2007 FREIGHTLINER COLUMBIA

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT

ENGINE AND ENGINE COOLING

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FREIGHTLINER, FCCC, STERLING, AND WESTERN STAR HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL

SUSPENSION:REAR

ON CERTAIN TRUCKS EQUIPPED WITH TUFTRAC REAR SUSPENSIONS, THE CENTER CASTING BRACKETS MAY BE OUT OF SPECIFICATION. AN OUT OF SQUARE CASTING MAY HAVE UNACCEPTABLE STRESS IN THE BRACKET WHEN IT IS INSTALLED AND MAY CAUSE IT TO CRACK IN SERVICE.

ENGINE AND ENGINE COOLING

DAIMLER TRUCKS IS RECALLING MODEL YEAR 2004-2010 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINE. THE VARIABLE VALVE ACTUATION OIL LINE MAY RUB AGAINST THE P-CLIPS RETAINING THE OIL LINE, CAUSING AN OIL LEAK.

STEERING

FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE

FUEL SYSTEM, DIESEL

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE

STEERING:RACK AND PINION

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 HEAVY DUTY TRUCKS MANUFACTURED FROM OCTOBER 29, 2005 THROUGH JULY 3, 2009. UNDER CERTAIN CONDITION, THE LEFT HAND INNER TIE ROD END MAY LOOSEN OVER TIME AND IF NOT CORRECTED, POTENTIALLY SEPARATE FROM THE STEERING RACK.

SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRI

EQUIPMENT

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers tha

SERVICE BRAKES, AIR:SUPPLY:RESERVOIR/TANK

Daimler Trucks North America LLC (DTNA) is recalling certain 2004-2019 Freightliner 108SD, 114SD, 122SD, Cascadia, Columbia, Classic, FL80, FLD 120SD, Business Class M2, Western Star 4700, 4900, 6900, Sterling Acterra, L7500, LT7500, L8500, LT8500, L9500, and LT9500 vehicles. The vehicles may have

EXTERIOR LIGHTING

Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Ca

TRAILER HITCHES:FIFTH WHEEL ASSEMBLY

ON CERTAIN TRUCK-TRACTORS EQUIPPED WITH HOLLAND SIMPLEX SE OR SE II FIFTH WHEELS, THE LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER-TIGHTENED WHICH COULD DISTORT THE PIVOT BOLT SPACER SLEEVE. CORROSION OR CONTAMINATES IN THE PIVOT MAY CAUSE IT TO BIND AND PREVENT THE FIFTH WHEEL JAW FROM LATCH

STEERING:RACK AND PINION

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005-2011 FREIGHTLINER CASCADIA, COLUMBIA, CENTURY, CORONADO, AND CLASSIC XL TRUCKS MANUFACTURED FROM NOVEMBER 1, 2004, THROUGH JUNE 15, 2010 FOR THE RACK AND PINION STEERING SYSTEM. THE LOWER PINION BEARING MAY CORRODE AND FAIL. A FAILED BEARING MAY

STEERING:COLUMN

ON CERTAIN TRUCKS BUILT WITH A TRW GLOBAL ADJUSTABLE UPPER STEERING COLUMN, TWO UPPER TILT PLATE BOLTS MAY LOOSEN WITH USE AND FALL OUT. THESE FASTENERS HOLD THE UPPER COLUMN ASSEMBLY IN PLACE. THE STEERING COLUMN PIVOT MAY FRACTURE IF THE BOLTS ARE MISSING WHEN AN EXCESSIVE FORCE IS APPLIED TO TH

PARKING BRAKE:CONVENTIONAL:AIR

CERTAIN HEAVY TRUCKS, SHUTTLE BUSES, AND SCHOOL BUSES EQUIPPED WITH BENDIX MODULATED SPRING BRAKE VALVES. A DEFECT IN THE MODULATED SPRING BRAKE VALVE CASTING MAY CAUSE AN INTERMITTENT DELAY IN THE APPLICATION OF THE PARK BRAKE.

