2005 GMC SIERRA

AIR BAGS:FRONTAL

CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYST

EQUIPMENT:ELECTRICAL

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

SEAT BELTS:REAR/OTHER

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT

PARKING BRAKE

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.

STEERING:GEAR BOX:SHAFT SECTOR

ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.

POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR

CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES

SERVICE BRAKES, HYDRAULIC

CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.

ENGINE AND ENGINE COOLING

ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.

ON 11-30-2015 I LOST THE BRAKE SYSTEM WHILE DRIVING ON A CITY STREET. UPON INSPECTION I FOUND A RUPTURED BRAKE LINE FROM THE PRIMARY SIDE OF THE MASTER CYLINDER. THE BRAKE LINE HAD FAILED DUE TO CORROSION. INSPECTING OTHER BRAKE LINES, I FOUND OTHERS THAT HAD CORROSION WHERE PLASTIC CLIPS WERE USED TO LOCATE LINES. I HAVE OWNED THIS TRUCK SINCE NEW AND HAVE CARED FOR IT METICULOUSLY. THE TRUCK HAS 66,00 MILES ON IT. I HAVE NEVER OWNED ANY VEHICLE THAT HAD IT BRAKE LINES RUST THROUGH LIKE THIS. A MAJOR CATASTROPHE TO ME AND MY FAMILY WAS AVERTED BY PULLING OVER AT THE FIRST SIGN OF FAILURE. GM SHOULD BE HELD LIABLE FOR EVERY VEHICLE IT MANUFACTURED WITH POOR QUALITY MATERIALS THAT CAN CAUSE FAILURE TO THE SINGLE MOST IMPORTANT PART OF AN AUTOMOBILE, THE BRAKES. AS YOU CAN SEE FROM THE ATTACHED PHOTOS, THIS TRUCK IS NOT RUSTED ANYWHERE ELSE.

Mileage: 66,376

ISSUES WITH EMISSIONS SWITCH. CHECK ENGINE LIGHT WILL NOT GO OFF. ALSO 3 AND 4TH GEAR ARE COMPLETELY GONE OUT. I DO NOT TOW OR HAVE HAD ANYTHING EVEN REMOTELY HEAVY IN THIS TRUCK. IT'S A 2005 GMC SIERRA WITH ONLY 78,480 MILES ON IT. I AM NOT THE ONLY ONE HAVING ISSUES WITH THIS 4 SPEED TRANSMISSION. IT IS NOT HEAVY DUTY ENOUGH FOR THIS SIZE TRUCK. GM NEEDS TO RECALL ALL OF THESE TRANSMISSIONS. WHEN IT FIRST STARTED SLIPPING I LOST ALL POWER GOING DOWN THE ROAD AT ABOUT 55MPH. THE VEHICLE THAT WAS BEHIND ME SLAMMED ON HIS BRAKES TO AVOID HITTING ME. THIS PROBLEM WITH THE TRANSMISSION IS GOING TO KILL SOMEONE.

Mileage: 78,480

ISSUES WITH EMISSIONS SWITCH. CHECK ENGINE LIGHT WILL NOT GO OFF. ALSO 3 AND 4TH GEAR ARE COMPLETELY GONE OUT. I DO NOT TOW OR HAVE HAD ANYTHING EVEN REMOTELY HEAVY IN THIS TRUCK. IT'S A 2005 GMC SIERRA WITH ONLY 78,480 MILES ON IT. I AM NOT THE ONLY ONE HAVING ISSUES WITH THIS 4 SPEED TRANSMISSION. IT IS NOT HEAVY DUTY ENOUGH FOR THIS SIZE TRUCK. GM NEEDS TO RECALL ALL OF THESE TRANSMISSIONS. WHEN IT FIRST STARTED SLIPPING I LOST ALL POWER GOING DOWN THE ROAD AT ABOUT 55MPH. THE VEHICLE THAT WAS BEHIND ME SLAMMED ON HIS BRAKES TO AVOID HITTING ME. THIS PROBLEM WITH THE TRANSMISSION IS GOING TO KILL SOMEONE.

