BRAKE PEDAL WENT TO THE FLOOR. TRIED TO PUMP BRAKE PEDAL TO GET MORE PRESSURE BUT DID NOT WORK. DROVE OFF ONTO SHOULDER AND GOT IT SLOWED DOWN . DRIVE VERY SLOW WITH HAZARD LIGHTS ON TO GET IT BACK TO MY HOUSE. I WAS ONLY ABOUT A MILE AWAY. GOT HOME AND LOOKED UNDERNEATH TO FIND BRAKE FLUID ALL OVER LEFT REAR WHEELS, FUEL TANK, LEFT REAR SHOCK AND DRIVE AXLE. CONTINUED TO LOOK AT ALL BRAKE LINES AND ALL OF THEM WERE CORRODED BAD. GETTING PRICES ON HAVING ALL BRAKE LINES REPLACED. *TR

Mileage: 137,000

SLOWING DOWN TO A RED TRAFFIC LIGHT AND BRAKE PEDAL WENT TO THE FLOOR. TRIED TO PUMP BRAKE PEDAL TO GET MORE PRESSURE BUT DID NOT WORK. DROVE OFF ONTO SHOULDER AND GOT IT SLOWED DOWN . DRIVE VERY SLOW WITH HAZARD LIGHTS ON TO GET IT BACK TO MY HOUSE. I WAS ONLY ABOUT A MILE AWAY. GOT HOME AND LOOKED UNDERNEATH TO FIND BRAKE FLUID ALL OVER LEFT REAR WHEELS, FUEL TANK, LEFT REAR SHOCK AND DRIVE AXLE. CONTINUED TO LOOK AT ALL BRAKE LINES AND ALL OF THEM WERE CORRODED BAD. GETTING PRICES ON HAVING ALL BRAKE LINES REPLACED. *TR

Mileage: 137,000

I FIRST NOTICED THAT THE ANTI-LOCK BRAKES WERE ACTIVATING AT SLOW SPEEDS ( 5-10 MPH ) UNDER DRY ROAD CONDITIONS. THIS WAS PRIOR TO BRAKE LINE INCIDENT ON 4-14-2012 BUT I AM NOT SURE OF EXACT DATE. I RESEARCHED THE ANTI-LOCK BRAKES AND FOUND NHTSA ID CAMPAIGN #05V379000 ACTION # PE05020 BUT THIS DID NOT INCLUDE MY HOME STATE OF KENTUCKY. HOWEVER, I HAVE BEEN WORKING IN OHIO SINCE THE PURCHASE OF SAID VEHICLE 10-17-2001 TO CURRENT DATE 2-11-2013. ON 4-14-2012 I WAS PREPARING TO TAKE MY BOAT TO FUEL IT . WHILE CHECKING THE TRAILER LIGHTS I STEPPED ON THE BRAKE PEDAL AND IT WENT STRAIGHT TO THE FLOOR. I FOUND THAT THE BRAKE LINE TO THE REAR WHEELS HAD BURST IN HALF AND WAS SEVERELY CORRODED. UPON CLOSER INSPECTION I FOUND THAT ALL THE BRAKE LINES SHOWED SIGNS OF SEVERE CORROISION. ON 2-8-2013 I DISCOVERED THAT DIESEL FUEL WAS LEAKING NEAR THE FUEL TANK AND FUEL COOLER. IT WAS FOUND TO BE A CORRODED RETURN FUEL LINE BETWEEN THE COOLER AND THE FUEL TANK .AGAIN UPON CLOSER INSPECTION ALL FUE

Mileage: 154,163

I FIRST NOTICED THAT THE ANTI-LOCK BRAKES WERE ACTIVATING AT SLOW SPEEDS ( 5-10 MPH ) UNDER DRY ROAD CONDITIONS. THIS WAS PRIOR TO BRAKE LINE INCIDENT ON 4-14-2012 BUT I AM NOT SURE OF EXACT DATE. I RESEARCHED THE ANTI-LOCK BRAKES AND FOUND NHTSA ID CAMPAIGN #05V379000 ACTION # PE05020 BUT THIS DID NOT INCLUDE MY HOME STATE OF KENTUCKY. HOWEVER, I HAVE BEEN WORKING IN OHIO SINCE THE PURCHASE OF SAID VEHICLE 10-17-2001 TO CURRENT DATE 2-11-2013. ON 4-14-2012 I WAS PREPARING TO TAKE MY BOAT TO FUEL IT . WHILE CHECKING THE TRAILER LIGHTS I STEPPED ON THE BRAKE PEDAL AND IT WENT STRAIGHT TO THE FLOOR. I FOUND THAT THE BRAKE LINE TO THE REAR WHEELS HAD BURST IN HALF AND WAS SEVERELY CORRODED. UPON CLOSER INSPECTION I FOUND THAT ALL THE BRAKE LINES SHOWED SIGNS OF SEVERE CORROISION. ON 2-8-2013 I DISCOVERED THAT DIESEL FUEL WAS LEAKING NEAR THE FUEL TANK AND FUEL COOLER. IT WAS FOUND TO BE A CORRODED RETURN FUEL LINE BETWEEN THE COOLER AND THE FUEL TANK .AGAIN UPON CLOSER INSPECTION ALL FUE

