FORD FUSION · model year

2020 FORD FUSION

227 NHTSA complaints, 9 crash reports, and 3 active recalls for this specific cohort.

NHTSA overall rating

5 / 5 ★

New Car Assessment Program

The 2020FORDFUSION carries 227 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 9 crashes, 3 fires, 4 injuries, and 0 fatalities. For crash performance, NHTSA's New Car Assessment Program gave this cohort an overall 5/5 rating, with 4/5 front crash, 5/5 side crash, and 4/5 rollover scores derived from standardized barrier and dynamic tests.

Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2020 FUSION is power train with 56 filings, followed by engine (40) and electrical system (33). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 3 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.

NHTSA currently has 3 investigation files overlapping the 2020 FUSION. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.

227
Complaints
9
Crashes
3
Fires
4
Injuries
0
Deaths
2020 FORD FUSION — NHTSA crash-test profile NHTSA NCAP crash-test star ratings for the 2020 FORD FUSION. Overall composite: 5.0 of 5 stars across 3 safety dimensions. Front CrashSide CrashRollover 5.0 NHTSA NCAP of 5 stars
  • Front Crash 4.0 ★
  • Side Crash 5.0 ★
  • Rollover 4.0 ★
NHTSA overall 5.0/5 stars, with front-crash, side-crash and rollover ratings from standardized NCAP barrier and dynamic tests.

Total Complaints

227 filings

Crashes Reported

9 reports

Source

NHTSA ODI

Federal complaints database

Complaints vs. fleet median (215)

Above median complaint volume — review patterns below.

NHTSA NCAP overall: 5/5 — Top NCAP rating · Front: 4/5 · Side: 5/5 · Rollover: 4/5

Complaints by Component

ComponentCount
POWER TRAIN56
ENGINE40
ELECTRICAL SYSTEM33
UNKNOWN OR OTHER23
SERVICE BRAKES10
FUEL/PROPULSION SYSTEM8
STEERING6
FORWARD COLLISION AVOIDANCE: WARNINGS5
ENGINE AND ENGINE COOLING5
STRUCTURE:BODY4
AIR BAGS4
VEHICLE SPEED CONTROL4
SUSPENSION4
WHEELS3
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL3

Recalls (3)

25V44200027/06/2025

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2

23V44000013/09/2023

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)

Ford Motor Company (Ford) is recalling certain 2019-2020 Fusion PHEV vehicles. The battery energy control module (BECM) may become damaged due to excessive voltage and current flow.

25V68500010/10/2025

EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it t

Recent Complaints

20260213FireELECTRICAL SYSTEM

"The incident occurred immediately after shifting the vehicle into reverse and starting to move. The engine suddenly shut down with a 'System Performance' alert, and cooling fans engaged at maximum speed. Moments later, a thermal runaway event began in the high-voltage Li-ion battery pack, leading to a catastrophic fire. This is directly related to Recall 23V440 / 23S33 (BECM failure). The fire was extinguished by the local fire department in Telavi, Georgia (Country)."

20260213FireFUEL/PROPULSION SYSTEM

"The incident occurred immediately after shifting the vehicle into reverse and starting to move. The engine suddenly shut down with a 'System Performance' alert, and cooling fans engaged at maximum speed. Moments later, a thermal runaway event began in the high-voltage Li-ion battery pack, leading to a catastrophic fire. This is directly related to Recall 23V440 / 23S33 (BECM failure). The fire was extinguished by the local fire department in Telavi, Georgia (Country)."

20260211ELECTRICAL SYSTEM

COMPONENT: ELECTRICAL SYSTEM, ENGINE I HAVE HAD THIS SENSOR THAT MAKES MY CHECK ENGINE LIGHT STAY ON 3 SEPARATE TIMES! THIS NEEDS TO BE RE CALLED I SEE MULTIPLE COMPLAINTS WITH THE SAME CONCERN

20260207SEAT BELTS

The locking mechanism that keeps the seat belt safely locked into place is malfunctioning. I have to ensure the belt is firmly in place and will not tug out of the lock before going anywhere. The seatbelt will not lock in place properly.