Mileage: 78,480

VEHICLE WAS STOPPED. BRAKE PEDDLE WENT TO THE FLOORBOARD. NOT ABLE TO PUMP UP ANY PRESSURE. INVESTIGATION SHOWED BRAKE FLUID COMING FROM PERFORATED BRAKE LINE AT LEFT FRONT WHEEL. NO BRAKING ACTION AVAILABLE! APPEARS TO BE SOME TYPE OF CORROSIVE REACTION BETWEEN THE BRAKE LINE AND THE CLAMPS USED TO FASTEN THE LINE TO THE CHASSIS. NOTE: THIS VEHICLE HAS NEVER BEEN OPERATED IN SNOW OR ROAD SALT TO MY KNOWLEDGE.

Mileage: 60,000

BRAKE FAILURE DO TO RUSTED OUT LINES.A ONGOING PROBLEM THAT GM WILL NOT TAKE RESPONSIBILITY FOR THE POOR QUALITY OF THESE LINES PUTTING PEOPLE'S LIVES AT RISK.

Mileage: 101,000

TL* THE CONTACT OWNS A 2005 GMC SIERRA. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE ENGINE SUDDENLY INCREASED IN SPEED TO APPROXIMATELY 10 MPH. THE CONTACT STATED THAT THE DISPLAY PANEL READ "REDUCED POWER MODE" AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED WITHOUT WARNING. THE VEHICLE WAS THEN TAKEN TO A DEALER WHERE THE THROTTLE BODY WIRE HARNESS, THE THROTTLE ACCELERATOR CONTROL MODULE, AND THE ACCELERATOR PEDAL ASSEMBLY WERE REPAIRED. THE REPAIR FAILED TO REMEDY THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 270,000.

Mileage: 270,000

WITHOUT ANY WARNING, MY BRAKE LINES FAILED AND I COULD NOT STOP MY TRUCK. I LIVE IN THE NORTHEAST AND IT WOULD SEEM REASONABLE FOR BRAKE LINES TO RUST OUT. HOWEVER, MY TRUCK IS ONLY 10 YEARS OLD AND I HAVE SPENT THOUSANDS OF DOLLARS KEEPING IT WASHED, INCLUDING THE UNDERCARRIAGE. I HAVE NEVER HAD A BRAKE LINE FAIL ON ANOTHER CAR AND I HAVE DRIVEN SOME REALLY OLD VEHICLES. I HAVE ALSO NEVER HEARD OF ANYONE I KNOW HAVING A PROBLEM WITH THEIR VEHICLES. THIS IS BECAUSE IT IS A SPECIFIC PROBLEM WITH GMC SIERRA AND CHEVY SILVERADO.

Mileage: 115,000

A VEHICLE APPROACHING FROM MY LEFT SIDE WAS SPEEDING AND RAN THE STOP LIGHT IN FRONT OF ME AT APPROXIMATELY 40MPH. I SLAMMED ON MY BRAKES TO AVOID THE COLLISION AND MY BRAKES WET TO THE FLOOR. I MISSED HITTING THE CAR BY ABOUT 1 FOOT. AT AN INSPECTION AT A DEALERSHIP IT APPEARS THE BRAKE LINES HAD RUSTED THROUGH UNDER THE DRIVERS SIDE OF THE TRUCK. APPARENTLY FORM ROAD SALT CORROSION,

Mileage: 30,000

2005 GMC SIERRA. CONSUMER WRITES IN REGARDS TO VEHICLE SPEEDOMETER STOPPED WORKING. *SMD

Mileage: 76,000

ANOTHER GM RUSTY BRAKE LINE FAILURE WHILE ATTEMPTING TO STOP ON A 2005 GMC SIERRA 1500. I DON'T EXPECT THINGS TO LAST FOREVER, BUT BRAKE LINES ARE ESSENTIAL TO THE SAFETY OF A VEHICLE AND THEY SHOULD NOT BE RUSTING TO FAILURE AT THIS POINT. I DON'T CARE WHAT THE CLIMATE IS. AT THIS POINT MY TRUCK IS IN THE SHOP GETTING FIXED ON MY DIME (GM REFUSES TO REPAIR IT). BUT THEY NEED TO LOOK INTO THIS. I HAVE WORKED ON/DRIVEN MANY MUCH OLDER CARS IN THE SAME CONDITION, AND I HAVE NEVER SEEN BRAKE LINES RUST TO THIS EXTENT IN 10 YEARS. MY LAST CAR WAS A 20 YEAR OLD MONTE CARLO THAT STILL HAD ORIGINAL BRAKE LINES. IN MY OPINION THIS HAS THE POTENTIAL TO TURN INTO BIGGER SAFETY ISSUE AT SOME TIME. IN MY OPINION, IT IS ONLY A MATTER OF TIME. *TR

