Total Complaints
4 filings
GMC SAVANA 2500 · model year
2005 GMC SAVANA 2500
4 NHTSA complaints, and 1 active recall for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2005GMCSAVANA 2500 carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2005 SAVANA 2500 is engine and engine cooling with 1 filings, followed by steering (1) and engine (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 2 investigation files overlapping the 2005 SAVANA 2500. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING | 1 |
| STEERING | 1 |
| ENGINE | 1 |
| STRUCTURE:BODY | 1 |
Recalls (1)
06E04300019/05/2006
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE
Recent Complaints
20141009STRUCTURE:BODY
PAINT IS PEALING AND BLOWING OFF IN SHEETS AND BODY IS RUSTING. *TR
Mileage: 75,000
20140410ENGINE
TL* THE CONTACT OWNS A 2005 GMC SAVANA 2500. THE CONTACT EXPERIENCED A LOSS OF COOLANT AND WAS CONSTANTLY HAVING TO REPLACE THE COOLANT. THE CONTACT DISCOVERED THE CYLINDER HEADS WERE DEFECTIVE. THE CONTACT TOOK HIS VEHICLE TO THE DEALER. THE DEALER STATED THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE REPAIR; HOWEVER, DECLINED TO PROVIDE FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 115,000.
20110209STEERING
I HAVE A 2005 SAVANNAH GMC WITH SEVERE FRONT END PROBLEMS FROM DAY ONE. THE DEALER HAS SIDE-STEPPED THIS FROM DAY ONE. NOW THE FRONT WHEELS BOUNCE AND SHAKE LONG AFTER A ROAD BUMP IS CONTACTED. ONLY SUDDEN SLOWING DOWN MAKES THIS STOP, CREATING HAZARD CONDITIONS FOR ME AND THOSE BEHIND ME. *TR
Mileage: 200
20080407ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2005 GMC SAVANA 2500. THE CONTACT EXPERIENCED A LOSS OF COOLANT, CRACKED CYLINDER HEADS, OXYGEN SENSOR FAILURE AND FLUID LEAKING ONTO THE EXHAUST. A LOCAL MECHANIC INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THE RADIATOR CAP AND OXYGEN SENSORS NEEDED TO BE REPLACED. AFTER THE REPLACEMENTS, THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER ALSO REPLACED THE RADIATOR CAP AND THE OXYGEN SENSORS. THE FAILURE RECURRED A THIRD TIME, AND THE CATALYTIC CONVERTER WAS REPLACED. THE FAILURE CONTINUED AND THE CONTACT RETURNED TO HIS LOCAL MECHANIC, WHO LOCATED A SERVICE BULLETIN THAT IDENTIFIED THE FAILURE AND THE REMEDY. THE FAILURE CAUSED $10,000 WORTH OF DAMAGE TO THE ENGINE, WHICH ALSO HAD TO BE REPLACED. THE FAILURE MILEAGE WAS 352,000 AND CURRENT MILEAGE WAS 360,000. UPDATED 06/10/08. *LJ UPDATED 06/10/08
Mileage: 352,000
Compare 2005GMCSAVANA 2500 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2005 GMC SAVANA 2500 have?▼
The 2005 GMC SAVANA 2500 has 4 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2005 GMC SAVANA 2500?▼
Yes, the 2005 GMC SAVANA 2500 has 1 recall(s). The most common affected component is FUEL SYSTEM, GASOLINE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2005 GMC SAVANA 2500?▼
The most-complained component for the 2005 GMC SAVANA 2500 is ENGINE AND ENGINE COOLING with 1 complaints. Other frequently reported areas include STEERING and ENGINE.
Is the 2005 GMC SAVANA 2500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.