2004 FREIGHTLINER COLUMBIA

ENGINE AND ENGINE COOLING

DAIMLER TRUCKS IS RECALLING MODEL YEAR 2004-2010 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINE. THE VARIABLE VALVE ACTUATION OIL LINE MAY RUB AGAINST THE P-CLIPS RETAINING THE OIL LINE, CAUSING AN OIL LEAK.

FUEL SYSTEM, DIESEL

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE

SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRI

EQUIPMENT

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers tha

POWER TRAIN:DRIVELINE

ON CERTAIN VEHICLES, THERE IS A DEFECT IN THE INTERAXLE DRIVELINE YOKES. THE BOLT HOLES LOCATED ON THE EARWORK OF THE MALE SHAFT YOKES WERE MANUFACTURED WITH AN OVERSIZED MINOR THREAD DIAMETER.

WHEELS:HUB

ON CERTAIN TRUCKS EQUIPPED WITH 3RD GENERATION CONMET ALUMINUM WHEELS, THE DRUM MOUNTING FLANGE ON THE CONMET TRUTURN BRAKE DRUM MAY HAVE BEEN MANUFACTURED WITH A TAPER FROM THE PILOT HOLE TO THE BARREL OF THE DRUM.

STEERING:LINKAGES

ON CERTAIN TRUCK AND MOTOR HOME CHASSIS EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THERE IS A POTENTIAL FOR A FAILURE OF THE FORK/SHAFT CONNECTION.

ENGINE AND ENGINE COOLING

ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE VARIABLE VALVE ACTUATION OIL LINE MAY WEAR AGAINST THE SHARP EDGE OF THE CYLINDER HEAD IF NOT POSITIONED CORRECTLY.

POWER TRAIN:MANUAL TRANSMISSION

ON CERTAIN TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, THE TAPERED JOINT THAT ATTACHES THE SHIFTER TO THE TRANSMISSION MAY BECOME LOOSE MAKING IT DIFFICULT TO PUT THE TRANSMISSION INTO GEAR.

SEATS

ON CERTAIN TRUCKS EQUIPPED WITH SEATS BUILT BY GRA-MAG, THE SEAT PIVOT BOLTS CAN LOOSEN AND POSSIBLY FRACTURE OR DISLODGE, CAUSING THE SEAT BACK TO FAIL TO PROVIDE FULL SUPPORT TO THE DRIVER'S BACK.

PERSONAL FRIEND/TRUCK DRIVER WAS DRIVING 2004 FREIGHTLINER COLUMBIA WITH MERCEDES ENGINE ON INTERSTATE HIGHWAY. OTHER MOTORIST SAW HIM DRIVING ERRATICALLY, AND CALLED POLICE. DASH CAMERA RECORDS HIM WEAVING IN THE ROAD AND FINALLY VEERING INTO ONCOMING LANE, CRASHING INTO CONCRETE BARRIER. IMPACT WITH THE WALL CAUSES FUEL TANK TO SEPARATE FROM CAB, CAUSING SMALL FIRE WHICH DID NOT BURN DRIVER OR CAB. DRIVER WAS PRONOUNCED DEAD AT THE SCENE. AUTOPSY REVEALED SIGNIFICANTLY HIGH LEVEL OF CO IN

2004 FREIGHTLINER COLUMBIA CONVENTIONAL TIRE BLOW OUT. CONSUMER STATED THAT WHEN THE TIRE BLEW OUT IT CAUSED THE SECOND TRAILER TO HIT A GUARDRAIL IN TWO LOCATIONS. *KB OHIO TRAFFIC CRASH REPORT # 10-0013-89. *JB

2004 FREIGHTLINER COLUMBIA CAUGHT FIRE UNDER THE HOOD. *KB ACCORDING TO THE REPORT, THE FIRE STARTED DUE TO A POSSIBLE SHORT IN THE WRING. OHIO TRAFFIC CRASH REPORT *JB

