2006 FORD FOCUS

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND A

Driving on hiway and vehicle shifted gears. Would no shift normally afterwards. Tried several times. Left myself and granddaughter in hiway in danger. Had local mechanic inspect the vehicle. Was told defective shifting linkage. Has occurred multiple times.

Driving on hiway and vehicle shifted gears. Would no shift normally afterwards. Tried several times. Left myself and granddaughter in hiway in danger. Had local mechanic inspect the vehicle. Was told defective shifting linkage. Has occurred multiple times.

Shifting linkage, was driving and went to shift into next gear and nothing. Clutch engaged, shifter goes in slot but doesn't stay it won't lock into gear, further examination found rubber clip and plastic clip from linkage broken and had fallen to topside of transmission.

The welded retainer of the front bushing on the right side lower (control) arm had rusted through. This allowed the control arm to separate from the frame and the right front wheel to turn outward (while I was traveling straight ahead). The drive shaft was pulled from the transmission and some parts hit the ground. Luckily, I was approaching a stop sign and traveling at less than 30 miles per hour. (The day before I was on I95 at 65 mph) Upon inspection you can see that the control arm is forged in the shape of a "C" from very thick metal where the bushing rests against the arm. However, the bushing is retained by a much thinner metal, welded across the arm forming the other side of the "C". It is that thinner welded retainer that had rusted out. We live in an area where salt is routinely used on the roads during the winter. I know the car is very old. However, this design is inadequate from a safety perspective in the Northeast.

THE WIRING HARNESS FLEXES WHERE IT PASSES FROM THE BODY TO THE TAILGATE CAUSING THE IINSULATION AND WIRING TO BREAK AND SHORT TO THE BODY RESULTING IN A BLOWN FUSE AND NO REAR LIGHTS. THIS HAS OCCURRED WHILST DRIVING AND WHEN STATIONARY OPENING THE HATCHBACK.

Mileage: 76,000

THE WIRING HARNESS FLEXES WHERE IT PASSES FROM THE BODY TO THE TAILGATE CAUSING THE IINSULATION AND WIRING TO BREAK AND SHORT TO THE BODY RESULTING IN A BLOWN FUSE AND NO REAR LIGHTS. THIS HAS OCCURRED WHILST DRIVING AND WHEN STATIONARY OPENING THE HATCHBACK.

Mileage: 76,000

AIR BAG WARNING LIGHT STAYED ON AFTER CAR WAS PARKED AND THEN STARTED. ENGINE STARTED, AND THE AIR BAG SRS LIGHT CAME ON AS PART OF SELF TEST, WENT OFF FOR ABOUT 5 SECONDS, CAME BACK ON THEN STAYED ON. CAR WAS NEVER IN A SIGNIFICANT ACCIDENT. ONLY ACCIDENT WAS SCRATCHED BUMPER FROM SIDESWIPE WHEN VEHICLE WAS STATIONARY. CHECKED UNDER AND AROUND 2 FRONT SEATS FOR DEBRIS PER OWNER'S MANUAL. ALL OK WITH INSPECTION. LATCHED AND UNLATCHED SEAT BELTS (DR AND PASS), PULLED AND RETRACTED SEAT BELTS. NO CHANGE, AIR BAG LIGHT STILL ON.

Mileage: 86,000

DRIVING DOWN THE ROAD AND GAS PEDDLE GET STUCK AND SOMETIMES WONT PUSH DOWN TO GO SOMETIMES WHILE ON THE HIGHWAY THE HEADLIGHTS AND ALL LIGHTS FLICKER ALL THE TIME WHEN I HAVE THEM ON AT NIGHT GOTTIN PULLED OVER A COUPLE OF TIMES TOOKIN IT TOO THE SHOP AND THEY SAID EVERYTHINGS OK ON HIGHWAY 36 BETWEEN BROOKFIELD AND CHILLICOTHE MO

Mileage: 160,000

DRIVING DOWN THE ROAD AND GAS PEDDLE GET STUCK AND SOMETIMES WONT PUSH DOWN TO GO SOMETIMES WHILE ON THE HIGHWAY THE HEADLIGHTS AND ALL LIGHTS FLICKER ALL THE TIME WHEN I HAVE THEM ON AT NIGHT GOTTIN PULLED OVER A COUPLE OF TIMES TOOKIN IT TOO THE SHOP AND THEY SAID EVERYTHINGS OK ON HIGHWAY 36 BETWEEN BROOKFIELD AND CHILLICOTHE MO

Mileage: 160,000

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT WHEN THEY ATTEMPT TO FILL THE FUEL TANK, THE FUEL WOULD BEGIN TO LEAK FROM THE VEHICLE. THE CONTACT STATED THE FUEL WOULD LEAK OUT OF THE SAME OPENING THEY WERE ATTEMPTING TO PUT THE FUEL INTO AS IF THE FUEL WAS SPEWING BACK AT THEM. THE CONTACT CONTACTED THE DEALER (MULLINAX FORD OF PALM BEACH LOCATED AT 1210 NORTHLAKE BLVD, LAKE PARK, FL 33403; PHONE NUMBER 888-856-1675) WHO INFORMED THE CONTACT THAT THEIR VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06E056000 (FUEL SYSTEM, GASOLINE). THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 128,156.