SUSPENSION:FRONT:HUB

ON CERTAIN TRUCKS BUILT WITH FRONT AXLES ASSEMBLED BY ARVINMERITOR, THE FRONT SPINDLE NUT MAY BE OVER-TIGHTENED CAUSING PRELOAD ON THE FRONT WHEEL BEARINGS WHICH COULD LEAD TO PREMATURE BEARING WEAR.

POWER TRAIN:DRIVELINE

ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE CASTING AND EVENTUALLY CAUSE THE EAR WOR

FUEL SYSTEM, DIESEL

DAIMLER TRUCKS IS RECALLING 62,000 MY 2005-2007 FREIGHTLINER BUSINESS CLASS, CENTURY CLASS, COLUMBIA, CORONADO, FLD, CLASSIC, STERLING A-LINE, L-LINE, AND WESTERN STAR 4900 TRUCKS. A FRACTURED FUEL LINE COULD LEAK DIESEL FUEL.

ENGINE AND ENGINE COOLING

DAIMLER TRUCKS IS RECALLING MODEL YEAR 2007-2010 FREIGHTLINER, STERLING AND WESTERN STAR VEHICLES EQUIPPED WITH DETROIT DIESEL DD15 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GR

ELECTRONIC STABILITY CONTROL (ESC)

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006-2012 FREIGHTLINER BUSINESS CLASS M2, CASCADIA, CENTURY, COLUMBIA, CORONADO AND STERLING A-LINE VEHICLES BUILT WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) SYSTEM MANUFACTURED FROM SEPTEMBER 15, 2005 THROUGH SEPTEMBER 1, 2011. UNDER CERTAI

POWER TRAIN:AXLE ASSEMBLY

ON CERTAIN TRUCKS BUILT WITH DANA REAR AXLES, THE HOUSINGS MAY CONTAIN THINNER MATERIAL THAN WHAT IS NECESSARY FOR NORMAL VEHICLE OPERATION.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 HEAVY TRUCKS MANUFACTURED BETWEEN JANUARY 17, 2006 AND MARCH 31, 2009, EQUIPPED WITH EPA07 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES. THE PLASTIC LINES MAY EXPERIENCE LEAKS DUE TO FATIGUE CRACKS CAUSED BY STRESS

STEERING:LINKAGES:TIE ROD ASSEMBLY

ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD SOCKET ATTACHMENT TO THE STEERING RACK ON

STEERING:LINKAGES:TIE ROD ASSEMBLY

ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

ENGINE AND ENGINE COOLING

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 FREIGHTLINER, CASCADIA, CENTURY, COLUMBIA FLD, AND M2, STERLING 9500, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM MARCH 20, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE4000 EPA07 MODEL ENGINES. THE INTAKE AI

SUSPENSION:FRONT

ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR FRONT AXLE ASSEMBLIES, THE FRONT SPINDLE NUT MAY BE OVER-TIGHTENED CAUSING PRELOAD ON THE FRONT WHEEL BEARINGS WHICH MAY LEAD TO PREMATURE BEARING WEAR.

FUEL SYSTEM, GASOLINE:DELIVERY

ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANG

THE VIN LAST 6: [XXX] ; ZF MERIT OR,12 SPEED AUTOMATIC TRANSMISSION THE CENTER CARRIER BEARING WHICH SUPPORTS THE OUTPUT SHAFT AFTER THE TRANSMISSION DID NOT LAST MORE THAN 3 YEARS AND HAD EXCESSIVE PLAY. THE FIRST REPAIR INVOICE WAS ON 3/1/2012 AND THE MOST RECENT REPAIR WAS ON 4/28/2014. THE RUBBER COMPOUND USED IN THE CENTER CARRIER BEARING NEEDS TO BE REEVALUATED. ONCE THE CENTER CARRIER BEARING HAS PLAY IN THE Z DIRECTION, THERE WOULD BE EXCESSIVE VIBRATION THAT CAN FATIGUE OTHER COMPONENTS AND CAUSE FAILURE BY INITIATING A FATIGUE CRACK AND PROPAGATING DUE TO CYCLIC STRESSES. MERITOR SHOULD REEVALUATE THE RELIABILITY OF THEIR CENTER CARRIER ASSEMBLY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

