Total Complaints
2 filings
FREIGHTLINER BUSINESS CLASS M2 · model year
2021 FREIGHTLINER BUSINESS CLASS M2
2 NHTSA complaints, and 14 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2021FREIGHTLINERBUSINESS CLASS M2 carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2021 BUSINESS CLASS M2 is power train with 1 filings, followed by unknown or other (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 14 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.
NHTSA currently has 1 investigation file overlapping the 2021 BUSINESS CLASS M2. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| POWER TRAIN | 1 |
| UNKNOWN OR OTHER | 1 |
Recalls (14)
20V66000027/10/2020
SUSPENSION:REAR:AXLE:SPINDLE
Daimler Trucks North America LLC (DTNA) is recalling certain 2020-2021 Freightliner Cascadia, 2021 Freightliner 108SD, 114SD and Business Class M2 and Western Star 4700, 4900 and 5700 vehicles. The steer axle spindle nut snap-ring locking feature may be incorrectly installed or missing from the lef
23V29900026/04/2023
ELECTRONIC STABILITY CONTROL (ESC)
Daimler Trucks North America, LLC (DTNA) is recalling certain short wheelbase 2020-2024 Freightliner Cascadia, 2021-2024 Freightliner M2 Business Class, 2022 Western Star 4700, and 2020 Freightliner Classic Cascadia vehicles. The vehicle is equipped with an electronic stability control system and t
20V80700021/12/2020
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
Daimler Trucks North America, LLC (DTNA) is recalling certain 2021 Freightliner Custom Chassis MC, Business Class M2, Custom Chassis MBC Chassis, Custom Chassis S2 Chassis, Custom Chassis MT55 Chassis, and 2022 Custom Chassis Saf-T-Liner C2 vehicles. The hydraulic caliper tie bar support fasteners
21V01800020/01/2021
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
Daimler Trucks North America, LLC (DTNA) is recalling 2021 Western Star 4700 and 5700, Freightliner Business Class M2, Cascadia, and Custom Chassis XC Chassis vehicles manufactured with a certain steering arm configuration with air disc brakes identified by the axle assembly supplier. On certain ve
21V36900019/05/2021
STEERING:LINKAGES:TIE ROD ASSEMBLY
Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Freightliner 114SD, 122SD, Business Class M2, Cascadia, 108SD, Western Star 4900, 4700, 5700, Custom Chass RV Chassis, Custom Chass S2 Chassis, Custom Chass XC Chassis, Custom Chass XB Chassis, and Custom Chass MT Chassis. The
20V21400014/04/2020
EXTERIOR LIGHTING
Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Ca
22V91900012/12/2022
WHEELS:RIM
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2023 Freightliner 114SD, 2023 Freightliner 122SD, 2020 Western Star 4700, 2019-2022 Western Star 4900, 2019-2023 Freightliner Business Class M2, and 2021 Freightliner Cascadia vehicles. The vehicles are equipped with tires that are
21V25600012/04/2021
STEERING:LINKAGES:TIE ROD ASSEMBLY
Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Freightliner Cascadia, Business Class M2, 114SD, 108SD, 122SD, Custom Chass S2 Chassis, Custom Chass XB Chassis, Custom Chass XC Chassis, and Custom Chass MT Chassis Western Star 4700, 4900, 5700 vehicles. The steering arm and
20V46600007/08/2020
ELECTRICAL SYSTEM:WIRING
Daimler Trucks North America, LLC (DTNA) is recalling certain 2017-2021 Freightliner Business Class M2 trucks. The engine harness may contact and chafe at various locations around the air compressor and the frame rail. If the wires are damaged, they may short circuit, possibly causing an engine st
21V32600007/05/2021
FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL
Daimler Trucks North America, LLC (DTNA) is recalling certain 2018-2021 Freightliner Custom Chass XC Chassis, 108SD, Custom Chass XB Chassis, Business Class M2, 114SD, and Western Star 4700 vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel
25V76000005/11/2025
SUSPENSION:CRITICAL FASTENERS
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2026 Western Star 49X, Freightliner Business Class M2, Freightliner 114SD, Freightliner 108SD, 2021-2026 Western Star 47X, 2021-2023 Freightliner 122SD, 2022 Western Star 48X, and 2023 Western Star 4700 vehicles. The axle clamp faste
22V11800002/03/2022
SERVICE BRAKES, AIR:DRUM
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2022 Freightliner M2 vehicles. The brake drum may contact the hub assembly, causing the brake drum to crack.
22V81700001/11/2022
SERVICE BRAKES, AIR:ANTILOCK:MODULATOR
Daimler Trucks North America, LLC (DTNA) is recalling certain 2017-2023 Freightliner Cascadia, 2020-2022 Freightliner Business Class M2, and 2022 Freightliner 114SD, and 2020-2023 Western Star 49X, 2021-2023 Western Star 47X, and 2021-2022 Western Star 57X vehicles. The brake modulator valves on th
20V52700001/09/2020
ENGINE AND ENGINE COOLING
Daimler Trucks North America LLC (DTNA) is recalling certain 2018-2021 Freightliner 114SD, 108SD, and Business Class M2 vehicles. The engine harness wires may chafe at various locations around the air compressor and the frame rail. The damaged wires may short causing the engine to stall without an
Recent Complaints
20240503UNKNOWN OR OTHER
The DEF header failed on this truck and it causes the vehicle to be disabled. The DEF header is an emissions part. PART NUMBER 04-31354-004 HEADER-SSI,CONC,6 BOLT,CMNS
20230613POWER TRAIN
Meritor T-Case coating has failed internally. Coating has come off and is clogging the oil pump pick up tube. This can lead to catastrophic failure of the transfer case components.
Compare 2021FREIGHTLINERBUSINESS CLASS M2 to Similar Vehicles
NHTSA Investigations
Frequently Asked Questions
How many complaints does the 2021 FREIGHTLINER BUSINESS CLASS M2 have?▼
The 2021 FREIGHTLINER BUSINESS CLASS M2 has 2 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2021 FREIGHTLINER BUSINESS CLASS M2?▼
Yes, the 2021 FREIGHTLINER BUSINESS CLASS M2 has 14 recall(s). The most common affected component is SUSPENSION:REAR:AXLE:SPINDLE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2021 FREIGHTLINER BUSINESS CLASS M2?▼
The most-complained component for the 2021 FREIGHTLINER BUSINESS CLASS M2 is POWER TRAIN with 1 complaints. Other frequently reported areas include UNKNOWN OR OTHER.
Is the 2021 FREIGHTLINER BUSINESS CLASS M2 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology - how this data is sourced, computed, and verified.