Total Complaints
8 filings
GMC SAVANA 3500 · model year
2003 GMC SAVANA 3500
8 NHTSA complaints, and 1 active recall for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2003GMCSAVANA 3500 carries 8 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 5 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2003 SAVANA 3500 is suspension:front:wheel bearing with 1 filings, followed by service brakes, hydraulic (1) and service brakes, hydraulic:foundation components:disc:rotor (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 2 investigation files overlapping the 2003 SAVANA 3500. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
8
Complaints
0
Crashes
5
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SUSPENSION:FRONT:WHEEL BEARING | 1 |
| SERVICE BRAKES, HYDRAULIC | 1 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR | 1 |
| ELECTRICAL SYSTEM:HORN | 1 |
| ELECTRICAL SYSTEM | 1 |
| ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| UNKNOWN OR OTHER | 1 |
| EQUIPMENT | 1 |
Recalls (1)
06E04300019/05/2006
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE
Recent Complaints
20090321FireELECTRICAL SYSTEM
VAN WAS BEING DRIVEN EARLY MORNING FOR ABOUT 30 MINUTES. NO RAIN, 45 DEGREE OUTSIDE TEMP., HEADLIGHTS ON. DRIVER FIRST NOTICED DASH LIGHTS FLICKER & ALTERNATOR GAUGE SHOWING A DISCHARGE, THEN THESE ISSUES RETURNED TO NORMAL. THE VAN CONTINUED BEING DRIVEN FOR 15 MINUTES TO DESTINATION W/O FURTHER ISSUES. UPON DEPARTING VAN, DRIVER NOTICED UNUSUAL SMELL AND WAS TOLD BY ANOTHER PERSON THAT SMOKE AND FIRE WERE COMING FROM UNDERNEATH THE VAN AT ABOUT MIDPOINT. UPON INSPECTION THE DRIVER SAW FLAMES EMANATING FROM SAID POINT UNDERNEATH THE VAN AND LIQUIDS ON THE GROUND. EMERGENCY CALL TO THE FIRE DEPARTMENT WAS MADE & A THIRD PERSON BROUGHT A FIRE EXTINGUISHER TO THE SCENE. FIRE WAS EXTINGUISHED BUT REIGNITED AS THE FIREMEN ARRIVED TO COMPLETE THE JOB. VEHICLE NOT SEVERELY DAMAGED AND NO INJURIES. VEHICLE WAS TOWED FOR INSPECTION. DISCOVERED THE ALTERNATOR CHARGING WIRE TO THE BATTERY HAD NOT ORIGINALLY BEEN SECURED OR SHIELDED PROPERLY AND WAS RUBBING ON A BOLT HEAD SECURING TWO A/C CHARGIN
Mileage: 58,500
20090321FireENGINE AND ENGINE COOLING:COOLING SYSTEM
VAN WAS BEING DRIVEN EARLY MORNING FOR ABOUT 30 MINUTES. NO RAIN, 45 DEGREE OUTSIDE TEMP., HEADLIGHTS ON. DRIVER FIRST NOTICED DASH LIGHTS FLICKER & ALTERNATOR GAUGE SHOWING A DISCHARGE, THEN THESE ISSUES RETURNED TO NORMAL. THE VAN CONTINUED BEING DRIVEN FOR 15 MINUTES TO DESTINATION W/O FURTHER ISSUES. UPON DEPARTING VAN, DRIVER NOTICED UNUSUAL SMELL AND WAS TOLD BY ANOTHER PERSON THAT SMOKE AND FIRE WERE COMING FROM UNDERNEATH THE VAN AT ABOUT MIDPOINT. UPON INSPECTION THE DRIVER SAW FLAMES EMANATING FROM SAID POINT UNDERNEATH THE VAN AND LIQUIDS ON THE GROUND. EMERGENCY CALL TO THE FIRE DEPARTMENT WAS MADE & A THIRD PERSON BROUGHT A FIRE EXTINGUISHER TO THE SCENE. FIRE WAS EXTINGUISHED BUT REIGNITED AS THE FIREMEN ARRIVED TO COMPLETE THE JOB. VEHICLE NOT SEVERELY DAMAGED AND NO INJURIES. VEHICLE WAS TOWED FOR INSPECTION. DISCOVERED THE ALTERNATOR CHARGING WIRE TO THE BATTERY HAD NOT ORIGINALLY BEEN SECURED OR SHIELDED PROPERLY AND WAS RUBBING ON A BOLT HEAD SECURING TWO A/C CHARGIN
Mileage: 58,500
20090321FireUNKNOWN OR OTHER
VAN WAS BEING DRIVEN EARLY MORNING FOR ABOUT 30 MINUTES. NO RAIN, 45 DEGREE OUTSIDE TEMP., HEADLIGHTS ON. DRIVER FIRST NOTICED DASH LIGHTS FLICKER & ALTERNATOR GAUGE SHOWING A DISCHARGE, THEN THESE ISSUES RETURNED TO NORMAL. THE VAN CONTINUED BEING DRIVEN FOR 15 MINUTES TO DESTINATION W/O FURTHER ISSUES. UPON DEPARTING VAN, DRIVER NOTICED UNUSUAL SMELL AND WAS TOLD BY ANOTHER PERSON THAT SMOKE AND FIRE WERE COMING FROM UNDERNEATH THE VAN AT ABOUT MIDPOINT. UPON INSPECTION THE DRIVER SAW FLAMES EMANATING FROM SAID POINT UNDERNEATH THE VAN AND LIQUIDS ON THE GROUND. EMERGENCY CALL TO THE FIRE DEPARTMENT WAS MADE & A THIRD PERSON BROUGHT A FIRE EXTINGUISHER TO THE SCENE. FIRE WAS EXTINGUISHED BUT REIGNITED AS THE FIREMEN ARRIVED TO COMPLETE THE JOB. VEHICLE NOT SEVERELY DAMAGED AND NO INJURIES. VEHICLE WAS TOWED FOR INSPECTION. DISCOVERED THE ALTERNATOR CHARGING WIRE TO THE BATTERY HAD NOT ORIGINALLY BEEN SECURED OR SHIELDED PROPERLY AND WAS RUBBING ON A BOLT HEAD SECURING TWO A/C CHARGIN