20260204ENGINE

Last month, while transporting my brother to his arm surgery in Chapel Hill, NC, I observed unusual and audible shifting behavior when engaging the vehicle's sport mode. This mode is typically utilized for extended journeys on highways and interstates. Although the anomaly was brief, I did not initially consider it significant. Several weeks later, upon departing from my community college campus, I encountered a red light near Santa Fe Drive. The vehicle exhibited a hesitant and labored acceleration, eventually moving forward. This incident was particularly concerning given the high volume of traffic during that time of day. I subsequently stopped at a nearby 7-Eleven for fuel, suspecting a low fuel level might be the cause. No engine warning lights or mechanical indicators were illuminated, and the oil life was at 70% with appropriate oil levels. Fast forward to the last week of January. On Wednesday the 28th, I began to notice recurring shifting issues with the vehicle during a clas

20260204UNKNOWN OR OTHER

Last month, while transporting my brother to his arm surgery in Chapel Hill, NC, I observed unusual and audible shifting behavior when engaging the vehicle's sport mode. This mode is typically utilized for extended journeys on highways and interstates. Although the anomaly was brief, I did not initially consider it significant. Several weeks later, upon departing from my community college campus, I encountered a red light near Santa Fe Drive. The vehicle exhibited a hesitant and labored acceleration, eventually moving forward. This incident was particularly concerning given the high volume of traffic during that time of day. I subsequently stopped at a nearby 7-Eleven for fuel, suspecting a low fuel level might be the cause. No engine warning lights or mechanical indicators were illuminated, and the oil life was at 70% with appropriate oil levels. Fast forward to the last week of January. On Wednesday the 28th, I began to notice recurring shifting issues with the vehicle during a clas

20260204UNKNOWN OR OTHER

Back up camera, and touch screen go completely out...the whole system will not come back on until vehicle is shut off and restarted. This has happened multiple times now.

20260120FireUNKNOWN OR OTHER

In 2024 on Black Friday while driving home from work my car all of a sudden was starting to lose speed. Even when I'm hitting the gas it would not accelerate and I could push it all the way down to the floor or nothing. And all of a sudden I start to see a whole bunch of monitors go off on my dashboard animal League to the government off and then all of a sudden I started see this underneath my core board pulled over and all sudden those planes coming from my engine and within minutes the whole car was destroyed. Fire department came to drop the fire and everything but the trunk was left essentially. The insurance company has taken to car since and I believed it was sold for parts. I have Thought I had submitted this before but never got somebody you can just in case I messed up. I just feel like a car shouldn't just randomly catch fire

20260117ELECTRICAL SYSTEM

I don't know what failed, but my vehicle spontaneously combusted this morning in front of my apartment.and is a total loss. Fire Marshal's [XXX] ) Case# XX-XXX. The fire also destroyed the vehicle sittling next to it. We are lucky the building didn't catch on fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

20260109ELECTRICAL SYSTEM

I am the second owner on my Ford fusion 2020 SE all-wheel-drive I got the car at 21,000 I had warranty since I had the warranty. I've been going for this power training code and having them check my car out all the time they always say there's nothing wrong with it. It's just the code is being erased so by the time my warranty went out all these problems are coming up and now they could find those problems I've been inquiring about

20260109POWER TRAIN

I am the second owner on my Ford fusion 2020 SE all-wheel-drive I got the car at 21,000 I had warranty since I had the warranty. I've been going for this power training code and having them check my car out all the time they always say there's nothing wrong with it. It's just the code is being erased so by the time my warranty went out all these problems are coming up and now they could find those problems I've been inquiring about