TL* THE CONTACT OWNS A 2007 FREIGHTLINER COLUMBIA 120 TRUCK. THE CONTACT STATED THAT THE WATER FROM THE FRONT WINDSHIELD WIPERS WOULD OBSTRUCT HIS VIEW WHENEVER IT WAS RAINING AND WATER WAS ON THE OUTSIDE REARVIEW MIRRORS. THE VEHICLE HAD NOT BEEN DIAGNOSED AND THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 1,000,000. UPDATED 06/15/10 *BF UPDATED 07/14/10.*JB

Mileage: 100,000

TL* THE CONTACT OWNS A 2007 FREIGHTLINER COLUMBIA. UPON ATTEMPTING TO START THE VEHICLE, THE VEHICLE WOULD NOT RESPOND. THE DEALER REPLACED THE STARTER AND POWER STEERING PUMP IN AN ATTEMPT TO CORRECT THE FAILURE. THE FAILURE PERSISTED. THE CURRENT AND FAILURE MILEAGES WERE 413,238.

Mileage: 413,238

2007 FREIGHTLINER COLUMBIA DASH BOARD INSTRUMENT UNIT OWN TRUCK FOR 3 YEARS AND I AM ON MY 3RD ONE, AND LOW VOLTGE SHUT DOWN, SHUTS DOWN ALL NON PRIMARY ELECTRICAL STUFF, THEY FREIGHTLINER DISCONNECTED IT AND ITS NEVER BEEN FIX, CAUSE THEY COULD NOT FIND THE PROBLEM, I THINK THAT THERE IS AN ELECTRICAL PROBLEM WITH THIS YEAR TRUCK. *TR

WIPERS ON LOWEST INTERMITTENT POSITION DURING A LIGHT MIST, AFTER ABOUT 45 MINUTES IN THIS POSITION, WIPERS STOPPED SUDDENLY AND REMAINED IN THEIR "TRANSIT" POSITION. VISIBILITY IMMEDIATELY WENT TO ZERO (I WAS IN OUTSIDE LANE AND PULLED OVER TO SHOULDER.) I REPLACED THE FUSE/CIRCUIT WITH A STANDARD FUSE OF EQUAL RATING AND IT IMMEDIATELY BLEW. AFTER ABOUT THIRTY MINUTES, I RE-INSTALLED THE ORIGINAL FUSE/CIRCUIT AND THE WIPERS BEGAN WORKING. I CONTINUED WITH THE WIPERS IN THE STANDARD RUN POSITION WITH NO FURTHER PROBLEMS. ABOUT TWO MONTHS LATER DURING A SNOW STORM IN COLORADO I HAD THE WIPER IN THE LOW INTERMITTENT POSITION AND EXPERIENCED THE SAME PROBLEM. THIS RESULTED IN HAVING STOP THE VEHICLE ON THE HIGHWAY UNTIL THE WIPERS RESUMED OPERATING. THIS TIME IT TOOK ONLY A FEW MINUTES. *TR