Mileage: 58,500
20090321FireEQUIPMENT
VAN WAS BEING DRIVEN EARLY MORNING FOR ABOUT 30 MINUTES. NO RAIN, 45 DEGREE OUTSIDE TEMP., HEADLIGHTS ON. DRIVER FIRST NOTICED DASH LIGHTS FLICKER & ALTERNATOR GAUGE SHOWING A DISCHARGE, THEN THESE ISSUES RETURNED TO NORMAL. THE VAN CONTINUED BEING DRIVEN FOR 15 MINUTES TO DESTINATION W/O FURTHER ISSUES. UPON DEPARTING VAN, DRIVER NOTICED UNUSUAL SMELL AND WAS TOLD BY ANOTHER PERSON THAT SMOKE AND FIRE WERE COMING FROM UNDERNEATH THE VAN AT ABOUT MIDPOINT. UPON INSPECTION THE DRIVER SAW FLAMES EMANATING FROM SAID POINT UNDERNEATH THE VAN AND LIQUIDS ON THE GROUND. EMERGENCY CALL TO THE FIRE DEPARTMENT WAS MADE & A THIRD PERSON BROUGHT A FIRE EXTINGUISHER TO THE SCENE. FIRE WAS EXTINGUISHED BUT REIGNITED AS THE FIREMEN ARRIVED TO COMPLETE THE JOB. VEHICLE NOT SEVERELY DAMAGED AND NO INJURIES. VEHICLE WAS TOWED FOR INSPECTION. DISCOVERED THE ALTERNATOR CHARGING WIRE TO THE BATTERY HAD NOT ORIGINALLY BEEN SECURED OR SHIELDED PROPERLY AND WAS RUBBING ON A BOLT HEAD SECURING TWO A/C CHARGIN
Mileage: 58,500
20080611FireELECTRICAL SYSTEM:HORN
TL*THE CONTACT OWNS A 2003 GMC SAVANA 3500. THE CONTACT NOTICED THAT THE HORN IN THE VEHICLE SOUNDED AUTOMATICALLY WHILE PARKED. IN AN ATTEMPT TO STOP THE NOISE, SOMEONE PRESSED THE HORN TO COUNTERACT THE FAILURE. ALMOST IMMEDIATELY, SMOKE BEGAN POURING FROM THE HOOD AND THE POLICE DEPARTMENT WAS CALLED. THE VEHICLE WENT UP IN FLAMES WITHIN A MATTER OF MINUTES. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. AT THE TIME OF THE COMPLAINT, THE CONTACT'S INSURANCE COMPANY WAS ASSESSING THE DAMAGE TO DETERMINE IF THE VEHICLE WAS DESTROYED. THE ENTIRE FRONT END WAS BURNED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 89,000.
Mileage: 89,000
20061206SUSPENSION:FRONT:WHEEL BEARING
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH UNDER NORMAL ROAD CONDITIONS, THE FRONT WHEEL BEARINGS FROZE UP, AND THE TIRES DID NOT TURN. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO REPLACED THE FRONT WHEEL BEARINGS AND THE BRAKE ROTORS. UPDATED 02/12/07. *JB
Mileage: 70,115
20061206SERVICE BRAKES, HYDRAULIC
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH UNDER NORMAL ROAD CONDITIONS, THE FRONT WHEEL BEARINGS FROZE UP, AND THE TIRES DID NOT TURN. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO REPLACED THE FRONT WHEEL BEARINGS AND THE BRAKE ROTORS. UPDATED 02/12/07. *JB
Mileage: 70,115
20061206SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH UNDER NORMAL ROAD CONDITIONS, THE FRONT WHEEL BEARINGS FROZE UP, AND THE TIRES DID NOT TURN. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO REPLACED THE FRONT WHEEL BEARINGS AND THE BRAKE ROTORS. UPDATED 02/12/07. *JB
Mileage: 70,115
Compare 2003GMCSAVANA 3500 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2003 GMC SAVANA 3500 have?▼
The 2003 GMC SAVANA 3500 has 8 NHTSA complaints, 0 crashes, 5 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2003 GMC SAVANA 3500?▼
Yes, the 2003 GMC SAVANA 3500 has 1 recall(s). The most common affected component is FUEL SYSTEM, GASOLINE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2003 GMC SAVANA 3500?▼
The most-complained component for the 2003 GMC SAVANA 3500 is SUSPENSION:FRONT:WHEEL BEARING with 1 complaints. Other frequently reported areas include SERVICE BRAKES, HYDRAULIC and SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR.
Is the 2003 GMC SAVANA 3500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.