Mileage: 154,163

I FIRST NOTICED THAT THE ANTI-LOCK BRAKES WERE ACTIVATING AT SLOW SPEEDS ( 5-10 MPH ) UNDER DRY ROAD CONDITIONS. THIS WAS PRIOR TO BRAKE LINE INCIDENT ON 4-14-2012 BUT I AM NOT SURE OF EXACT DATE. I RESEARCHED THE ANTI-LOCK BRAKES AND FOUND NHTSA ID CAMPAIGN #05V379000 ACTION # PE05020 BUT THIS DID NOT INCLUDE MY HOME STATE OF KENTUCKY. HOWEVER, I HAVE BEEN WORKING IN OHIO SINCE THE PURCHASE OF SAID VEHICLE 10-17-2001 TO CURRENT DATE 2-11-2013. ON 4-14-2012 I WAS PREPARING TO TAKE MY BOAT TO FUEL IT . WHILE CHECKING THE TRAILER LIGHTS I STEPPED ON THE BRAKE PEDAL AND IT WENT STRAIGHT TO THE FLOOR. I FOUND THAT THE BRAKE LINE TO THE REAR WHEELS HAD BURST IN HALF AND WAS SEVERELY CORRODED. UPON CLOSER INSPECTION I FOUND THAT ALL THE BRAKE LINES SHOWED SIGNS OF SEVERE CORROISION. ON 2-8-2013 I DISCOVERED THAT DIESEL FUEL WAS LEAKING NEAR THE FUEL TANK AND FUEL COOLER. IT WAS FOUND TO BE A CORRODED RETURN FUEL LINE BETWEEN THE COOLER AND THE FUEL TANK .AGAIN UPON CLOSER INSPECTION ALL FUE

Mileage: 154,163

I FIRST NOTICED THAT THE ANTI-LOCK BRAKES WERE ACTIVATING AT SLOW SPEEDS ( 5-10 MPH ) UNDER DRY ROAD CONDITIONS. THIS WAS PRIOR TO BRAKE LINE INCIDENT ON 4-14-2012 BUT I AM NOT SURE OF EXACT DATE. I RESEARCHED THE ANTI-LOCK BRAKES AND FOUND NHTSA ID CAMPAIGN #05V379000 ACTION # PE05020 BUT THIS DID NOT INCLUDE MY HOME STATE OF KENTUCKY. HOWEVER, I HAVE BEEN WORKING IN OHIO SINCE THE PURCHASE OF SAID VEHICLE 10-17-2001 TO CURRENT DATE 2-11-2013. ON 4-14-2012 I WAS PREPARING TO TAKE MY BOAT TO FUEL IT . WHILE CHECKING THE TRAILER LIGHTS I STEPPED ON THE BRAKE PEDAL AND IT WENT STRAIGHT TO THE FLOOR. I FOUND THAT THE BRAKE LINE TO THE REAR WHEELS HAD BURST IN HALF AND WAS SEVERELY CORRODED. UPON CLOSER INSPECTION I FOUND THAT ALL THE BRAKE LINES SHOWED SIGNS OF SEVERE CORROISION. ON 2-8-2013 I DISCOVERED THAT DIESEL FUEL WAS LEAKING NEAR THE FUEL TANK AND FUEL COOLER. IT WAS FOUND TO BE A CORRODED RETURN FUEL LINE BETWEEN THE COOLER AND THE FUEL TANK .AGAIN UPON CLOSER INSPECTION ALL FUE

Mileage: 154,163

I FIRST NOTICED THAT THE ANTI-LOCK BRAKES WERE ACTIVATING AT SLOW SPEEDS ( 5-10 MPH ) UNDER DRY ROAD CONDITIONS. THIS WAS PRIOR TO BRAKE LINE INCIDENT ON 4-14-2012 BUT I AM NOT SURE OF EXACT DATE. I RESEARCHED THE ANTI-LOCK BRAKES AND FOUND NHTSA ID CAMPAIGN #05V379000 ACTION # PE05020 BUT THIS DID NOT INCLUDE MY HOME STATE OF KENTUCKY. HOWEVER, I HAVE BEEN WORKING IN OHIO SINCE THE PURCHASE OF SAID VEHICLE 10-17-2001 TO CURRENT DATE 2-11-2013. ON 4-14-2012 I WAS PREPARING TO TAKE MY BOAT TO FUEL IT . WHILE CHECKING THE TRAILER LIGHTS I STEPPED ON THE BRAKE PEDAL AND IT WENT STRAIGHT TO THE FLOOR. I FOUND THAT THE BRAKE LINE TO THE REAR WHEELS HAD BURST IN HALF AND WAS SEVERELY CORRODED. UPON CLOSER INSPECTION I FOUND THAT ALL THE BRAKE LINES SHOWED SIGNS OF SEVERE CORROISION. ON 2-8-2013 I DISCOVERED THAT DIESEL FUEL WAS LEAKING NEAR THE FUEL TANK AND FUEL COOLER. IT WAS FOUND TO BE A CORRODED RETURN FUEL LINE BETWEEN THE COOLER AND THE FUEL TANK .AGAIN UPON CLOSER INSPECTION ALL FUE

