Total Complaints
1 filings
FREIGHTLINER ARGOSY · model year
2005 FREIGHTLINER ARGOSY
1 NHTSA complaints, and 4 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2005FREIGHTLINERARGOSY carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2005 ARGOSY is tires with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 4 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 38 investigation files overlapping the 2005 ARGOSY. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| TIRES | 1 |
Recalls (4)
09V36600023/09/2009
ENGINE AND ENGINE COOLING
DAIMLER TRUCKS IS RECALLING MODEL YEAR 2004-2010 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINE. THE VARIABLE VALVE ACTUATION OIL LINE MAY RUB AGAINST THE P-CLIPS RETAINING THE OIL LINE, CAUSING AN OIL LEAK.
07V30200016/07/2007
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRI
05V46700005/10/2005
SUSPENSION:REAR:AXLE:SPINDLE
CERTAIN 2005 THOMAS BUILT FS-65 AND C-2 SCHOOL BUSES AND 2005 FREIGHTLINER ARGOSY, COLUMBIA, CENTURY ST, AND M2 BUSINESS CLASS TRUCKS MANUFACTURED BETWEEN JUNE 4 AND JULY 8, 2005. THE SPINDLES IN THE REAR AXLE HOUSING WERE OVERHEATED DURING THE HEAT TREATMENT PROCESS. INCORRECTLY HEAT TREATED SPIN
06V19000005/06/2006
ELECTRICAL SYSTEM
ON CERTAIN TRUCKS, THE PROTECTIVE COVER FOR THE CAB POWER DISTRIBUTION MODEL (PDM) MAY BE MISSING OR IMPROPERLY INSTALLED.
Recent Complaints
20110629TIRES
2005 FREIGHTLINER SEMI, UNIT 1,2 AND 3 WERE TRAVELING WESTBOUND ON THE OHIO TURNPIKE. UNIT 2 BLEW A TIRE WHICH RESULTED IN THE MUD FLAP BRACKET SEPARATING FROM UNIT 2 AND GOING INTO THE ROADWAY. UNIT 3 STRUCK THE MUD FLAP BRACKET IN THE ROADWAY. UNIT 1 WAS STRUCK BY THE MUD FLAP AFTER IT WAS KICKED UP BY A VEHICLE THAT WAS TRAVELING IN FRONT OF UNIT 1. ALL THREE UNITS CONTINUED ON BEFORE PULLING OVER ON THE RIGHT BERM. *BF (OHIO TRAFFIC CRASH REPORT # 10-0319-90)*JB
Compare 2005FREIGHTLINERARGOSY to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 2005 FREIGHTLINER ARGOSY have?▼
The 2005 FREIGHTLINER ARGOSY has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2005 FREIGHTLINER ARGOSY?▼
Yes, the 2005 FREIGHTLINER ARGOSY has 4 recall(s). The most common affected component is ENGINE AND ENGINE COOLING. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2005 FREIGHTLINER ARGOSY?▼
The most-complained component for the 2005 FREIGHTLINER ARGOSY is TIRES with 1 complaints. Other frequently reported areas include various components.
Is the 2005 FREIGHTLINER ARGOSY safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2005 FREIGHTLINER ARGOSY; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.