Total Complaints
1 filings
Freightliner MT-45 · model year
2008 Freightliner MT-45
1 NHTSA complaints, and 1 recall campaign listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
- Complaints
- 1
- Recalls
- 1
The verdict
The 2008 Freightliner MT-45 posts top-1% complaint standing (fewest filings) among its own model-year siblings.
- Top 0%
- fewest complaints, own model years
- 1
- recall campaign
The 2008FreightlinerMT-45 carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2008 MT-45 is suspension with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 1 NHTSA recall campaign listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 38 investigation files overlapping the 2008 MT-45. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
F
PlainCars Safety Score
0/100
2008 Freightliner MT-45
PlainCars' own composite of NHTSA NCAP crash-test ratings and rollover-risk assessment, each dimension normalized against the federal scale or the full national model-year corpus. Not an official NHTSA figure, and not a substitute for a specific vehicle's VIN-level recall check.
NHTSA Overall Rating N/A
Not rated
NHTSA New Car Assessment Program overall crash-test rating.
Front Crash N/A
Not rated
Frontal barrier crash-test rating.
Side Crash N/A
Not rated
Side barrier and pole crash-test rating.
Rollover Resistance N/A
Not rated
Static stability factor + dynamic rollover test rating.
Rollover Risk N/A
Not reported
NHTSA single-vehicle rollover probability, dynamic test.
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SUSPENSION | 1 |
Recalls (1)
10V47200008/10/2010
ENGINE AND ENGINE COOLING
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 FREIGHTLINER BUSINESS CLASS M2, CUSTOM CHASSIS MT45, S2 CHASSIS, AND STERING ACTERRA VEHICLES MANUFACTURED FROM OCTOBER 5, 2006, THROUGH MAY 24, 2010, EQUIPPED WITH EPA 2007 MBE 900 DETROIT DIESEL ENGINES. ENGINE SOFTWARE MAY NOT REA
Recent Complaints
20100216SUSPENSION
I HAVE A FREIGHTLINER STEP VAN AND I WORK FOR FEDEX. I BOUGHT THIS VAN BRAND NEW ALMOST TWO YEARS AGO AND EVER SINCE I STARTED DRIVING IT I NOTICED THAT THE SUSPENSION WAS TERRIBLE. THE VEHICLE PUSH AND PULLS ALL OVER THE ROAD, THE FRONT END MAKES NOISES LIKE SOMETHING IS LOOSE, AND IT SWAYS ALL OVER THE ROAD. I HAVE BEEN IN CONTACT WITH CORPORATE FREIGHTLINER AND THEY DID CHANGE THE FRONT LEAF SPRINGS(SO CALLED FLAT STYLE LEAF SPRING). IT MADE A LITTLE IMPROVEMENT, BUT THE NOISES STILL PERSIST AND IT STILL IS ALL OVER THE ROAD. THIS VAN DOES THINGS THAT I NEVER THOUGHT A VAN COULD DO. THE VAN ALSO HAS A WOBBLE TO IT SINCE THE BEGINNING AND THE FRONT END SHAKES AT AROUND 50MPH. I HAVE HAD THIS VEHICLE TO THE DEALER FIVE TIMES, BUT I AM TOLD THAT NOTHING IS WRONG. I HAVE OFFERED CORPORATE FREIGHTLINER A CHANCE TO SPEND A DAY WITH ME AND HAVE ONE OF THEIR ENGINEERS DRIVE IT, BUT WAS NEVER TAKEN UP ON THE OFFER. I HAVE SAID TO CORPORATE, THAT THIS VAN IS A NIGHTMARE. I HAD A P10
Compare 2008FreightlinerMT-45 to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Vehicle Safety Guides
Frequently Asked Questions
How many complaints does the 2008 Freightliner MT-45 have?▼
The 2008 Freightliner MT-45 has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2008 Freightliner MT-45?▼
Yes, the 2008 Freightliner MT-45 has 1 recall(s). The most common affected component is ENGINE AND ENGINE COOLING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2008 Freightliner MT-45?▼
The most-complained component for the 2008 Freightliner MT-45 is SUSPENSION with 1 complaints. Other frequently reported areas include various components.
Is the 2008 Freightliner MT-45 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2008 Freightliner MT-45; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.