Total Complaints
41 filings
FREIGHTLINER FREIGHTLINER · model year
2001 FREIGHTLINER FREIGHTLINER
41 NHTSA complaints, and 1 recall campaign listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2001FREIGHTLINERFREIGHTLINER carries 41 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 1 fatality. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2001 FREIGHTLINER is fuel system, gasoline:delivery with 16 filings, followed by suspension:front:springs:leaf spring assembly:hanger,bracket (4) and tires (2). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 1 NHTSA recall campaign listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 35 investigation files overlapping the 2001 FREIGHTLINER. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
41
Complaints
0
Crashes
0
Fires
0
Injuries
1
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| FUEL SYSTEM, GASOLINE:DELIVERY | 16 |
| SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET | 4 |
| TIRES | 2 |
| UNKNOWN OR OTHER | 2 |
| SUSPENSION:FRONT | 2 |
| SERVICE BRAKES, AIR | 2 |
| SUSPENSION:FRONT:SPRINGS:COIL SPRINGS | 1 |
| ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| STEERING: STEERING WHEEL/HANDLE BAR | 1 |
| STEERING | 1 |
| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | 1 |
| VEHICLE SPEED CONTROL | 1 |
| STRUCTURE:BODY:HOOD | 1 |
| STRUCTURE | 1 |
| VISIBILITY:WINDSHIELD | 1 |
Recalls (1)
05V20700027/04/2005
ENGINE AND ENGINE COOLING
CERTAIN MY 2000-2003 FREIGHTLINER, THOMAS MVP SCHOOL BUS AND WESTERN STARS TRUCKS MANUFACTURED BETWEEN NOVEMBER 19, 2000, AND MARCH 30, 2005, AND EQUIPPED WITH WEBASTO COOLANT HEATERS, MODEL DBW 2010, ASSEMBLED WITH WEBASTO BURNER TUBES, P/N 303046/26533A. THE STAINLESS STEEL BURNER TUBE IS MADE O
Recent Complaints
20070627FatalUNKNOWN OR OTHER
TL*THE CONTACT OWNS A 2001 FREIGHTLINER. THE VEHICLE RAN OFF THE ROAD DURING ICY CONDITIONS. THE VEHICLE WAS NOT TAKEN TO THE MECHANIC. A POLICE REPORT WAS FILED. THE FAILURE RESULTED IN AN INJURY AND A DEATH. NO OTHER VEHICLE INFORMATION IS AVAILABLE. THE CONSUMER STATED THE DRIVER DIED IN THE ACCIDENT AND NO OTHER PASSENGERS WERE IN THE TRAILER. THE CONSUMER STATED THE DRIVER WAS UNDERNEATH THE PASSENGER SEAT. THE CONSUMER PROVIDED PICTURES OF THE DECEASED AND THE TRAILER. THE CONSUMER STATED US EXPRESS WILL NOT PROVIDE ANY INFORMATION ON THE TRAILER. UPDATED 09/05/07 *TR
Mileage: 100,000
20030630SERVICE BRAKES, AIR
THE REMEDY FOR THE SERVICE BRAKE RECALL 93 V 104 000 FAILED 15 TIMES. THE DEALERSHIP WAS UNABLE TO CORRECT THE PROBLEM. MODEL F160.*AK *TS *JB
20030630SERVICE BRAKES, AIR
THE REMEDY FOR THE SERVICE BRAKES RECALL 93 V 104 000 FAILED 6 TIMES. THE DEALERSHIP WAS UNABLE TO CORRECT THE PROBLEM. MODEL # F160. *AK *SCC *JB
20021016SUSPENSION:REAR
THE EXHAUST SYSTEM WAS ROUTED SO THAT IT WAS IN CONTACT WITH THE REAR AIR SPRING SUSPENSION. OVER TIME THE HEAT FROM THE EXHAUST PIPE BURNED A HOLE IN AIR SPRING BAG. IN OUR CASE THE FAILURE WAS NOT CASTASTROPHIC. WE WERE PARKED AND AIR LOSS WAS SLOW. I HAVE CONCERNS THAT UNDER DRIVING CONDITIONS THE AIR LOSS COULD HAVE BEEN MORE RAPID AND HANDLING COMPROMISED. I HAVE PICTURES OF THE ROUTING AND THE FAILED COMPONENT. M
20020917TIRES