Mileage: 128,156

WHILE DRIVING, THE VEHICLE BEGAN TO ACCELERATE ON IT'S OWN. WHEN BRAKES WERE APPLIED THE RPMS SKY ROCKETED. TURNS OUT IT WAS A BROKEN CRUISE CONTROL MODULE CABLE THAT WOULD CAUSE THE THROTTLE TO GET "STUCK". AT THE SAME TIME IT WAS ALSO BOGGING OUT AND SHUTTING ITSELF OFF WHILE DRIVING. THE CHECK ENGINE LIGHT REMAINED ON THROWING A P071? CODE WHICH IS ASSOCIATED WITH O2 LEVELS.THIS TURNED OUT TO BE A BROKEN "BREATHER HOSE" WHICH IS CONNECTED TO THE AIR INTAKE. BOTH PARTS HAVE PROVEN TO BE EXTREMELY DIFFICULT TO TRACK DOWN. AFTER REPLACING THE "BREATHER HOSE", CCM THROTTLE CABLE, AND ALSO AN O2 SENSOR THE OVERALL COST FOR PARTS WAS $300 AND LABOR WAS $300. THANKFULLY NO INJURIES.

Mileage: 158,000

WHILE DRIVING, THE VEHICLE BEGAN TO ACCELERATE ON IT'S OWN. WHEN BRAKES WERE APPLIED THE RPMS SKY ROCKETED. TURNS OUT IT WAS A BROKEN CRUISE CONTROL MODULE CABLE THAT WOULD CAUSE THE THROTTLE TO GET "STUCK". AT THE SAME TIME IT WAS ALSO BOGGING OUT AND SHUTTING ITSELF OFF WHILE DRIVING. THE CHECK ENGINE LIGHT REMAINED ON THROWING A P071? CODE WHICH IS ASSOCIATED WITH O2 LEVELS.THIS TURNED OUT TO BE A BROKEN "BREATHER HOSE" WHICH IS CONNECTED TO THE AIR INTAKE. BOTH PARTS HAVE PROVEN TO BE EXTREMELY DIFFICULT TO TRACK DOWN. AFTER REPLACING THE "BREATHER HOSE", CCM THROTTLE CABLE, AND ALSO AN O2 SENSOR THE OVERALL COST FOR PARTS WAS $300 AND LABOR WAS $300. THANKFULLY NO INJURIES.

Mileage: 158,000

WHILE DRIVING, THE VEHICLE BEGAN TO ACCELERATE ON IT'S OWN. WHEN BRAKES WERE APPLIED THE RPMS SKY ROCKETED. TURNS OUT IT WAS A BROKEN CRUISE CONTROL MODULE CABLE THAT WOULD CAUSE THE THROTTLE TO GET "STUCK". AT THE SAME TIME IT WAS ALSO BOGGING OUT AND SHUTTING ITSELF OFF WHILE DRIVING. THE CHECK ENGINE LIGHT REMAINED ON THROWING A P071? CODE WHICH IS ASSOCIATED WITH O2 LEVELS.THIS TURNED OUT TO BE A BROKEN "BREATHER HOSE" WHICH IS CONNECTED TO THE AIR INTAKE. BOTH PARTS HAVE PROVEN TO BE EXTREMELY DIFFICULT TO TRACK DOWN. AFTER REPLACING THE "BREATHER HOSE", CCM THROTTLE CABLE, AND ALSO AN O2 SENSOR THE OVERALL COST FOR PARTS WAS $300 AND LABOR WAS $300. THANKFULLY NO INJURIES.

