Total Complaints
2 filings
FREIGHTLINER FS-65 · model year
1998 FREIGHTLINER FS-65
2 NHTSA complaints. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 1998FREIGHTLINERFS-65 carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 2 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 1998 FS-65 is engine and engine cooling:engine:diesel with 1 filings, followed by electrical system (1). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause.
NHTSA currently has 38 investigation files overlapping the 1998 FS-65. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
2
Complaints
0
Crashes
2
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 1 |
| ELECTRICAL SYSTEM | 1 |
Recent Complaints
20120223FireENGINE AND ENGINE COOLING:ENGINE:DIESEL
NORTH CAROLINA PUBLIC SCHOOL BUS LOCATED IN MECKLENBURG COUNTY WAS IN ROUTE WITH SIX CHILDREN AND A DRIVER WHEN THE DRIVER SMELLED SMOKE AND SAW THE SMOKE COMING FROM THE AREA BELOW THE STEERING COLUMN. THE DRIVER STOPPED THE BUS IN A SAFE AREA AND IMMEDIATELY STARTED EVACUATION PROCEDURES AND SUCCESSFULLY UNLOADED THE CHILDREN TO A SAFE PLACE. WITHIN APPROXIMATELY 5 TO 7 MINUTES AFTER EVACUATION FIRE WAS SEEN IN THE PASSENGER COMPARTMENT AND PROCEEDED TO SPREAD THROUGH OUT THE INSTRUMENT PANEL AREA AND THEN TO THE REAR OF THE BUS BODY. THE BUS WAS TOTALLY DESTROYED BY THE FIRE. INDEPENDENT INVESTIGATION WAS CONDUCTED WITH PRELIMINARY INDICATION THAT FIRE ORIGINATED IN THE ENGINE COMPARTMENT NEAR THE REAR OF ENGINE WHERE WIRING HARNESS IS ROUTED AROUND METALLIC HEATER SHUTOFF VALVE. THERE APPEARS TO HAVE BEEN AN ELECTRICAL SHORT WHERE THE INTAKE HEATER WIRE CHAFFED THROUGH THE WIRE HOUSING AND CONVOLUTED TUBING FROM RUBBING THE HEATER VALVE CREATING A SHORT TO THE HEATER VALVE WHICH IS
Mileage: 188,497
20120223FireELECTRICAL SYSTEM
NORTH CAROLINA PUBLIC SCHOOL BUS LOCATED IN MECKLENBURG COUNTY WAS IN ROUTE WITH SIX CHILDREN AND A DRIVER WHEN THE DRIVER SMELLED SMOKE AND SAW THE SMOKE COMING FROM THE AREA BELOW THE STEERING COLUMN. THE DRIVER STOPPED THE BUS IN A SAFE AREA AND IMMEDIATELY STARTED EVACUATION PROCEDURES AND SUCCESSFULLY UNLOADED THE CHILDREN TO A SAFE PLACE. WITHIN APPROXIMATELY 5 TO 7 MINUTES AFTER EVACUATION FIRE WAS SEEN IN THE PASSENGER COMPARTMENT AND PROCEEDED TO SPREAD THROUGH OUT THE INSTRUMENT PANEL AREA AND THEN TO THE REAR OF THE BUS BODY. THE BUS WAS TOTALLY DESTROYED BY THE FIRE. INDEPENDENT INVESTIGATION WAS CONDUCTED WITH PRELIMINARY INDICATION THAT FIRE ORIGINATED IN THE ENGINE COMPARTMENT NEAR THE REAR OF ENGINE WHERE WIRING HARNESS IS ROUTED AROUND METALLIC HEATER SHUTOFF VALVE. THERE APPEARS TO HAVE BEEN AN ELECTRICAL SHORT WHERE THE INTAKE HEATER WIRE CHAFFED THROUGH THE WIRE HOUSING AND CONVOLUTED TUBING FROM RUBBING THE HEATER VALVE CREATING A SHORT TO THE HEATER VALVE WHICH IS
Mileage: 188,497
Compare 1998FREIGHTLINERFS-65 to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 1998 FREIGHTLINER FS-65 have?▼
The 1998 FREIGHTLINER FS-65 has 2 NHTSA complaints, 0 crashes, 2 fires, 0 injuries, and 0 deaths reported.
What are the most common problems with the 1998 FREIGHTLINER FS-65?▼
The most-complained component for the 1998 FREIGHTLINER FS-65 is ENGINE AND ENGINE COOLING:ENGINE:DIESEL with 1 complaints. Other frequently reported areas include ELECTRICAL SYSTEM.
Is the 1998 FREIGHTLINER FS-65 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 1998 FREIGHTLINER FS-65; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.