Total Complaints
5 filings
GMC SAVANA 1500 · model year
2004 GMC SAVANA 1500
5 NHTSA complaints, and 1 active recall for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2004GMCSAVANA 1500 carries 5 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2004 SAVANA 1500 is tires with 2 filings, followed by steering:linkages:tie rod assembly (1) and service brakes, hydraulic (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 2 investigation files overlapping the 2004 SAVANA 1500. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
5
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| TIRES | 2 |
| STEERING:LINKAGES:TIE ROD ASSEMBLY | 1 |
| SERVICE BRAKES, HYDRAULIC | 1 |
| STRUCTURE:BODY | 1 |
Recalls (1)
06E04300019/05/2006
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE
Recent Complaints
20110518TIRES
TL*THE CONTACT OWNS A 2004 GMC SAVANNA EQUIPPED WITH DEFINITY DAKOTA A/T TIRES, SIZE 235/75R16. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH, WHEN THE VEHICLE MADE A THUMPING NOISE. THE CONTACT PULLED OVER AND NOTICED ALL OF THE TREAD ON THE RIGHT REAR TIRE WAS MISSING. A SPARE TIRE WAS INSTALLED ON THE VEHICLE. THE FOLLOWING DAY, THE CONTACT STATED THAT THE FRONT PASSENGER SIDE TIRE HAD A 9/10 INCH BLISTER ON IT. THE CONTACT INSTALLED FOUR NEW TIRES. THE FAILURE MILEAGE WAS 62,000 AND CURRENT MILEAGE WAS 63,400.
Mileage: 62,000
20100802TIRES
TL* THE CONTACT OWNS A 2004 GMC SAVANNA 1500 WITH FALKEN ZINEN STZ01 TIRES, LINE SIZE P265/50/R20. WHILE DRIVING AT 50 MPH, THE VEHICLE BEGAN TO VIBRATE EXCESSIVELY. ONE OF THE TIRES EXPERIENCED BELT SEPARATION AND THE REAR BELT FRACTURED. THE TIRE WAS REPLACED HOWEVER; WITHIN 200 MILES ALL THREE REMAINING TIRES EXPERIENCED THE EXACT SAME FAILURE. THE REMAINING THREE TIRES WERE REPLACED. THE CONTACT STATED THAT THE FRONT REPLACEMENT TIRES BEGAN TO EXHIBIT BELT SEPARATION. THE TIRES WERE NOT YET REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE 42,000.
Mileage: 17,000
20090407STRUCTURE:BODY
THE CARGO DOORS ARE VERY DIFFICULT TO OPEN. THE DOOR HINGES HAVE RUSTED INTERNAL, SO THAT ONE OF THE HINGES SNAPPED OFF (LOWER HINGE, PASSENGER SIDE CARGO DOOR). GM HAS TSB FOR THIS BUT WILL NOT COVER IT. IT IS VERY UNSAFE IF YOU CAN NOT EXIT THE DOOR. *TR
Mileage: 54,000
20070328SERVICE BRAKES, HYDRAULIC
TL*- THE CONTACT OWNS A 2004 GMC SAVANNA VAN WITH A CURRENT ODOMETER READING OF 10,200 MILES. THE CONTACT STATED THAT THE VAN TOOK A LONG TIME TO STOP WHEN THE BRAKES WERE APPLIED. THE CONTACT FOUND THAT THE BRAKES THAT CAME WITH THE VEHICLE WERE TOO SMALL, WHICH RESULTED IN EXTENDED STOPPING DISTANCE WHEN APPLIED. THE MANUFACTURER WAS CALLED ABOUT THIS PROBLEM ,AND THEY TOLD THE CONTACT TO CALL HIS LOCAL DEALER AND HAVE THEM LOOK AT THE BRAKES. THE DEALER TOLD THE CONTACT THAT THE BRAKES WERE PERFORMING CORRECTLY. THE CONTACT STATED THAT WHEN HE WAS DRIVING AT 70 MPH UNDER ANY WEATHER CONDITIONS HE OFTEN HAD TO PULL TO THE SIDE OF THE ROAD WHEN BRAKING TO AVOID HITTING OTHER VEHICLES. *AK UPDATE *4/23/07 *TR
Mileage: 10,200
20060831STEERING:LINKAGES:TIE ROD ASSEMBLY
DT*: THE CONTACT STATED WHILE DRIVING AT 30 MPH, A NOISE WAS HEARD COMING FROM THE FRONT OF THE VEHICLE. UPON INSPECTION BY AN INDEPENDENT MECHANIC, IT WAS DETERMINED THAT THE INNER TIE ROD WAS FRACTURED AND HAD TO BE REPLACED. THIS WAS THE SECOND TIME THE SAME PROBLEM OCCURRED AND HAD TO BE REPLACED. THE MANUFACTURER WAS INFORMED. UPDATED 10/04/06.*JB
Mileage: 26,000
Compare 2004GMCSAVANA 1500 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2004 GMC SAVANA 1500 have?▼
The 2004 GMC SAVANA 1500 has 5 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2004 GMC SAVANA 1500?▼
Yes, the 2004 GMC SAVANA 1500 has 1 recall(s). The most common affected component is FUEL SYSTEM, GASOLINE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2004 GMC SAVANA 1500?▼
The most-complained component for the 2004 GMC SAVANA 1500 is TIRES with 2 complaints. Other frequently reported areas include STEERING:LINKAGES:TIE ROD ASSEMBLY and SERVICE BRAKES, HYDRAULIC.
Is the 2004 GMC SAVANA 1500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.