Total Complaints
7 filings
GMC SAVANA 1500 · model year
2005 GMC SAVANA 1500
7 NHTSA complaints, and 1 recall campaign listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2005GMCSAVANA 1500 carries 7 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2005 SAVANA 1500 is service brakes, hydraulic with 2 filings, followed by structure:body (1) and tires (1). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 1 NHTSA recall campaign listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 2 investigation files overlapping the 2005 SAVANA 1500. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
7
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES, HYDRAULIC | 2 |
| STRUCTURE:BODY | 1 |
| TIRES | 1 |
| SERVICE BRAKES | 1 |
| AIR BAGS | 1 |
| AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE | 1 |
Recalls (1)
06E04300019/05/2006
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE
Recent Complaints
20140519AIR BAGS
TL* THE CONTACT OWNS A 2005 GMC SAVANA 1500. THE AIR BAG WARNING LIGHT ILLUMINATED ON THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER, WHO STATED THAT THE FRONTAL AIR BAG SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 46,000.
Mileage: 46,000
20140519AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
TL* THE CONTACT OWNS A 2005 GMC SAVANA 1500. THE AIR BAG WARNING LIGHT ILLUMINATED ON THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER, WHO STATED THAT THE FRONTAL AIR BAG SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 46,000.
Mileage: 46,000
20130805SERVICE BRAKES
FOOT BRAKE IS NOT FUNCTIONING IF PARKED ON A GRADE GREATER THAN 8 DEGREES. AS ALWAYS, FOOT BRAKE ONLY APPLIED AFTER THE GEAR IS SHIFTED ON PARK. I DIDN'T DISCOVER THE FOOT BRAKE IS NOT PROPERLY FUNCTION UNTIL SEVERAL YEARS AFTER PURCHASE. IT SEEMS THE FOOT BRAKE WAS NOT ADJUSTED AT ALL BEFORE THE VEHICLE LEFT THE FACTORY. IF I HAVE THE GEAR SET ON NEUTRAL ON DRIVEWAY, ONLY APPLY THE FOOT BRAKE, VEHICLE ROLLS BY ITSELF. *TR
Mileage: 29,000
20101129TIRES
TL*THE CONTACT OWNS A 2005 GMC SAVANA 1500. WHILE THE VEHICLE WAS PARKED, THE CONTACT CHECKED THE SPARE TIRE. WHILE USING THE JACK, THE SPARE TIRE ONLY CAME DOWN SIX INCHES. THE CONTACT WAS UNABLE TO GET THE SPARE TIRE BACK UP AGAIN. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CABLE WAS CUT TO GET THE SPARE TIRE OFF; IT WAS THEN PLACED IN THE REAR OF THE VAN. THE CONTACT ALSO STATED THAT THE BRAKES FUNCTIONED POORLY; THE PEDAL WAS VERY LOW. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE BRAKES WORKED FINE. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT LEFT SENSOR ON THE LEFT FRONT WHEEL NEEDED TO BE REPLACED. THE MECHANIC REPLACED THE HUB ASSEMBLY AND REPLACED THE ROTOR ON THE REAR WHEELS. THE REAR PLATES ON THE REAR WHEELS WERE ALSO RUSTED WHICH CAUSED BRAKE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.
Mileage: 56,000
20101129SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2005 GMC SAVANA 1500. WHILE THE VEHICLE WAS PARKED, THE CONTACT CHECKED THE SPARE TIRE. WHILE USING THE JACK, THE SPARE TIRE ONLY CAME DOWN SIX INCHES. THE CONTACT WAS UNABLE TO GET THE SPARE TIRE BACK UP AGAIN. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CABLE WAS CUT TO GET THE SPARE TIRE OFF; IT WAS THEN PLACED IN THE REAR OF THE VAN. THE CONTACT ALSO STATED THAT THE BRAKES FUNCTIONED POORLY; THE PEDAL WAS VERY LOW. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE BRAKES WORKED FINE. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT LEFT SENSOR ON THE LEFT FRONT WHEEL NEEDED TO BE REPLACED. THE MECHANIC REPLACED THE HUB ASSEMBLY AND REPLACED THE ROTOR ON THE REAR WHEELS. THE REAR PLATES ON THE REAR WHEELS WERE ALSO RUSTED WHICH CAUSED BRAKE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.
Mileage: 56,000
20101012STRUCTURE:BODY
TL* THE CONTACT OWNS A 2005 GMC SAVANA 1500. WHEN THE CONTACT EXAMINED THE VEHICLE, HE FOUND THAT THE SPARE TIRE CABLE WAS CORRODED. THE CABLE WAS CUT TO REMOVE THE SPARE TIRE. THE REAR BRAKE METAL COVER WAS ALSO CORRODED CAUSING ROTORS AND BRAKE PADS TO FAIL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE REAR ROTORS AND BRAKE PADS WERE REPLACED. THE CONTACT PLANNED TO CALL THE MANUFACTURER. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 64,000. UPDATED 1/21/11 *CN UPDATED 04/20/11
Mileage: 64,000
20101012SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2005 GMC SAVANA 1500. WHEN THE CONTACT EXAMINED THE VEHICLE, HE FOUND THAT THE SPARE TIRE CABLE WAS CORRODED. THE CABLE WAS CUT TO REMOVE THE SPARE TIRE. THE REAR BRAKE METAL COVER WAS ALSO CORRODED CAUSING ROTORS AND BRAKE PADS TO FAIL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE REAR ROTORS AND BRAKE PADS WERE REPLACED. THE CONTACT PLANNED TO CALL THE MANUFACTURER. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 64,000. UPDATED 1/21/11 *CN UPDATED 04/20/11
Mileage: 64,000
Compare 2005GMCSAVANA 1500 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2005 GMC SAVANA 1500 have?▼
The 2005 GMC SAVANA 1500 has 7 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2005 GMC SAVANA 1500?▼
Yes, the 2005 GMC SAVANA 1500 has 1 recall(s). The most common affected component is FUEL SYSTEM, GASOLINE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2005 GMC SAVANA 1500?▼
The most-complained component for the 2005 GMC SAVANA 1500 is SERVICE BRAKES, HYDRAULIC with 2 complaints. Other frequently reported areas include STRUCTURE:BODY and TIRES.
Is the 2005 GMC SAVANA 1500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2005 GMC SAVANA 1500; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.