Total Complaints
3 filings
FREIGHTLINER 114SD · model year
2023 FREIGHTLINER 114SD
3 NHTSA complaints, and 7 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2023FREIGHTLINER114SD carries 3 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2023 114SD is power train with 1 filings, followed by fuel/propulsion system (1) and service brakes (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 7 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 38 investigation files overlapping the 2023 114SD. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
3
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| POWER TRAIN | 1 |
| FUEL/PROPULSION SYSTEM | 1 |
| SERVICE BRAKES | 1 |
Recalls (7)
22V55400029/07/2022
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Freightliner 108SD, 114SD, Business Class M2, Cascadia, 2023 Freightliner FCCC MC, MT45, S2C 106CAB, XCM, S2RV 106CAB, XCR, XCS, and 2023 Western Star 4700, 49X, and 47X vehicles. The engine control module (ECM) may experience an in
22V72200028/09/2022
STEERING:LINKAGES:TIE ROD ASSEMBLY
Daimler Trucks North America, LLC (DTNA) is recalling certain 2022-2023 Western Star 4700 and 2023 Western Star 4900, 49X, 6900, and Freightliner 114SD vehicles. The tie rod clamps may have been improperly heat-treated, causing them to crack and allowing the tie rods to separate.
22V91900012/12/2022
WHEELS:RIM
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2023 Freightliner 114SD, 2023 Freightliner 122SD, 2020 Western Star 4700, 2019-2022 Western Star 4900, 2019-2023 Freightliner Business Class M2, and 2021 Freightliner Cascadia vehicles. The vehicles are equipped with tires that are
24V66800010/09/2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Daimler Trucks North America, LLC (DTNA) is recalling certain 2024-2025 Freightliner 108SD, 2022-2025 Freightliner 114SD, Freightliner Business Class M2, 2025 Freightliner eM2, 2020-2025 Western Star 49X, 2021-2025 Western Star 47X, and 2022-2025 Western Star 57X vehicles that may be upfitted with a
25V76000005/11/2025
SUSPENSION:CRITICAL FASTENERS
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2026 Western Star 49X, Freightliner Business Class M2, Freightliner 114SD, Freightliner 108SD, 2021-2026 Western Star 47X, 2021-2023 Freightliner 122SD, 2022 Western Star 48X, and 2023 Western Star 4700 vehicles. The axle clamp faste
23V23800004/04/2023
STEERING:LINKAGES:TIE ROD ASSEMBLY
Daimler Trucks North America, LLC (DTNA) is recalling certain 2022 FCCC Shuttle Chassis, 2022-2023 FCCC RV Chassis, FCCC Van Chassis, Van Chassis Gas, 2023 Freightliner Cascadia, Freightliner Business Class M2, Thomas Built Bus School Bus Chassis, Western Star 4700, Western Star 47X, Western Star 49
22V39400003/06/2022
STEERING
Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Freightliner M2, 108SD, and 114SD vehicles. The u-joint pinch bolt on the steering shaft may become detached, which can cause a loss of steering control.
Recent Complaints
20230329POWER TRAIN
The drive shaft fwd carrier bearing was missing 2 of the 3 bolt that hold it to the cross member. Being held with one bolt change the center line of the drive shaft moving towards the driver's side of the truck this resulted the the drive shaft rubbing on a air tank hanger. I do have pictures. It looks like the missing bolts where never installed.
20230329FUEL/PROPULSION SYSTEM
The drive shaft fwd carrier bearing was missing 2 of the 3 bolt that hold it to the cross member. Being held with one bolt change the center line of the drive shaft moving towards the driver's side of the truck this resulted the the drive shaft rubbing on a air tank hanger. I do have pictures. It looks like the missing bolts where never installed.
20230329SERVICE BRAKES
The drive shaft fwd carrier bearing was missing 2 of the 3 bolt that hold it to the cross member. Being held with one bolt change the center line of the drive shaft moving towards the driver's side of the truck this resulted the the drive shaft rubbing on a air tank hanger. I do have pictures. It looks like the missing bolts where never installed.
Compare 2023FREIGHTLINER114SD to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 2023 FREIGHTLINER 114SD have?▼
The 2023 FREIGHTLINER 114SD has 3 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2023 FREIGHTLINER 114SD?▼
Yes, the 2023 FREIGHTLINER 114SD has 7 recall(s). The most common affected component is ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM). Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2023 FREIGHTLINER 114SD?▼
The most-complained component for the 2023 FREIGHTLINER 114SD is POWER TRAIN with 1 complaints. Other frequently reported areas include FUEL/PROPULSION SYSTEM and SERVICE BRAKES.
Is the 2023 FREIGHTLINER 114SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.