Mileage: 141,000

ROOF LEAK THAT HAS BEEN ON GOING SINCE TAKING DELIVERY OF TRUCK BRAND NEW IN JUNE OF 2007. WHEN TRUCK IS SUBJECTED TO HEAVY RAIN, AND SOMETIMES JUST A TRUCK WASH, WATER COMES IN ROOF AT SOME POINT AND SHORTS OUT THE ELECTRONIC MODULES LOCATED IN SIDE PILLAR NEXT TO DRIVERS SEAT. HAVE ALSO HAD EPISODES WHERE THE DASH INSTRUMENTS WILL SURGE POWER ON AND OFF WITH NO KEY IN IGNITION, OR IF TRUCK IS RUNNING IT CANNOT BE SHUT OFF WITH KEY WHEN THIS HAPPENS. HAVE PUT TRUCK IN DEALER SHOP ON FOUR SEPARATE OCCASIONS TO HAVE THIS PROBLEM FIXED UNDER WARRANTY. EACH TIME THEY HAVE REPLACED THE ELECTRONIC MODULES THAT HAVE SHORTED OUT, AND THEY ACKNOWLEDGE THAT THERE IS A LEAK SOMEWHERE. HOWEVER, DEALER HAS BEEN UNABLE TO ISOLATE THE PROBLEM AND FIX IT. NOT EVEN SURE OF WHERE ELSE THE WATER IS GOING INSIDE TRUCK. ONLY KNOW ABOUT IT INSIDE PILLAR BECAUSE OF THE ELECTRONIC MODULES IT DAMAGES. TRUCK HAS SINCE STARTED TO ACQUIRE A MUSTY DAMP ODOR AND HAS GOTTEN TO THE POINT WHERE I CAN NO LONGER DRIVE

A DRIVER FOR OUR COMPANY WAS OPERATING A 2007 FREIGHTLINER CL 112 TRACTOR WITH 50,000 MILES EQUIPPED WITH A MERCEDES BENZ (MBE4000) WHEN THE ENGINE SUDDENLY CAUGHT FIRE. UNIT WAS BEING DRIVEN UNDER NORMAL OPERATING CONDITIONS WHEN SMOKE WAS SEEN COMING IN THE CAB. DRIVER PULLED THE TRUCK TO THE SHOULDER OF THE ROAD AND FLAMES WERE COMING OUT FROM UNDER THE HOOD. DRIVER TRIED TO PUT THE FIRE OUT WITH A FIRE EXTINGUISHER BUT WAS UNABLE TO CONTAIN IT. THE FIRE DEPT WAS CALLED AND DID PUT THE FIRE OUT. THE TRACTOR WAS COMPLETELY DESTROYED. AT THIS TIME NO CAUSE FOR THE FIRE HAS BEEN DETERMINED. *JB

Mileage: 50,000

I FEEL THAT THERE SHOULD BE A RECALL FOR A SAFETY RELATED ISSUES WITH A 5TH WHEEL ON HEAVY TRUCKS. I HAVE MORE LOTS MORE INFORMATION THAT I CAN FORWARD TO YOU. OVER 300 VINS AND A LETTER FROM THE VENDOR OF THE EQUIPMENT. *TR

I FEEL THAT THERE SHOULD BE A RECALL FOR A SAFETY RELATED ISSUES WITH A 5TH WHEEL ON HEAVY TRUCKS. I HAVE MORE LOTS MORE INFORMATION THAT I CAN FORWARD TO YOU. OVER 300 VINS AND A LETTER FROM THE VENDOR OF THE EQUIPMENT. *TR

THIS IS A COMPLAINT ABOUT EXHAUST FUMES ENTERING THE CAB OF A COMMERCIAL VEHICLE. *JB

Mileage: 1

I AM A COMPANY DRIVER AND HAVE BEEN COMPLAINING OF EXHAUST FUMES IN THE TRUCK. I HAVE BEEN SLEEPING MUCH MORE THAN NORMAL 12 - 14 HRS A DAY NOW, WAKE UP SLOW WITH SICK FEELING AND VERY BAD HEADACHES. MY MEMORY AND CONCENTRATION HAVE BECOME DIMINISHED, ALONG WITH A RISE IN BLOOD PRESSURE. *JB

Mileage: 1

DT*: THE CONTACT STATED THE WINDSHIELD WIPERS OPERATED ON AN INTERMITTENT BASIS. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER TWO TIMES, BUT THE PROBLEM COULD NOT BE RECREATED. THE MANUFACTURER WAS NOT YET NOTIFIED.

Mileage: 825