20251219POWER TRAIN

In early October 2025, the vehicle was taken to an independent dealership service department for a routine oil change. Several weeks later, the vehicle appeared to be leaking fluid and began experiencing loud knocking/clacking noises, significant vibration, and drivability concerns, especially during acceleration. On October 10, 2025, while parked at a family member’s residence, the vehicle would not start. Due to safety concerns, the servicing dealership arranged for the vehicle to be towed for inspection. Technicians found a split transmission hose causing transmission fluid loss, which was repaired; however, the abnormal noises, vibration, and drivability issues persisted. Further inspection identified loud popping/clacking noises from the bell housing area. The technician physically inspected the flex plate and documented that the flex plate was cracked. The dealership advised that a cracked flex plate can worsen, cause severe vibration, damage related components, and lead to d

20251219FUEL/PROPULSION SYSTEM

In early October 2025, the vehicle was taken to an independent dealership service department for a routine oil change. Several weeks later, the vehicle appeared to be leaking fluid and began experiencing loud knocking/clacking noises, significant vibration, and drivability concerns, especially during acceleration. On October 10, 2025, while parked at a family member’s residence, the vehicle would not start. Due to safety concerns, the servicing dealership arranged for the vehicle to be towed for inspection. Technicians found a split transmission hose causing transmission fluid loss, which was repaired; however, the abnormal noises, vibration, and drivability issues persisted. Further inspection identified loud popping/clacking noises from the bell housing area. The technician physically inspected the flex plate and documented that the flex plate was cracked. The dealership advised that a cracked flex plate can worsen, cause severe vibration, damage related components, and lead to d

20251219ENGINE

In early October 2025, the vehicle was taken to an independent dealership service department for a routine oil change. Several weeks later, the vehicle appeared to be leaking fluid and began experiencing loud knocking/clacking noises, significant vibration, and drivability concerns, especially during acceleration. On October 10, 2025, while parked at a family member’s residence, the vehicle would not start. Due to safety concerns, the servicing dealership arranged for the vehicle to be towed for inspection. Technicians found a split transmission hose causing transmission fluid loss, which was repaired; however, the abnormal noises, vibration, and drivability issues persisted. Further inspection identified loud popping/clacking noises from the bell housing area. The technician physically inspected the flex plate and documented that the flex plate was cracked. The dealership advised that a cracked flex plate can worsen, cause severe vibration, damage related components, and lead to d

20251218POWER TRAIN

When these problems started it was only 6 months after purchase and I was already having issues with power train malfunctions and it didnt want to switch gears. I purchased this at roughly 47,000 miles and it didnt make it to 70,000 miles before I ultimately decided it was not the safe vehicle that was advertised to my family and I. It was taken to the dealership over 3 times in under a year and for some reason the problem never got resolved. I have been sued for the remaining balance now despite that toward the end of my time owning it the vehicle was reving out with barely any pressure on the gas pedal, having issues braking on its own (anti-collision assist), and occasionally the steering wheel would jerk me in to oncoming traffic. I am just trying to get a recall issued at this point because this car is going to kill someone if it stays on the road.

20251218ELECTRICAL SYSTEM

When these problems started it was only 6 months after purchase and I was already having issues with power train malfunctions and it didnt want to switch gears. I purchased this at roughly 47,000 miles and it didnt make it to 70,000 miles before I ultimately decided it was not the safe vehicle that was advertised to my family and I. It was taken to the dealership over 3 times in under a year and for some reason the problem never got resolved. I have been sued for the remaining balance now despite that toward the end of my time owning it the vehicle was reving out with barely any pressure on the gas pedal, having issues braking on its own (anti-collision assist), and occasionally the steering wheel would jerk me in to oncoming traffic. I am just trying to get a recall issued at this point because this car is going to kill someone if it stays on the road.

