2021 FORD MUSTANG MACH E

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM):SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E vehicles previously repaired incorrectly under recall number 22V-412. The high voltage battery main contactors may overheat.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Ford Motor Company (Ford) is recalling certain 2021 Mach-E vehicles. An Over-The-Air (OTA) update to the Anti-lock Braking System (ABS) may result in a loss of power brake assist, ABS, Electronic Stability Control, Traction Control, and driver assistance features.

SEAT BELTS:REAR/OTHER:ANCHORAGE

Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E and 2022 Maverick vehicles. The rear seat belt buckles may not be properly attached to the rear floor assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208,

VISIBILITY:WINDSHIELD

Ford Motor Company (Ford) is recalling certain 2021 Mustang Mach-E vehicles. The windshield may not have been properly bonded to the vehicle, which could allow it to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 212, "Windshiel

VISIBILITY:FIXED PANARAMIC ROOF/SKY LIGHT ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2021 Mustang Mach-E vehicles. The vehicle's panoramic roof glass panel may not have been properly bonded to the vehicle, which could allow it to detach.

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicle

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)

Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E vehicles equipped with an extended range battery. The high voltage battery main contactors may overheat.

ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2025 Mustang Mach E vehicles. In the event of a low battery charge, the electronic door latches may remain locked once the driver or front passenger exits and shuts the door, possibly trapping someone who is unable to use the inside door release ha

VEHICLE SPEED CONTROL

Ford Motor Company (Ford) is recalling certain 2021 Mustang Mach-E vehicles equipped with all-wheel drive. The powertrain control module (PCM) functional safety software may fail to detect a software error, resulting in unintended acceleration, unintended deceleration, or a loss of drive power.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM):SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E vehicles. The high voltage battery main contactors may overheat.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Ford Motor Company (Ford) is recalling certain 2021 Mach-E vehicles that were repaired incorrectly under recall 24V777. An Over-The-Air (OTA) update to the Anti-lock Braking System (ABS) may result in a loss of power brake assist, ABS, Electronic Stability Control, Traction Control, and driver assis

SUSPENSION:SUBFRAME/MOUNTING BRACKET

Ford Motor Company (Ford) is recalling certain 2021 Mustang Mach-E vehicles. The front subframe bolts may not have been tightened properly during assembly, which could result in loose bolts.

Vehicle experienced immediate loss of motive power while in motion at 45 mph after "Stop Safely Now" alert. This is a repeat power failure. The vehicle was in service for 75+ days (Dec-Feb) for this exact defect. The Ford service center said they replaced the “battery controller” yet the issue recurred. The car previously flagged this alert while in motion 2 times prior (one on the highway going ~65mph and on another major street going roughly ~45 mph). As a Ford Reacquired Vehicle (Buyback), the failure to resolve this catastrophic electrical fault creates an extreme risk of crash and entrapment in traffic, putting myself, my family and the drivers in vicinity at significant safety risk. The car is currently at a different Ford Service Center. They have been able to reproduce the issue and are currently running diagnostics to identify a resolution.

Vehicle experienced immediate loss of motive power while in motion at 45 mph after "Stop Safely Now" alert. This is a repeat power failure. The vehicle was in service for 75+ days (Dec-Feb) for this exact defect. The Ford service center said they replaced the “battery controller” yet the issue recurred. The car previously flagged this alert while in motion 2 times prior (one on the highway going ~65mph and on another major street going roughly ~45 mph). As a Ford Reacquired Vehicle (Buyback), the failure to resolve this catastrophic electrical fault creates an extreme risk of crash and entrapment in traffic, putting myself, my family and the drivers in vicinity at significant safety risk. The car is currently at a different Ford Service Center. They have been able to reproduce the issue and are currently running diagnostics to identify a resolution.

Vehicle experienced immediate loss of motive power while in motion at 45 mph after "Stop Safely Now" alert. This is a repeat power failure. The vehicle was in service for 75+ days (Dec-Feb) for this exact defect. The Ford service center said they replaced the “battery controller” yet the issue recurred. The car previously flagged this alert while in motion 2 times prior (one on the highway going ~65mph and on another major street going roughly ~45 mph). As a Ford Reacquired Vehicle (Buyback), the failure to resolve this catastrophic electrical fault creates an extreme risk of crash and entrapment in traffic, putting myself, my family and the drivers in vicinity at significant safety risk. The car is currently at a different Ford Service Center. They have been able to reproduce the issue and are currently running diagnostics to identify a resolution.

