Total Complaints
1 filings
FREIGHTLINER CLASSIC · model year
2007 FREIGHTLINER CLASSIC
1 NHTSA complaints, and 6 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2007FREIGHTLINERCLASSIC carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2007 CLASSIC is engine and engine cooling with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 6 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 38 investigation files overlapping the 2007 CLASSIC. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING | 1 |
Recalls (6)
07V30600018/07/2007
STEERING
FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE
07V30200016/07/2007
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRI
07V53000013/11/2007
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
ON CERTAIN TRUCK-TRACTORS EQUIPPED WITH HOLLAND SIMPLEX SE OR SE II FIFTH WHEELS, THE LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER-TIGHTENED WHICH COULD DISTORT THE PIVOT BOLT SPACER SLEEVE. CORROSION OR CONTAMINATES IN THE PIVOT MAY CAUSE IT TO BIND AND PREVENT THE FIFTH WHEEL JAW FROM LATCH
06V20500012/06/2006
PARKING BRAKE:CONVENTIONAL:AIR
CERTAIN HEAVY TRUCKS, SHUTTLE BUSES, AND SCHOOL BUSES EQUIPPED WITH BENDIX MODULATED SPRING BRAKE VALVES. A DEFECT IN THE MODULATED SPRING BRAKE VALVE CASTING MAY CAUSE AN INTERMITTENT DELAY IN THE APPLICATION OF THE PARK BRAKE.
08V11300011/03/2008
FUEL SYSTEM, DIESEL
DAIMLER TRUCKS IS RECALLING 62,000 MY 2005-2007 FREIGHTLINER BUSINESS CLASS, CENTURY CLASS, COLUMBIA, CORONADO, FLD, CLASSIC, STERLING A-LINE, L-LINE, AND WESTERN STAR 4900 TRUCKS. A FRACTURED FUEL LINE COULD LEAK DIESEL FUEL.
07V33500002/08/2007
FUEL SYSTEM, GASOLINE:DELIVERY
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANG
Recent Complaints
20071024ENGINE AND ENGINE COOLING
TL-2007 FREIGHTLINER (MODEL UNKNOWN). THE REAR DOOR HANDLE HAS OXIDATION WITH THE ALUMINUM ON THE STEEL. WHEN ATTEMPTING TO OPEN THE DOOR THE HANDLE FALLS OFF IN ONE PIECE INTO YOUR HAND. WHEN THIS OCCURS THERE IS NO WAY TO OPEN THE REAR DOOR FROM THE OUTSIDE. THE CURRENT MILEAGE WAS 34,000. THE MILEAGE AT THE TIME OF FAILURE WAS 22,000.
Mileage: 22,000
Compare 2007FREIGHTLINERCLASSIC to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 2007 FREIGHTLINER CLASSIC have?▼
The 2007 FREIGHTLINER CLASSIC has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2007 FREIGHTLINER CLASSIC?▼
Yes, the 2007 FREIGHTLINER CLASSIC has 6 recall(s). The most common affected component is STEERING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2007 FREIGHTLINER CLASSIC?▼
The most-complained component for the 2007 FREIGHTLINER CLASSIC is ENGINE AND ENGINE COOLING with 1 complaints. Other frequently reported areas include various components.
Is the 2007 FREIGHTLINER CLASSIC safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2007 FREIGHTLINER CLASSIC; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.