SPEEDOMETER DOES NOT RETURN TO ZERO WHEN YOU STOP IF IT GOES DOWN TO 40 AND YOU DRIVE OFF DOING 40 IT READS 80. *TR

Mileage: 32,898

WENT TO STOP AT STOP SIGN, BRAKES FELT SPONGY. STOPPED UP THE ROAD ABOUT 2 MILES AT MY MOMS HOUSE TO GET MY KIDS, LOOKED UNDER THE TRUCK AND SAW BRAKE FLUID DRIPPING DOWN ON THE LEFT SIDE OF THE FRAME BEHIND THE LEFT FRONT WHEEL.I HAVE TO REPLACE ALL OF MY BRAKE LINES NOW DUE TO RUST. *TR

Mileage: 99,634

TL* THE CONTACT OWNS A 2005 GMC SIERRA. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG DEPLOYED WHEN THE VEHICLE WAS SHUT OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

Mileage: 102,000

WHEN TRYING TO EXIT HIGHWAY OFFRAMP BRAKES COMPLETELY FAILED DUE TO BRAKE LINES RUSTING THROUGH. VEHICLE WAS BROUGHT TO A STOP WITH PARKING BRAKE. *TR

Mileage: 211,925

I WAS TRAVELING AT 35 MPH AND APPROACHED A STOP LIGHT. THE BRAKES FAILED AND I WENT THROUGH THE RED LIGHT. I NEARLY WAS HIT BY ONCOMING TRAFFIC. THE BRAKE LINE HAS A SEVER LEAK AT A RUSTED AREA IN THE LINE. *TR

Mileage: 148,000

AROUND THE MIDDLE OF DECEMBER 2014 THE "SERVICE BRAKE SYSTEM" MESSAGE APPEARED ON MY 2005 GMC 1500 SIERRA SLE. I CHECKED THE BRAKE FLUID RESERVOIR AND IT WAS NEARLY EMPTY. I COULD NOT FIND WHERE THE FLUID HAD LEAKED FROM SO I SERVICED THE RESERVOIR WITH 12 OUNCES BRAKE FLUID TO THE FULL MARK. FROM ABOUT DECEMBER 15, 2014 UNTIL 28 DECEMBER 2014, I LOST ABOUT 7 OUNCES OF BRAKE FLUID. NO TRACE OF BRAKE FLUID CAN BE FOUND ON THE DRIVEWAY. I CRAWLED UNDER THE TRUCK AND HAD MY WIFE PRESS THE BRAKES WHILE I LOOKED FOR A LEAK. I FOUND THE LEAK NEAR THE LEFT REAR WHEEL AREA ON A VERY CORRODED BRACKET. IT APPEARS TO BE A VERY SMALL HOLE BECAUSE THE FLUID COMES OUT AS A FINE MIST AND NOT A STREAM. THE RIGID BRAKE LINE CONNECTS TO A FLEXIBLE BRAKE LINE AT THE BRACKET AND THERE IS A LOT OF RUST AT THE CONNECTION AS WELL AS THE BRAKE LINE. I HAVE FOUND RUST FORMING ON OTHER BRAKE LINES AS WELL. *TR

Mileage: 115,800

ENGINE HAS LOSE OF ENGINE COOLANT OVER TIME WITH NO EVIDENCE OF LEAKS FOUND. WE BROUGHT THE TRUCK TO A GM DEALER WHICH TOLD US THIS WAS A KNOWN DEFECT ISSUE. THEY PROVIDED US WITH BULLETIN # 06-06-01-019B DOCUMENT ID 1986750 WHICH CLEARLY STATE THIS WAS DEFECT IN THE CASTING OF THE CASTECH HEADS. THE COST WITH PARTS AND LABOR IS $3,100.00 DOLLARS. CLEARLY, GM SHOULD COVER THIS COST SINCE THIS OBVIOUSLY IS A KNOWN DEFECT. SEARCHING THE INTERNET YOU CAN SEE A LARGE NUMBER OF PEOPLE EXPERIENCING THIS ISSUE WITH LITTLE OR NO HELP FROM GM. *TR

