Total Complaints
1 filings
FREIGHTLINER BUSINESS CLASS · model year
2000 FREIGHTLINER BUSINESS CLASS
1 NHTSA complaints, 1 crash report, and 9 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2000FREIGHTLINERBUSINESS CLASS carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 1 crash, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2000 BUSINESS CLASS is wheels with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 9 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 38 investigation files overlapping the 2000 BUSINESS CLASS. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
1
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
1 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| WHEELS | 1 |
Recalls (9)
03V11200021/03/2003
SUSPENSION:FRONT:HUB
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
00V22900117/08/2000
POWER TRAIN:AUTOMATIC TRANSMISSION
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, SHUTTLE BUSES, TRANSIT BUSES AND STEP VANS EQUIPPED WITH ALLISON 1000 OR 2400 SERIES TRANSMISSIONS. THESE TRANSMISSIONS CAN EXPERIENCE PARK PAWL TO REAR COVER INTERFERENCE DUE TO AN OUT OF FLATNESS CONDITION.
03V22700017/06/2003
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
ON CERTAIN TRUCK TRACTORS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.
00V08100017/03/2000
SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH DUAL LEAF SPRING TYPE AIR RIDE SUSPENSIONS AND VEHICLES BUILT WITH SINGLE LEAF SPRING TYPE AIR RIDE SUSPENSIONS. REAR SUSPENSION SPRINGS CAN FRACTURE THROUGH THE CENTER BOLT HOLE AFTER VEHICLE ASSEMBLY.
01V18900114/06/2001
SERVICE BRAKES, AIR:CONTROLS, PEDALS AND LINKAGES
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH CERTAIN HALDEX BRAKE SYSTEM TWO AND FOUR PORT RELAY VALVES. THE VALVE MAY STICK OPEN WHEN A HIGH-PRESSURE APPLICATION IS RELEASED.
00V19000110/07/2000
WHEELS:RIM
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH ACCURIDE 22.5 X 8.25 15 TUBELESS DEMOUNTABLE RIMS, PART NO. 32051. CERTAIN RIMS CONTAIN A NON-FUSION AREA IN THE BUTT-WELD OF THE MOUNTING RING. UNDER CERTAIN CIRCUMSTANCES, THE DEFECT COULD DEVELOP INTO A CRACK ON THE MOUNTING RING.
02V10800110/04/2002
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
ON CERTAIN TRUCKS EQUIPPED WITH MERITOR BRAND 12" X 4" DCM DRUM PARKING BRAKE, THE BOLTS USED TO ATTACH THE PARKING BRAKE ASSEMBLY TO THE FLANGE YOKE ARE TOO LARGE AND CAN INTERFERE WITH THE PROPER ENGAGEMENT OF THE BRAKING SYSTEM AND POSSIBLY DISENGAGE.
00V23200207/08/2000
SERVICE BRAKES, AIR:ANTILOCK
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT
00V35700003/11/2000
SERVICE BRAKES, AIR:CONTROLS, PEDALS AND LINKAGES
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE BRAKE PEDAL PUSH ROD THAT ACTIVATES THE SERVICE BRAKES COULD FRACTURE.
Recent Complaints
20170921CrashWHEELS
ON AUGUST 22, 2017, MY HUSBAND AND I WERE TRAVELING NORTHBOUND ON I-55 NEAR LITCHFIELD, ILLINOIS. A SEMI TRUCK OWNED BY ARNOLD JAMES KNAGGS OF CARSONVILLE, MICHIGAN, WAS TRAVELING SOUTHBOUND. AT APPROXIMATELY NOON ON THAT DATE, TWO WHEELS DETACHED FROM THAT TRUCK. ONE WHEEL CAME TO REST IN THE WIDE GRASSY MEDIAN; THE OTHER WHEEL BARRELED ACROSS THE MEDIAN AND STRUCK THE MINIVAN IN WHICH MY HUSBAND AND I WERE TRAVELING. ALL WINDOWS ON THE DRIVER'S SIDE SHATTERED AND THE SLIDING PASSENGER DOOR WAS RIPPED OFF THE VEHICLE. HE VAN WAS TOTALED. IF MY HUSBAND HAD NOT TAKEN EVASIVE ACTION AT THE LAST SECOND, HE WOULD HAVE BEEN SEVERELY INJURED OR KILLED. THE ILLINOIS TRAFFIC CRASH REPORT CITES PROBLEMS WITH THE TRUCK TIRES AND NOTES THAT VEHICLE CONDITION WAS THE PRIMARY CONTRIBUTORY CAUSE OF THE CRASH. THE DRIVER WAS CITED FOR DRIVING WITH A SUSPENDED CDL AND FOR DRIVING A TRUCK WITH LOOSE OR MISSING WHEEL BOLTS. THE QUESTION 'DID MOTOR CARRIER SAFETY REGULATIONS (MCS) VIOLATION CONTRIBUTE
Mileage: 102,000
Compare 2000FREIGHTLINERBUSINESS CLASS to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 2000 FREIGHTLINER BUSINESS CLASS have?▼
The 2000 FREIGHTLINER BUSINESS CLASS has 1 NHTSA complaints, 1 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2000 FREIGHTLINER BUSINESS CLASS?▼
Yes, the 2000 FREIGHTLINER BUSINESS CLASS has 9 recall(s). The most common affected component is SUSPENSION:FRONT:HUB. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2000 FREIGHTLINER BUSINESS CLASS?▼
The most-complained component for the 2000 FREIGHTLINER BUSINESS CLASS is WHEELS with 1 complaints. Other frequently reported areas include various components.
Is the 2000 FREIGHTLINER BUSINESS CLASS safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.