Total Complaints
1 filings
FREIGHTLINER FLA · model year
1991 FREIGHTLINER FLA
1 NHTSA complaints, 1 crash report for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 1991FREIGHTLINERFLA carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 1 crash, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 1991 FLA is service brakes, air with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability.
NHTSA currently has 38 investigation files overlapping the 1991 FLA. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
1
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
1 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES, AIR | 1 |
Recent Complaints
19951026CrashSERVICE BRAKES, AIR
THE RIGHT FRONT ROCKWELL BRAKE PULLS TO THE RIGHT. TT CONSUMER STATES THE RIGHT FRONT BRAKES WERE HOTTER THAN THE OTHER BRAKES, DEALER REPLACED RIGHT FRONT BRAKE SHOES, PROBLEM CAME BACK AND DEALER REPLACED RELAY VALVE, LEFT AND RIGHT FRONT SHOES AND DRUMS, HAD TO HAVE FRONT AND REAR AXLES REALIGNED, WHILE TRAVELING ON A WET ROAD, CONSUMER LOST TRACTION AND WENT TO THE LEFT, HE APPLIED BRAKES AND VEHICLE PULLED HARD TO THE RIGHT CAUSING TRUCK TO JACK KNIFE, CONSUMER STATES PROBLEM IS IN THE FRONT BRAKES. *SLC
Compare 1991FREIGHTLINERFLA to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 1991 FREIGHTLINER FLA have?▼
The 1991 FREIGHTLINER FLA has 1 NHTSA complaints, 1 crashes, 0 fires, 0 injuries, and 0 deaths reported.
What are the most common problems with the 1991 FREIGHTLINER FLA?▼
The most-complained component for the 1991 FREIGHTLINER FLA is SERVICE BRAKES, AIR with 1 complaints. Other frequently reported areas include various components.
Is the 1991 FREIGHTLINER FLA safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.