WHILE DRIVING, THE RIGHT STEER TIRE DETACHED FROM THE VEHICLE, CAUSING DAMAGE TO THE FENDER AND BRAKES, OHIO TRAFFIC CRASH REPORT. *SLC
20020514SUSPENSION:FRONT
THE CONSUMER STATES THAT THE UNIT WAS TOO HAZARDOUS TO DRIVE BECAUSE IT SUDDENLY BEGINS TO SWAY SIDE TO SIDE. *YH
20020222SUSPENSION:FRONT
THE CONSUMER STATES THAT THE UNIT WAS TOO HAZARDOUS TO DRIVE BECAUSE IT SUDDENLY BEGINS TO SWAY SIDE TO SIDE. *YH
20011128TIRES
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128STEERING: STEERING WHEEL/HANDLE BAR
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128STEERING
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128VEHICLE SPEED CONTROL
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128UNKNOWN OR OTHER
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128STRUCTURE:BODY:HOOD
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128STRUCTURE
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128VISIBILITY:WINDSHIELD
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128WHEELS
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011128SUSPENSION
TRUCK WONDERS ON ROAD, DEALER BELIEVES THAT TIRES ARE THE SOURCE OF PROBLEM. *AKCONSUMER STATED THE ABS LIGHT COMES ON, THE FRONT WHEEL SENSOR WAS OUT OF ADJUSTMENT, DEALER FOUND THE SENSOR DISC ON LEFT FRONT WHEEL HAD BEEN BENT UPON ASSEMBLY OF THE WORK, SHIMS FELL OUT FROM UNDER THE RUBBER CONE FOR THE HOOD MOUNT ON THE DRIVERS SIDE WHICH CAUSED THE HOOD TO SAG AND RUBBED PAINT OFF OF THE COWL AND THE INSULATION UNDER THE HOOD STARTED COMING LOOSE AND IT HANGS DOWN ON TO THE ENGINE, THE CAB LEAKS WATER CAUSING THE WATER TO LAY AROUND THE FLOOR, THE PASSENGER SIDE WINDOW LEAKS WATER FROM THE TOP AND ALSO THE DRIVERS SIDE WINDOW AND THE BUNK DOOR LEAKS AIR AND SOUND AS THOUGH THEY ARE OPEN, THE DASH APART THREE TIMES AND IT RATTLES, DEALER REPLACED DASH LIGHTS AND FLASHER RELAY, AFTER STARTING THE ENGINE AND TURNING OFF THE KEY, ENGINE STOPS BUT STARTER CONTINUED TO RUN, FRONT CRANKSHAFT SEAL ON THE ENGINE STARTED TO LEAK MOTOR OIL, THE OIL SLUNG ALL OVER THE FRONT OF ENGINE, BATTERY,
20011106FUEL SYSTEM, GASOLINE:DELIVERY
#1 FUEL LINE BRAKES HIGH PRESSURE FUEL SPARYS OVER HOT EXHAUST MANIFOLD MAY CAUSE FIRE CHILDREN ON SCHOOLBUS FUEL ON GROUND
Compare 2001FREIGHTLINERFREIGHTLINER to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
PE18004Preliminary EvaluationClosed
PNDB Electrical Power Distribution
Frequently Asked Questions
How many complaints does the 2001 FREIGHTLINER FREIGHTLINER have?▼
The 2001 FREIGHTLINER FREIGHTLINER has 41 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 1 deaths reported.
Are there any recalls for the 2001 FREIGHTLINER FREIGHTLINER?▼
Yes, the 2001 FREIGHTLINER FREIGHTLINER has 1 recall(s). The most common affected component is ENGINE AND ENGINE COOLING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2001 FREIGHTLINER FREIGHTLINER?▼
The most-complained component for the 2001 FREIGHTLINER FREIGHTLINER is FUEL SYSTEM, GASOLINE:DELIVERY with 16 complaints. Other frequently reported areas include SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET and TIRES.
Is the 2001 FREIGHTLINER FREIGHTLINER safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2001 FREIGHTLINER FREIGHTLINER; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.