Mileage: 158,000

I PURCHASED 2 BF GOODRICH G-FORCE SPORT COMP-2 RADIAL 205/50.R16 87Z SL TIRES ON APRIL 15, 2019 FROM AMAZON, INSTALLED ON FRONT TIRE POSITIONS ON MAY 9, 2019. REAR TIRES ARE GENERAL G-MAX AS-03 WHICH ARE THE SAME SIZE AND WERE USED THE SUMMER BEFORE WITH NO ISSUES, STILL SIGNIFICANT TREAD LIFE LEFT AND NO DAMAGE. ALL FOUR TIRES WERE INFLATED TO 36 PSI AFTER INSTALLATION. WHEN DRIVING ON ANY KIND OF MOISTURE, RAIN NIGHT BEFORE OR DRIZZLE OR POURING RAIN, FRONT TIRES DO NOT GRIP ROAD SURFACE AND HAVE ALMOST LED TO NUMEROUS ACCIDENTS AT VARYING SPEEDS ON RURAL ROADS, CITY STREETS, AND HIGHWAYS, ANYWHERE FROM 20MPH TO 75MPH. I HAVE NOW BECOME USED TO THE DANGER OF THE BF GOODRICH TIRES AND DRIVE EXTREMELY SLOWLY IN WET CONDITIONS. AS I HAVE A MANUAL TRANSMISSION FRONT WHEEL DRIVE VEHICLE, I ALWAYS PUT THE NEW TIRES ON THE FRONT TO ENSURE TRACTION IN BAD WEATHER CONDITIONS, THE BF GOODRICH TIRES HAVE ALMOST GOTTEN ME KILLED MORE THAN A HANDFUL OF TIMES. AS STATED BY ANOTHER CONSUMER, I ALSO

Mileage: 166,000

TL* THE CONTACT OWNED A 2006 FORD FOCUS. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKES FAILED AND THE VEHICLE CRASHED INTO A TELEPHONE POLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT WAS NOT INJURED, BUT WAS TAKEN TO A MEDICAL EMERGENCY CENTER FOR OBSERVATION. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS TOWED AND DEEMED TOTALED BY THE INSURANCE COMPANY. THE CAUSE OF THE BRAKE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 117,459.

Mileage: 117,459

TAMARA RECALL. MY OUTSIDE DRIVERS SIDE DOOR HANDLE BROKE BECAUSE THE MECHANISM IS PLASTIC. NO ONE CAN FIX IT CORRECTLY AND IT KEEPS BREAKING SO NOW I CAN'T GET MY CAR INSPECTION DONE.

Mileage: 1,220,000

PASSENGER BACK DOOR LATCH BROKE. CAR DOOR TAPED

Mileage: 95,000

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT THE REAR PASSENGER AND DRIVER SIDE DOOR LATCHES FAILED. SHORTLY AFTER, THE FRONT DRIVER SIDE DOOR WAS UNABLE TO BE OPENED FROM OUTSIDE THE VEHICLE. THE DEALER WAS NOT CONTACTED. AN INDEPENDENT REPAIR FACILITY REPLACED THE REAR LATCHES AND STATED THAT THE DRIVER'S DOOR LATCH ALSO NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

REAR HATCH WIRING HARNESS HAS FRAYED WIRES AND CAN CAUSE A FIRE THERE IS RUBBING AGAINST WIRING HARNESS FROM THE RUBBER BOOT COVERING IT. THESE WIRES ARE LIVE AND CAUSE A FIRE AND ARE ALWAYS ON DUE TO CONNECTION TO ALL REAR ELECTRICAL COMPONENTS. I FOUND THIS OUT WHEN TRYING TO FIGURE OUT WHY MY REAR HATCH WOULD NOT OPEN UNLESS UNLOCKED WITH THE KEY.

Mileage: 100,000

HELLO NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, I WOULD LIKE TO CREATE A VEHICLE COMPLAINT REGARDING THE FORD FOCUS 2006 SEDAN ZX4 THAT I PURCHASED THE VEHICLE SEPTEMBER 20, 2017. WHILE DRIVING WITHIN A SERVICE ROAD, THE VEHICLE'S STALLED AND STOPPED RUNNING WHILE DRIVING UPON MULTIPLE INSTANCES OVER THE SAME DAY OF PURCHASING AND THROUGH OUT THE WEEKEND OF SEPTEMBER 22 - SEPTEMBER 30TH. AS A RESULT, I RETURNED THE VEHICLE TO THE DEALER OF LANSING POWER MOTORS INC. FOR AN INSPECTION SEPTEMBER 23, 2017. UPON COMPLETION OF THE INSPECTION, THE MECHANICS CONFIRMED THAT "NOTHING WAS WRONG WITH THE VEHICLE" AND SUGGESTED TO PURCHASE A NEW COMPUTER FOR THE VEHICLE. ON OCTOBER 30, 2017 I WAS INVOLVED IN A CAR ACCIDENT WHICH I THINK WAS DUE TO BAD ELECTRICAL BRAKES WHICH RESULTED IN THE VEHICLE BEING T-BONED BY ANOTHER DRIVER WITHIN A RESIDENTIAL INTERSECTION. THE VEHICLE CONTINUES TO STALL OR STOP COMPLETELY WHILE DRIVING AS OF MAY 14, 2018. IN ADDITION, NOTICED THAT ALL LIGHTS ON TH

Mileage: 1,302