20251218SERVICE BRAKES

When these problems started it was only 6 months after purchase and I was already having issues with power train malfunctions and it didnt want to switch gears. I purchased this at roughly 47,000 miles and it didnt make it to 70,000 miles before I ultimately decided it was not the safe vehicle that was advertised to my family and I. It was taken to the dealership over 3 times in under a year and for some reason the problem never got resolved. I have been sued for the remaining balance now despite that toward the end of my time owning it the vehicle was reving out with barely any pressure on the gas pedal, having issues braking on its own (anti-collision assist), and occasionally the steering wheel would jerk me in to oncoming traffic. I am just trying to get a recall issued at this point because this car is going to kill someone if it stays on the road.

20251217ENGINE

My Ford started making a loud noise whenever the accelerator wasn't being pressed, after taking it to the mechanic, he said it is the cracked flex plate. After some light research, it was aparent that this is an issue that Ford's cars have, and ford has tried to make it better by offering free fixes. I contacted the local ford dealer and since the car has 90,000 miles, it would have been covered. However, since it doesn't have a clean title, I was declined this service free of charge. I don't agree with this decision since I've been driving this car for over a year since it was purchased off IAA auction, and this issue was made clear only yesterday, but this issue is prevalent in cars like mine.The damage to my car specifically was to the back, and only affected the rear bumper and trunk. Therefore I don't think it is fair that I was declined the serve even though Ford has made it clear it is there manufacturing mistake and they are willing to fix it, just not with cars with my type of

20251217FUEL/PROPULSION SYSTEM

My Ford started making a loud noise whenever the accelerator wasn't being pressed, after taking it to the mechanic, he said it is the cracked flex plate. After some light research, it was aparent that this is an issue that Ford's cars have, and ford has tried to make it better by offering free fixes. I contacted the local ford dealer and since the car has 90,000 miles, it would have been covered. However, since it doesn't have a clean title, I was declined this service free of charge. I don't agree with this decision since I've been driving this car for over a year since it was purchased off IAA auction, and this issue was made clear only yesterday, but this issue is prevalent in cars like mine.The damage to my car specifically was to the back, and only affected the rear bumper and trunk. Therefore I don't think it is fair that I was declined the serve even though Ford has made it clear it is there manufacturing mistake and they are willing to fix it, just not with cars with my type of

20251217POWER TRAIN

My Ford started making a loud noise whenever the accelerator wasn't being pressed, after taking it to the mechanic, he said it is the cracked flex plate. After some light research, it was aparent that this is an issue that Ford's cars have, and ford has tried to make it better by offering free fixes. I contacted the local ford dealer and since the car has 90,000 miles, it would have been covered. However, since it doesn't have a clean title, I was declined this service free of charge. I don't agree with this decision since I've been driving this car for over a year since it was purchased off IAA auction, and this issue was made clear only yesterday, but this issue is prevalent in cars like mine.The damage to my car specifically was to the back, and only affected the rear bumper and trunk. Therefore I don't think it is fair that I was declined the serve even though Ford has made it clear it is there manufacturing mistake and they are willing to fix it, just not with cars with my type of

Compare 2020FORDFUSION to Similar Vehicles

NHTSA Investigations

Frequently Asked Questions

How many complaints does the 2020 FORD FUSION have?
The 2020 FORD FUSION has 227 NHTSA complaints, 9 crashes, 3 fires, 4 injuries, and 0 deaths reported.
What is the safety rating for the 2020 FORD FUSION?
The 2020 FORD FUSION received an overall NHTSA safety rating of 5/5, front crash rating of 4/5, side crash rating of 5/5, and rollover rating of 4/5.
Are there any recalls for the 2020 FORD FUSION?
Yes, the 2020 FORD FUSION has 3 recall(s). The most common affected component is BACK OVER PREVENTION:SOFTWARE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2020 FORD FUSION?
The most-complained component for the 2020 FORD FUSION is POWER TRAIN with 56 complaints. Other frequently reported areas include ENGINE and ELECTRICAL SYSTEM.
Is the 2020 FORD FUSION safe to buy?
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. The 2020 FORD FUSION has an NHTSA safety rating of 5/5. Compare with other model years using the links above.
Where does this data come from?
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.

Vehicle Safety Guides

Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.