Total Complaints
2 filings
FREIGHTLINER MT-45 · model year
2002 FREIGHTLINER MT-45
2 NHTSA complaints, and 1 recall campaign listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2002FREIGHTLINERMT-45 carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2002 MT-45 is structure:body:hood with 2 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 1 NHTSA recall campaign listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 38 investigation files overlapping the 2002 MT-45. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| STRUCTURE:BODY:HOOD | 2 |
Recalls (1)
05V13800005/04/2005
EQUIPMENT:OTHER:LABELS
CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SING
Recent Complaints
20040603STRUCTURE:BODY:HOOD
INQUIRING ABOUT SAFETY RECALLS ON A 2002 18FT FREIGHTLINER CUSTOM CHASSIS MT45 STEP VAN AND REPORTING A PROBLEM WITH THE HOOD OF HIS VEHICLE. * CB *JB
20030327STRUCTURE:BODY:HOOD
THE HOOD OF THE VEHICLE IS POORLY CONSTRUCTED. THE HOOD NEVER SHUTS IN THE SAME PLACE TWICE AND THIS MAKES IT IMPOSSIBLE TO ADJUST THE HEADLIGHTS. THE HOOD ALSO KEEPS GETTING PULLED BY THE STRAPS MEANT TO HOLD IT DOWN. *MR *NLM *NLM
Compare 2002FREIGHTLINERMT-45 to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 2002 FREIGHTLINER MT-45 have?▼
The 2002 FREIGHTLINER MT-45 has 2 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2002 FREIGHTLINER MT-45?▼
Yes, the 2002 FREIGHTLINER MT-45 has 1 recall(s). The most common affected component is EQUIPMENT:OTHER:LABELS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2002 FREIGHTLINER MT-45?▼
The most-complained component for the 2002 FREIGHTLINER MT-45 is STRUCTURE:BODY:HOOD with 2 complaints. Other frequently reported areas include various components.
Is the 2002 FREIGHTLINER MT-45 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2002 FREIGHTLINER MT-45; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.