After recall-related software updates were performed on my 2021 Ford Mustang Mach-E, the vehicle began experiencing repeated electrical and climate control failures. The heating and defrost system stopped working, leaving the vehicle without heat and causing the windows to fog, which reduces visibility in cold weather and creates unsafe driving conditions. The vehicle has been taken to multiple authorized Ford dealerships for inspection and repair; however, the problem returned immediately after the repair. The issue was reproduced and confirmed by a second dealer. A required part is currently on back order until the end of Feburary, leaving the vehicle unrepaired for an extended period. In addition, the vehicle experienced 12-volt battery failure and slow charging after the last recall update. These issues were not present prior to the recall. There were no warning lights before the failures occurred. During severe winter weather conditions in Pennsylvania, the lack of heat and defr

After recall-related software updates were performed on my 2021 Ford Mustang Mach-E, the vehicle began experiencing repeated electrical and climate control failures. The heating and defrost system stopped working, leaving the vehicle without heat and causing the windows to fog, which reduces visibility in cold weather and creates unsafe driving conditions. The vehicle has been taken to multiple authorized Ford dealerships for inspection and repair; however, the problem returned immediately after the repair. The issue was reproduced and confirmed by a second dealer. A required part is currently on back order until the end of Feburary, leaving the vehicle unrepaired for an extended period. In addition, the vehicle experienced 12-volt battery failure and slow charging after the last recall update. These issues were not present prior to the recall. There were no warning lights before the failures occurred. During severe winter weather conditions in Pennsylvania, the lack of heat and defr

After recall-related software updates were performed on my 2021 Ford Mustang Mach-E, the vehicle began experiencing repeated electrical and climate control failures. The heating and defrost system stopped working, leaving the vehicle without heat and causing the windows to fog, which reduces visibility in cold weather and creates unsafe driving conditions. The vehicle has been taken to multiple authorized Ford dealerships for inspection and repair; however, the problem returned immediately after the repair. The issue was reproduced and confirmed by a second dealer. A required part is currently on back order until the end of Feburary, leaving the vehicle unrepaired for an extended period. In addition, the vehicle experienced 12-volt battery failure and slow charging after the last recall update. These issues were not present prior to the recall. There were no warning lights before the failures occurred. During severe winter weather conditions in Pennsylvania, the lack of heat and defr

On Saturday, [XXX], while driving under normal conditions, the vehicle experienced a sudden and complete loss of propulsion without warning. There was no reduced-power mode, no dashboard alert, and no mobile app notification prior to shutdown. The vehicle was subsequently inspected by a Ford dealership. The technician identified an intermittent software-related condition consistent with Ford TSB 26-2005, which documents a fault capable of draining the 12-volt electrical system during vehicle operation. The technician stated the 12-volt battery is not believed to be the root cause. The loss of propulsion occurred while the vehicle was in motion and resulted in a full shutdown. The condition was not preceded by any driver warning or controlled degradation. No driver warning was received after shutdown. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am requesting immediate escalation regarding my 2021 Ford Mustang Mach-E (VIN: [XXX] ), which is currently undrivable due to being stuck in “Power Accessory Active” mode. The vehicle will not enter Drive. The dealer has diagnosed DCEM / high-voltage system-related faults and stated that recall repairs cannot be completed unless I first pay approximately $3,000 to repair the “main battery.” My concern is that the symptoms and failure mode exactly match the known High-Voltage Battery Junction Box / DCEM defect described in Ford Safety Recall 23S56, including: •Vehicle unable to drive •High-voltage system refusing to close contactors •Vehicle remaining in accessory power mode •Safety-related loss of motive power While my VIN may not be currently listed as eligible for these recalls, my vehicle is exhibiting identical symptoms and failure modes associated with the following Ford safety recalls: •HV Battery Junction Box / DCEM defect (Recall 23S56) •Powertrain / Softwa

I am requesting immediate escalation regarding my 2021 Ford Mustang Mach-E (VIN: [XXX] ), which is currently undrivable due to being stuck in “Power Accessory Active” mode. The vehicle will not enter Drive. The dealer has diagnosed DCEM / high-voltage system-related faults and stated that recall repairs cannot be completed unless I first pay approximately $3,000 to repair the “main battery.” My concern is that the symptoms and failure mode exactly match the known High-Voltage Battery Junction Box / DCEM defect described in Ford Safety Recall 23S56, including: •Vehicle unable to drive •High-voltage system refusing to close contactors •Vehicle remaining in accessory power mode •Safety-related loss of motive power While my VIN may not be currently listed as eligible for these recalls, my vehicle is exhibiting identical symptoms and failure modes associated with the following Ford safety recalls: •HV Battery Junction Box / DCEM defect (Recall 23S56) •Powertrain / Softwa

The spot welds connecting the door at the hinges have failed. The metal is shearing, over 10mm, at multiple of the world locations.