Mileage: 114,000

THE VEHICLE WAS PURCHASED NEW AND HAS BEEN REGULARLY MAINTAINED. THE BRAKE LINES AND FRAME ARE HEAVILY CORRODED. WHILE PULLING OUT OF A PARKING SPOT ON 10/26/14 BRAKES WERE APPLIED ABRUPTLY WHICH CAUSED A RUPTURE OF THE CORRODED BRAKE LINES. ALL BRAKE LINES WILL NEED TO BE REPLACED IN ORDER TO SAFELY RETURN THE VEHICLE TO SERVICE. OTHER FAMILY MEMBERS HAVE 2004 CHEVY YUKON AND 1994 GMC 2500, BOTH VEHICLES HAD BRAKE LINES FAIL DUE TO CORROSION AND REQUIRED COMPLETE REPLACEMENT IN ORDER TO SAFELY RETURN THE VEHICLES TO SERVICE. THIS IS A SERIOUS SAFETY CONCERN AND THESE BRAKE LINE FAILURES ARE NOT NORMAL WEAR AND TEAR. I HAVE HAD SEVERAL VEHICLES MUCH OLDER THAN THIS VEHICLE WHICH STILL HAVE STOCK BRAKE LINES WITH NO CORROSION. *TR

Mileage: 140,000

MY SPEEDOMETER RECENTLY MALFUNCTIONED AT AROUND 77,000 MILES AND I BROUGHT IT TO THE ATTENTION OF THE DEALERSHIP'S SERVICE MANAGER, JEFF BEVINGTON, AT RALLY GMC AUTO GROUP IN PALMDALE, CA (WHERE I PURCHASED THE VEHICLE NEW IN 2005). I WAS GIVEN SERVICE BULLETIN #07187C - SPECIAL COVERAGE ADJUSTMENT INSTRUMENT PANEL CLUSTER GAUGE NEEDLE FUNCTION (MARCH 20, 2009), WHICH INDICATES THE FOLLOWING: THIS BULLETIN IS BEING REVISED TO INCLUDE CERTAIN 2005 MODEL YEAR VEHICLES IN THE U.S. ADDITIONALLY, FOR U.S. 2003-2005 MODEL YEAR VEHICLES, GM WILL PROVIDE THE INSTRUMENT PANEL CLUSTER (IPC) ONLY, AT NO CHARGE TO THE CUSTOMER FOR VERIFIED FAILURES BETWEEN 70,001 MILES (110,001 KM) AND 80,000 MILES (130,000 KM). ANY ADDITIONAL COSTS, INCLUDING LABOR TO REPLACE THE INSTRUMENT PANEL CLUSTER, WILL BE THE RESPONSIBILITY OF THE CUSTOMER. DEALERS WILL BE RESPONSIBLE FOR THE RETURN OF THE CUSTOMER'S IPC BACK TO THE ELECTRONIC SERVICE CENTER. PLEASE DISCARD ALL COPIES OF BULLETIN 01787B, ISSUED SEPTEM

Mileage: 77,000

POWER STEERING STOPS WORKING ON SLOW RIGHT HAND TURNS. I SOMETIMES NEED TO BACK UP IN ORDER TO COMPLETE THE TURN. I ALSO END UP CROSSING INTO ONCOMING LANES IF NO TRAFFIC IS COMEING TOWARDS ME. IF THERE IS TRAFFIC I NEED TO STOP IN THE MIDDLE OF THE TURN UNTIL THE TRAFFIC CLEARS. THE "CHECK AIRBAG" LIGHT CAME ON AT 85000 MILES AFTER THE BATTERY DISCHARGED FROM THE VEHICLE SITTING TO LONG WITHOUT BEING DRIVEN. *TR

Mileage: 57,000