I HAVE A FREIGHTLINER COLUMBIA WITH A MBE 4000 MERCEDES ENGINE. THIS IS THE SECOND TIME I HAD TO PUT THE TRUCK IN A SHOP FOR AN EXHAUST LEAK. THIS TIME THE EXHAUST MANIFOLD WAS LEAKING FUMES INTO THE CAB AND MADE ME SICK WITH CARBON MONOXIDE. TOOK TRUCK TO PENN DETROIT DIESEL IN YORK HAVEN,PA. THEY FOUND THAT THE EXHAUST MANIFOLD WAS OFF ON PORT #1 AND #2 BY 1/16 INCH THERE BY ALLOWING EXHAUST FUMES TO ESCAPE AND ENTER THE CAB THROUGH THE FRESH AIR VENT THAT IS UNDER THE HOOD OF THE TRUCK. T

Mileage: 295,400

SUSPECT CARBON MONOXIDE ENTERING THROUGH VENTS MAKING ME ILL HAVING HEADACHES ,EYE INFECTIONS AND CHEST PAINS SHORTNESS OF BREATH, FATIGUE BLURRED VISION. CHECKED LEVELS OF CARBON MONOXIDE UP TO 31, COMING THROUGH AIR VENTS. *JB

Mileage: 300,000

HAVING HEALTH ISSUES, HEADACHES, BLURRED VISION, INFECTION IN EYE, FATIGUE, HARD BREATHING, CHEST PAINS, DID TEST FOR CARBON MONOXIDE LEVELS OF 31,J UST SITTING, NO OTHER VEHICLES AROUND WHILE TESTING. BEEN ILL FOR A LONG TIME. CAN TASTE THE FUMES COMING IN. THESE FUMES COMING THROUGH THE AIR CONDITION VENTS. MERCEDES ENGINE. *JB

Mileage: 300,000

CARBON MONOXIDE LEAKAGE INTO CAB FROM HEATER/AIR CONDITIONING SYSTEM ON FREIGHTLINER COLUMBIA TRUCKS WITH DETROIT EGR (EPA COMPLIANT) ENGINES ABOUT 2003 AND NEWER. CARBON MONOXIDE RESULTED IN ELEVATED BLOOD PRESSURE, NAUSEA, FLU LIKE SYMPTOMS, HEADACHES, TIREDNESS, ETC.. TRUCK HAS BEEN WORKED ON 5 TIMES FOR THIS PROBLEM, NUMEROUS PARTS HAVE BEEN REPLACED. HAS NOT CORRECTED THE PROBLEM, OR ONLY FOR A SHORT WHILE. PROBLEM EXISTS IN SEVERAL AREAS AND IS NOT READILY APPARENT WHEN DOING IN SHOP TEST

Mileage: 150,000

CARBON MONOXIDE LEAKAGE INTO CAB FROM HEATER/AIR CONDITIONING SYSTEM ON FREIGHTLINER COLUMBIA TRUCKS WITH DETROIT EGR (EPA COMPLIANT) ENGINES ABOUT 2003 AND NEWER. CARBON MONOXIDE RESULTED IN ELEVATED BLOOD PRESSURE, NAUSEA, FLU LIKE SYMPTOMS, HEADACHES, TIREDNESS, ETC.. TRUCK HAS BEEN WORKED ON 5 TIMES FOR THIS PROBLEM, NUMEROUS PARTS HAVE BEEN REPLACED. HAS NOT CORRECTED THE PROBLEM, OR ONLY FOR A SHORT WHILE. PROBLEM EXISTS IN SEVERAL AREAS AND IS NOT READILY APPARENT WHEN DOING IN SHOP TEST

Mileage: 150,000

OUR COMPANY HAS A FLEET OF 2004 FREIGHTLINERS COLUMBIA CABS SEMI-TRACTORS, WHILE I WAS IN OUR REPAIR SHOP THIS LAST WEEKEND, THEY HAD A TRUCK ISOLATED, BECAUSE A DRIVER HAD DIED IN IT. COD HAS NOT BEEN DETERMINED AT THIS POINT. WE HAVE HAD SEVERAL ROLLOVER ACCIDENTS IN THESE TRUCKS, AND I HAVE TALKED TO NUMEROUS DRIVERS ABOUT EXHAUST LEAKS. OUR COMPANY IS NOW IN THE PROCESS OF INSTALLING CARBON MONOCIDE DETECTORS IN THESE NEW TRUCKS. MY CONCERN IS, HOW MANY UNEXPLAINABLE ACCIDENTS ARE WE GONING