Mileage: 154,163

THIS MORNING I NOTICED THE BRAKE PEDAL TRAVELING DOWN FURTHER THAN NORMAL AND LITTLE TO NO STOPPING POWER. ONCE ARRIVING AT WORK I TRIED TO PUMP THE BRAKE PEDAL AND IT KEPT GOING TO THE FLOOR. UPON LOOKING UNDER THE TRUCK I DISCOVERED A PUDDLE OF BRAKE FLUID. AFTER FURTHER INSPECTION I FOUND ONE OF BRAKE LINES HAD RUSTED THROUGH AND BLOWN OUT IN FRONT OF THE ABS MODULE. THE GENERAL CONDITION OF ALL THE BRAKE LINES IN THIS AREA IS VERY RUSTY. I WILL LIKELY HAVE TO REPLACE ALL THE BRAKE LINES DUE TO THIS. *TR

TL* THE CONTACT OWNS A 2002 GMC SIERRA 3500. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SMOKE AND LOSE POWER ABNORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FUEL FILTER WAS REPLACED. THE FAILURE RECURRED IN LESS THAN ONE YEAR. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THE CONTACT WAS ADVISED THAT THERE WERE THREE DEFECTIVE FUEL INJECTORS THAT WOULD NEED REPLACING. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 06E043000 (FUEL SYSTEM, GASOLINE) YET THE REPAIR DID NOT REMEDY THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 82,828.

Mileage: 80,000

TL*THE CONTACT OWNS A 2002 GMC SIERRA 3500. WHILE DRIVING 15 MPH, THE ANTILOCK BRAKE SYSTEM BEGAN TO ACTIVATE IN NORMAL WEATHER CONDITIONS. AS A RESULT, THE BRAKES BEGAN TO TREMBLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND A TECHNICIAN STATED THAT THERE WAS CORROSION OF THE WHEEL SPEED SENSOR, WHICH CAUSED THE ABS TO ACTIVATE. NO REPAIRS HAVE BEEN MADE. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL AND NO REIMBURSEMENT WOULD BE PROVIDED. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 49,100 AND CURRENT MILEAGE WAS 50,289.

Mileage: 49,100

MY ABS BRAKES PREVENT MY TRUCK FROM STOPPING AT SLOW SPEEDS. *TR

Mileage: 42,050

TL*THE CONTACT OWNS A 2002 GMC 3500. WHILE DRIVING 35 MPH, THE CONTACT SWERVED TO AVOID A DEER AND STRUCK A CONCRETE WALL. NONE OF THE AIR BAGS IN THE VEHICLE DEPLOYED. THE VEHICLE WAS TOWED FROM THE SCENE. THE CONTACT STATED THAT THERE WAS MINOR DAMAGE TO THE VEHICLE. A POLICE REPORT WAS FILED. THE VEHICLE HAS NOT BEEN INSPECTED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 78,000.

Mileage: 78,000

THERE WAS NO EVENT THAT WAS NOTED THAT WOULD CAUSE THE SEPARATION OF THE TIRE TREAD FROM THE SIDEWALL. A MAJOR LEAK WAS NOTED. THE SPLIT WAS LOCATED AT THE POINT OF SIDEWALL TO TREAD JOINT. THE TIRE HAS >9/32 OF TREAD LEFT ON THE TIRE. I AM AT A LOSS TO REPLACE THE TIRE. NO TRAUMA WAS INFLICTED ON THE TIRE. *NM

Mileage: 88,689

THIS COMPLAINT IS REGARDING NHTSA ID # 05V161000 AND GM RECALL # 05042. THE ABOVE IS FOR A DEFECT IN THE PARKING BRAKE WHICH CAUSES PREMATURE WEAR. THE RECALL ONLY APPLIES TO MANUAL SHIFT TRANSMISSIONS. I HAVE THIS SAME PROBLEM BUT HAVE AN AUTOMATIC TRANSMISSION. I BELIEVE THIS RECALL SHOULD ALSO APPLY TO MY VEHICLE SINCE A PARKING BRAKE IS ALSO INSTALLED ON MY VEHICLE AND IT IS ALSO DEFECTIVE. IF A PARKING BRAKE IS NOT NEEDED ON MY VEHICLE FOR SAFETY THAN WHY IS ONE INSTALLED? *JB

Mileage: 20,000