2007 FORD FREESTAR

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE

SEATS

Ford is recalling certain model year 2004-2007 Freestar and Mercury Monterey vehicles manufactured from March 24, 2003, through November 7, 2006, equipped with a third row seat and originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massac

The contact owns a 2007 Ford Freestar. The contact received notification of NHTSA Campaign Number: 13V081000 (Seats); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was unavailable.

The contact owns a 2007 Ford Freestar. The contact stated that he discovered two large holes located on both sides of the third-row seats. The contact stated that the holes were located at the seat anchors; the structural degradation at the seat anchor were mounted to the rear wheel wells. The contact then discovered that his vehicle was placed under NHTSA Campaign Number: 13V081000 (Seats). The contact then notified the dealer and was informed that the part to repair the vehicle was not available and also that the corrosion on the vehicle was too severe to complete the repair. The manufacturer was also notified of the failure and referred the contact to the Better Business Bureau for further assistance. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The failure mileage was approximately 100,000. Parts distribution disconnect.

Mileage: 100,000

PASSENGER SIDE MIRROR BURNED, SMOLDERED WITH A GREAT DEAL OF SMOKE. COULD SEE ORANGE GLOW BEHIND THE MIRROR. SMELLED LIKE AN ELECTRICAL BURN. CAR WAS PARKED, NO KEY IN IGNITION, HAPPENED RIGHT AFTER UNLOCKING CAR WITH KEY FOB.

Mileage: 68,000

TORQUE CONVERTER IS SHOWING SIGNS OF FAILURE WITH VAN A LESS THAN 50K MILES. A TRANSMISSION FLUSH AND SERVICE INCLUDING FORD'S FRICTION MODIFIER DID NOT FIX.

Mileage: 57,000

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED AS THE ACCELERATOR PEDAL WAS DEPRESSED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 89,000. *JS

Mileage: 89,000

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE THE VEHICLE WAS BEING REVERSED WITH PASSENGERS SEATED IN THE THIRD ROW, THE THIRD ROW SEAT ATTACHMENT BOLT FRACTURED. THE CONTACT STATED THAT THE SEAT SHIFTED AND WAS NO LONGER SECURELY FASTENED TO THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Mileage: 150,000

I HAVE A 2007 FORD FREESTAR SE. VIN# [XXX]. AT 102,296 MILES THE TRANSMISSION FAILED. I WAS DRIVING IT ON A SIDE STREET AT APPROXIMATELY 15 MILES PER HOUR. I WAS ACCELERATING FROM A STOP SIGN, WHEN THE TRANSMISSION APPEARED TO SLIP INTO NEUTRAL. I LOOKED AND IT WAS STILL IN DRIVE, I TRIED DOWNSHIFTING, PUTTING IT INTO NEUTRAL AND BACK INTO DRIVE AND NOTHING WORKED. I COASTED TO THE SIDE OF THE ROAD AND PUT IT INTO PARK. THAT APPEARED TO WORK. I THEN TRIED USING REVERSE AND IT DID NOT ENGAGE. I THEN TRIED ALL GEARS AND NOTHING HAPPENED. I THEN HAD THE VEHICLE TOWED TO MY HOUSE. I LET IT COOL DOWN AND IT STILL DID NOT WORK. THE TRANSMISSION FLUID IS A CLEAN PINK AND SMELLS BRAND NEW. I PROCEEDED TO DO ONLINE RESEARCH TO DETERMINE THE PROBLEM AND IF IT CAN BE EASILY REPAIRED, WHAT I FOUND WAS VERY INTERESTING. IT WAS A VERY COMMON PROBLEM OCCURRING AROUND 103,000 MILES. MANY (HUNDREDS IF NOT THOUSANDS OF PEOPLE HAD THE SAME ISSUE WITH THIS VEHICLE SPANNING SEVERAL YEARS, MOST NOTABLY F

I HAVE A 2007 FORD FREESTAR SE. VIN# [XXX]. AT 102,296 MILES THE TRANSMISSION FAILED. I WAS DRIVING IT ON A SIDE STREET AT APPROXIMATELY 15 MILES PER HOUR. I WAS ACCELERATING FROM A STOP SIGN, WHEN THE TRANSMISSION APPEARED TO SLIP INTO NEUTRAL. I LOOKED AND IT WAS STILL IN DRIVE, I TRIED DOWNSHIFTING, PUTTING IT INTO NEUTRAL AND BACK INTO DRIVE AND NOTHING WORKED. I COASTED TO THE SIDE OF THE ROAD AND PUT IT INTO PARK. THAT APPEARED TO WORK. I THEN TRIED USING REVERSE AND IT DID NOT ENGAGE. I THEN TRIED ALL GEARS AND NOTHING HAPPENED. I THEN HAD THE VEHICLE TOWED TO MY HOUSE. I LET IT COOL DOWN AND IT STILL DID NOT WORK. THE TRANSMISSION FLUID IS A CLEAN PINK AND SMELLS BRAND NEW. I PROCEEDED TO DO ONLINE RESEARCH TO DETERMINE THE PROBLEM AND IF IT CAN BE EASILY REPAIRED, WHAT I FOUND WAS VERY INTERESTING. IT WAS A VERY COMMON PROBLEM OCCURRING AROUND 103,000 MILES. MANY (HUNDREDS IF NOT THOUSANDS OF PEOPLE HAD THE SAME ISSUE WITH THIS VEHICLE SPANNING SEVERAL YEARS, MOST NOTABLY F

