2022 FORD MAVERICK

EXTERIOR LIGHTING:BRAKE LIGHTS

Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. Under certain circumstances, the Antilock Brake System (ABS) module may cause the brake lights to illuminate without the driver applying the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles previously repaired incorrectly under recall number 24V-140. The instrument panel cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-730. Under certain circumstances, the Antilock Brake System (ABS) module may cause the brake lights to illuminate without the driver applying the brakes. As such, these veh

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-590. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydr

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2

ENGINE

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources s

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.

ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Disp

ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.

SEAT BELTS:REAR/OTHER:ANCHORAGE

Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E and 2022 Maverick vehicles. The rear seat belt buckles may not be properly attached to the rear floor assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208,

FUEL SYSTEM, GASOLINE:STORAGE

Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. The fuel tank may have been damaged by drill holes during the installation of the spray-in bed-liner. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel Syste

EXTERIOR LIGHTING:TURN SIGNAL:BULBS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

EXTERIOR LIGHTING:TURN SIGNAL

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signa

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR). The rearview camera image may freeze when the vehicle is in reverse.

ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it t

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

AIR BAGS:SIDE/WINDOW:CURTAIN

Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. The side-curtain air bags may not deploy properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 226, "Ejection Mitigation."

ENGINE AND ENGINE COOLING

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition source

ENGINE

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine

I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I wa

I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I wa

I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I wa

The rear brake lights intermittently do not work, but at the same time the middle third light brake light works fine. also the turn signals work fine. People will rear end me if they don’t see my brake lights. I am a retired, master mechanic, and my son is also a mechanic. We have both looked into this problem and it possibly could be either a module or the turn signal switch. I had no warning of this problem coming on other than someone telling me my rear brake lights stopped working when they were following me. This is a very dangerous situation.

In cold weather -6F The cover over the positive terminal used to jump start the vehicle is impossible to remove. This causes a situation where the vehicle can not be jump started or render assistance to another that needs jump started. The issue stems from the fact that the plastic cover over the positive terminal is unable to bend when it is cold and can not be "unclipped".

This is a complaint of Sheridan Ford in Wilmington DE specifically refusing to complete the recall without my paying out of pocket. Manufacturer Recall Number24S59 NHTSA Recall Number24V684 was left incomplete because they demanded I pay for a "diagnostic" fee on a known safety issue - this dealership is taking advantage of a saftey recall that is required to force customers to pay

Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships r

Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships r

Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships r

When it rains water gets into the passenger-side footwell and beneath the carpeting during rain events.

After a little over 3 years, my truck has had issues maintaining its 12v battery putting me at risk of being stranded. The battery was replaced once under warranty. Now that I am out of warranty, the replacement battery is now going bad.

The vehicle experiences water intrusion into the passenger-side footwell and under-carpet area during rain events. The suspected failure involves the body sealing system, potentially including the windshield cowl area, firewall seams, HVAC intake/cowl drainage, or related body panel seals. The vehicle and all affected components are fully intact and available for inspection upon request. The carpet has been lifted to document standing water and mold growth but has not been replaced or permanently altered. This defect presents multiple safety risks, including: Visible Black Mold contamination inside the passenger compartment, airbag, and throughout HVAC system, creating a health hazard for occupants. Potential electrical system damage due to repeated water exposure. Possible impact on airbag and restraint system wiring, which is located beneath the passenger-side dash and carpet. Increased risk of window fogging and reduced visibility during wet conditions. The vehicle is currently u

Battery in the passenger compartment is charging at 15.2 volts constantly. Ford dealer claims this is not a problem, but the battery life has been shortened, and the battery model number states it should be charged between 13.8 and 14.2 volts. The battery is located under the rear seat, inside the passenger compartment. From my limited understanding of battery technology, over-charging can produce hydrogen into the passenger compartment. My vehicle is now on the third battery, and has only 73,511 miles.

The contact owns a 2022 Ford Maverick. The contact stated that while her son was driving approximately 60-65 MPH on the Interstate, the passenger’s side front wheel detached. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

Mileage: 40,000

The contact owns a 2022 Ford Maverick. The contact stated that while attempting to start the vehicle, the vehicle failed to respond. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed, and determined that the battery needed to be replaced. The contact stated that the failure had occurred on several occasions. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 19,150.

Mileage: 19,150

Door check has failed in the frame. The spot welds have broken in similar fashion to the Ford Customer Satisfaction Program 23B56 on the Escapes. There are popping noises, creaking, alignment issues, and prevents the window from rolling down.

The vehicle begins to vibrate in the front end when accelerating and reaching 80 km/h. It becomes extremely unstable. The dealership was unable to find the cause of the problem.

The rear drive unit (rdu) begin to shutter and lock rear tires at low turning speeds. The vehicle was out of warranty with 85k miles. I paid a Ford dealer to replace the rdu and 2 weeks later the same issue was occurring.

My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises

My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises