Total Complaints
2 filings
FREIGHTLINER 114SD · model year
2012 FREIGHTLINER 114SD
2 NHTSA complaints, and 8 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2012FREIGHTLINER114SD carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 1 fire, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2012 114SD is electrical system with 1 filings, followed by fuel/propulsion system (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 8 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 38 investigation files overlapping the 2012 114SD. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
2
Complaints
0
Crashes
1
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ELECTRICAL SYSTEM | 1 |
| FUEL/PROPULSION SYSTEM | 1 |
Recalls (8)
18V50300031/07/2018
STEERING:LINKAGES:TIE ROD ASSEMBLY
Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2015 Freightliner Cascadia, Coronado, Business Class M2, 114SD, and Western Star 4900 trucks. In certain front axle, brake lining, and brake spider combinations, braking may cause high vibrations, resulting in early failure of the t
12V07400028/02/2012
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT
14V08000021/02/2014
ENGINE AND ENGINE COOLING:ENGINE
Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model I
21V89600017/11/2021
TIRES
Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2021 Freightliner SD 108, Freightliner SD 114, 2016-2020 Freightliner Coronado, 2013 Western Star 6900, 2013-2022 Western Star 4700, Western Star 4900, and 2022 49X vehicles. The tires and rims are not approved and rated for these v
12V40500016/08/2012
EQUIPMENT
Daimler Trucks North America (DTNA) is recalling certain model year 2009-2012 Freightliner, Sterling, and Western Star vehicles manufactured from July 7, 2008, through December 15, 2011, and equipped with perpendicular air tank mounting brackets. The air tank mounting brackets may develop cracks wh
16V20600012/04/2016
SERVICE BRAKES, AIR:DISC:CALIPER
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2010-2017 Freightliner M2 Business Class, 108SD, 114SD, and Columbia trucks manufactured from January 6, 2010, through February 29, 2016, equipped with certain Bendix rear disk brakes and spring suspensions. The rear disk brake
13V07400004/03/2013
ELECTRICAL SYSTEM
Daimler Trucks North America (DTNA) is recalling certain model year 2012-2013 Business Class M2, 108SD, 114SD vehicle chassis, manufactured from December 3, 2011, through October 12, 2012 and equipped with a SmartPlex switch hub module. Residue left over in the manufacturing process of the switch h
15V34300003/06/2015
ENGINE AND ENGINE COOLING:ENGINE
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2007-2016 Freightliner 114SD and M2 Business Class trucks, 2008-2009 Sterling LT8500 trucks and Thomas Built Bus Saf-T-Liner HDX transit buses equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pr
Recent Complaints
20160321FireFUEL/PROPULSION SYSTEM
TRUCK FIRE WITH COMPLETE DESTRUCTION DUE TO HIGH PRESSURE FUEL LINES FROM PUMP TO FUEL RAIL. P CLIPS ALLEGEDLY COMPROMISED FUEL LINE. DAIMLER HAS HAD A RECALL BUT THIS IS A DESIGN DEFECT THAT NEEDS INVESTIGATED AS THE "FIX" IS NO FIX AND FIRES CONTINUE TO OCCUR.
Mileage: 544,000
20141108ELECTRICAL SYSTEM
I WAS DRIVING EAST ON I10 WHEN THE CHECK ENGINE LIGHT CAME ON. I THEN NOTICED THE DASH PANEL GOING IN ALL DIFFERENT DIRECTIONS. THE ERROR CODE CAME UP AS J1939. TALKING WITH WINNEBAGO AND CUMMINGS ENGINE THEY BOTH STATED THIS WAS A CHASSIS PROBLEM AND CONTACT FREIGHTLINER. I CALLED THEM IN ORLANDO FLORIDA AND THEY STATED THEY WERE AWARE OF SOME PROBLEM WITH THE DASH INSTRUMENT PANEL OR ASSOCIATED ELECTRICAL CONTROL BOARD. THEY ALSO STATED THERE COULD BE AN ELECTRICAL SHORT IN THE WIRING HARNESS. I DID NOT HAVE AN ACCIDENT AND DID NOT LIKE PULLING OFF THE ROAD TO CHECK FOR PROBLEMS ON THREE OCCASIONS BETWEEN JACKSONVILLE FL. AND ORLANDO, FL. *TR
Mileage: 13,269
Compare 2012FREIGHTLINER114SD to Similar Vehicles
NHTSA Investigations
PE24032Preliminary EvaluationClosed
EVDM connector plate separation
PE21006Preliminary EvaluationClosed
Halogen Headlights May Cause Fires
PE21002Preliminary EvaluationClosed
Trolley bus circuit breaker fires
PE20014Preliminary EvaluationClosed
Rear Wheel Speed Sensor Failure
PE20006Preliminary EvaluationClosed
Intermittent Loss of Power Steering Assist
Frequently Asked Questions
How many complaints does the 2012 FREIGHTLINER 114SD have?▼
The 2012 FREIGHTLINER 114SD has 2 NHTSA complaints, 0 crashes, 1 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2012 FREIGHTLINER 114SD?▼
Yes, the 2012 FREIGHTLINER 114SD has 8 recall(s). The most common affected component is STEERING:LINKAGES:TIE ROD ASSEMBLY. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2012 FREIGHTLINER 114SD?▼
The most-complained component for the 2012 FREIGHTLINER 114SD is ELECTRICAL SYSTEM with 1 complaints. Other frequently reported areas include FUEL/PROPULSION SYSTEM.
Is the 2012 FREIGHTLINER 114SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.