"TAKATA RECALL" WHILE DRIVING MY VAN I LOST TO GO TO THE BANK, WHEN I WENT TO PUT MY FOOT ON THE GAS PEDAL IT WOULD NOT GO. THERE WAS NO MOVEMENT. IT MADE THIS FUNNY SOUND UNDER THE HOOD. I HAD NO WARNING, IT SHIFTED GEARS, MY HUSBAND EVEN PLUGGED IN THE CODE READER AND NOTHING CAME UP. AS WE ARE LOOKING INTO THE ISSUE THE TORKE CONVERTER WENT OUT IN THE TRANSMISSION. SO NOW THIS NEEDS TO BE REPLACED. WE WE'RE ON A IT STREET AT A STOP LIGHT GETTING READY TO MAKE A LEFT HAND TURN.

Mileage: 141,000

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 25 MPH, WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE CONTACT HEARD A RATTLING NOISE UNDER THE HOOD. THE CONTACT STATED THAT THE RATTLING NOISE SEIZED ONCE THE SPEED WAS REDUCED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HOMER SKELTON FORD OF MILLINGTON (9030 US-51, MILLINGTON, TN 38053 (901) 873-3673) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.

Mileage: 152,000

NOISE FROM THE TRANSMISSION. CAR WILL SURGE JUMP WHILE IN GEAR.MY CAR ONLY HAS 48000 MILES

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE REAR QUARTER PANELS ON THE VEHICLE WERE RUSTED AND CORRODED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V081000 (STRUCTURE). THE CONTACT INDICATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

HAD ACCIDENT AND SEATBELT BROKE AND FRONT AIR BAGS DID NOT EMPLOY ON ICY ROAD

HAD ACCIDENT AND SEATBELT BROKE AND FRONT AIR BAGS DID NOT EMPLOY ON ICY ROAD

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE WHEELS SEIZED WHILE DRIVING, WHICH RESULTED IN A LOSS OF CONTROL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 142,900.

Mileage: 142,900

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DEPRESSING THE ACCELERATOR PEDAL AT ANY SPEED, THE VEHICLE DID NOT RESPOND AND A WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000.

Mileage: 103,000

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 30 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

Mileage: 140,000

TRANSMISSION JUST STOPPED WORKING WITH ROUGHLY 77,835 MILES, IN A STATIONARY MODE PARKED. FORD TRANSMISSION THEY PUT IN HAD A BETTER WARRANTY THAN ON THE NEW CAR.

Mileage: 77,835

WHEN I TOUCHED THE TRANSMISSION GEAR SHIFT ONE MORNING, THE CAR BEGAN ROLLING DOWN MY DRIVEWAY & ROLLED INTO THE STREET. I HAD A HARD TIME STOPPING THE VEHICLE BECAUSE THE ENGINE WAS NOT YET RUNNING & THE POWER BRAKES WERE NOT ON. THE GEAR SHIFT LEVER WOULD NOT HOLD IN PARK OR ANY OF THE OTHER GEARS. I HAD THE VEHICLE TOWED TO A TRANSMISSION REPAIR SHOP. WHEN I TOLD THE MECHANIC WHAT HAD HAPPENED, HE SAID IT WAS THE TRANSMISSION TORQUE CONVERTER & SAID, "THIS IS A COMMON PROBLEM WITH THIS VEHICLE." "I HAVE REPLACED HUNDREDS OF THEM OVER THE YEARS. OTHER INDEPENDENT TRANSMISSION REPAIR SHOPS HAVE SAID THE SAME THING. WHEN I ASKED THE CLERK AT THE LOCAL FORD DEALER PARTS DEPT., THEY WOULD NOT TELL ME HOW MANY OF THE TORQUE CONVERTERS THEY HAVE REPLACED. NOR COULD I GET ANY INFORMATION FROM THEIR TRANSMISSION REPAIR MECHANICS. MY INDEPENDENT MECHANIC DID SHOW ME THE DEFECTIVE PART OF MY TRANSMISSION & DEMONSTRATED HOW THE SPLINE IN THE CONVERTER HAD WORN OUT BECAUSE IT WAS NOT PROPER HEAT

Mileage: 70,000

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS UNKNOWN WHAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,430. THE VIN WAS NOT AVAILABLE. UPDATED 11/09/15*LJ *CN

Mileage: 70,430