The backup camera and 360 view stopped working, and the reverse break assist is not available when placing the vehicle in reverse. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The backup camera and 360 view stopped working, and the reverse break assist is not available when placing the vehicle in reverse. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The backup camera and 360 view stopped working, and the reverse break assist is not available when placing the vehicle in reverse. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Ford is unable to perform two safety recalls. The first is over the windshield which can lead to its failure while driving. The second is for the glass roof which can cause a failure while driving. The local dealer in Springfield Illinois says they can not do the work and can not identify anyone locally who will do the work. The dealership with the Ford autobody repair shop in the next town over in taylorville Illinois says they can not do the work. I called Ford customer service and they just sent me to the taylorville shop that said they can't do the work. The windshield or roof can come off and no one will do the repair including Fords own autobody shop. Help.

While charging my electric vehicle with this Enel X JuiceBox 40 charger, a burning plastic smell was noted. Upon examining the Enel X charger plug that was attached to my home's NEMA 14-50, it appeared partially melted and very to touch. Using a towel, the plug was removed and a small fire and sparks flew out of the NEMA outlet. The right half of the outlet's plastic shell was melted and the inner metal was charred. Same charring and melting was noted on the corresponding side of the Enel X plug. I turned the circuit breaker off and the sparks and fire subsided. Model of JuiceBox: 2JBO401RNA-PJWX-300

I bought this car in August of 2024. It started having issues with the door lock in September and in December I decided to sell it back to the dealer but was in a car accident on the way to the dealership. Unfortunately the door jamming issue caused repair problems and the auto repair shop could not fix the door issues. I lost the car to the repair shop in a lien sale due to the cost of repair which was over $20,000. In August of 2025 Ford issued a recall which allowed the auto repair shop was able to fix the car and sell it to a dealership. I have contacted Ford several times in relation to the issues with the car and how they caused me to loose the car, but they have not responded despite the promise to do so in 7-15 business days. Loosing this car has caused deep stresses in my life. I have lost several business clients because I'm no longer able to get around. I have had my life impacted to the point of having to relocate. I bought the car outright paying $45,000. Ford has ref

The car would intermittently give an error saying pre-collision assist not available and now this error is permanent. There is a technical service bulletin for it 23-2155 Lots of people have been complaining about this in the mach e forum https://www.macheforum.com/site/threads/front-camera-fault-pre-collision-assist-not-available-errors.18710/page-69#post-1026803 This causes people to drop out from the automatic driving bluecruise without notice and adaptive cruise control becomes unusable.

The car would intermittently give an error saying pre-collision assist not available and now this error is permanent. There is a technical service bulletin for it 23-2155 Lots of people have been complaining about this in the mach e forum https://www.macheforum.com/site/threads/front-camera-fault-pre-collision-assist-not-available-errors.18710/page-69#post-1026803 This causes people to drop out from the automatic driving bluecruise without notice and adaptive cruise control becomes unusable.

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that while driving approximately 20 - 25 MPH in the rain at night, the brake pedal was bouncing up and down. The contact stated that the doors locked and failed to open. Additionally, the vehicle stalled. The contact stated that the hazard lights were inoperable. They stated that one of the passenger’s side tire warning lights was illuminated. The contact stated that the battery was at 98 percent and that several unknown warning lights were illuminated. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 22V333000 (Vehicle Speed Control, Power Train) prior to the failure. The contact called Roadside Assistance, but Roadside Assistance was unable to assist. The contact stated that a Police Officer arrived on the scene to assist. The vehicle was towed to the local dealer after several hours. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was p

Mileage: 40,400

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that while driving approximately 20 - 25 MPH in the rain at night, the brake pedal was bouncing up and down. The contact stated that the doors locked and failed to open. Additionally, the vehicle stalled. The contact stated that the hazard lights were inoperable. They stated that one of the passenger’s side tire warning lights was illuminated. The contact stated that the battery was at 98 percent and that several unknown warning lights were illuminated. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 22V333000 (Vehicle Speed Control, Power Train) prior to the failure. The contact called Roadside Assistance, but Roadside Assistance was unable to assist. The contact stated that a Police Officer arrived on the scene to assist. The vehicle was towed to the local dealer after several hours. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was p

Mileage: 40,400