Total Complaints
4 filings
FREIGHTLINER SPRINTER 3500 · model year
2010 FREIGHTLINER SPRINTER 3500
4 NHTSA complaints, and 4 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2010FREIGHTLINERSPRINTER 3500 carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2010 SPRINTER 3500 is air bags with 1 filings, followed by electronic stability control (esc) (1) and fuel/propulsion system (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 4 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 38 investigation files overlapping the 2010 SPRINTER 3500. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| AIR BAGS | 1 |
| ELECTRONIC STABILITY CONTROL (ESC) | 1 |
| FUEL/PROPULSION SYSTEM | 1 |
| ENGINE | 1 |
Recalls (4)
11V21000030/03/2011
SEAT BELTS
MERCEDES-BENZ IS RECALLING CERTAIN MODEL YEAR 2008-2011 2500 AND 3500 SPRINTER VEHICLES EQUIPPED WITH AN OPTIONAL THREE-SEAT BENCH IN THE PASSENGER COMPARTMENT. THE SEAT BENCHES IN THE SECOND SEATING ROW MAY HAVE BEEN EQUIPPED WITH SAFETY BELTS THAT DO NOT MEET THE MINIMUM REQUIREMENTS OF FEDERAL M
10V29400029/06/2010
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
SPRINTER IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 VEHICLES MANUFACTURED FROM NOVEMBER 2009 THROUGH MARCH 2010 AND SOLD UNDER THE MERCEDES-BENZ, FREIGHTLINER, AND DODGE BRAND NAME. THE SPRING PLATE WHICH ATTACHES THE OIL FILLER NECK TO THE CYLINDER-HEAD COVER MAY CRACK.
17V47900028/07/2017
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Daimler Vans USA, LLC (DVUSA) is recalling certain 2010-2011 Freightliner and Mercedes Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled into the passenger frontal air bag modules used as original equipment or replacement equipment. In the e
16V07700010/02/2016
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Daimler Vans USA, LLC (Daimler Vans) is recalling certain model year 2007-2009 Dodge Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 31, 2008, 2007-2014 Freightliner Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 1, 2014, and 2010-2014 Mercedes Benz Sprinter 25
Recent Complaints
20190716FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 FREIGHTLINER SPRINTER 3500. THE CONTACT STATED THAT THE CHECK ENGINE AND FUEL PRESSURE LOW WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO EXCEL TRUCK GROUP OF COLUMBIA (2790 SHOP RD, COLUMBIA, SC 29209) AND WAS REPAIRED. THE CAUSE OF THE FAILURE WAS NOT DISCLOSED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 13,402. *BF THE CONSUMER STATED THE SENSOR WAS BAD AND HAD IT REPLACED AT THE TUNE OF $1455.41. THE CONSUMER WANTS TO BE REIMBURSED FOR THE REPAIRS. *TR
Mileage: 13,402
20190716ENGINE
TL* THE CONTACT OWNS A 2010 FREIGHTLINER SPRINTER 3500. THE CONTACT STATED THAT THE CHECK ENGINE AND FUEL PRESSURE LOW WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO EXCEL TRUCK GROUP OF COLUMBIA (2790 SHOP RD, COLUMBIA, SC 29209) AND WAS REPAIRED. THE CAUSE OF THE FAILURE WAS NOT DISCLOSED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 13,402. *BF THE CONSUMER STATED THE SENSOR WAS BAD AND HAD IT REPLACED AT THE TUNE OF $1455.41. THE CONSUMER WANTS TO BE REIMBURSED FOR THE REPAIRS. *TR
Mileage: 13,402
20110613ELECTRONIC STABILITY CONTROL (ESC)
THE HANDLING OF THIS VEHICLE IS VERY UNSTABLE AT 50 MILES HOUR OR LESS. WIND COULD BE SOME OF THE PROBLEMS. OTHER VEHICLES DID NOT APPEAR TO HAVE THIS PROBLEM, AS THEY WOULD PASS US AND NOT TO HAPPY THAT WE COULDN'T DRIVE FASTER.
Mileage: 720
20110407AIR BAGS
TL* THE CONTACT OWNS A 2010 FREIGHTLINER SPRINTER 3500. UPON STARTING THE VEHICLE, THE SRS WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED AND WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 800 AND THE CURRENT MILEAGE WAS 1,000. THE VIN WAS UNAVAILABLE.
Mileage: 800
Compare 2010FREIGHTLINERSPRINTER 3500 to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 2010 FREIGHTLINER SPRINTER 3500 have?▼
The 2010 FREIGHTLINER SPRINTER 3500 has 4 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2010 FREIGHTLINER SPRINTER 3500?▼
Yes, the 2010 FREIGHTLINER SPRINTER 3500 has 4 recall(s). The most common affected component is SEAT BELTS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2010 FREIGHTLINER SPRINTER 3500?▼
The most-complained component for the 2010 FREIGHTLINER SPRINTER 3500 is AIR BAGS with 1 complaints. Other frequently reported areas include ELECTRONIC STABILITY CONTROL (ESC) and FUEL/PROPULSION SYSTEM.
Is the 2010 FREIGHTLINER SPRINTER 3500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.