Total Complaints
1 filings
FORD F-650 SD · model year
2011 FORD F-650 SD
1 NHTSA complaints, and 3 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2011FORDF-650 SD carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2011 F-650 SD is electrical system with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 3 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 177 investigation files overlapping the 2011 F-650 SD, and 8 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ELECTRICAL SYSTEM | 1 |
Recalls (3)
15V53300020/08/2015
SEAT BELTS:FRONT:ANCHORAGE
Ford Motor Company (Ford) is recalling certain model year 2011-2013 and 2015 Ford F-650, and F-750 trucks manufactured February 14, 2011, to April 28, 2015, and equipped with a 70% fixed bench passenger seat. The affected vehicles have passenger seat belt anchorage floor attachments that are not in
12V00900012/01/2012
POWER TRAIN:AXLE ASSEMBLY
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-650 TRUCKS, MANUFACTURED FROM FEBRUARY 2, 2011, THROUGH FEBRUARY 17, 2011, AND EQUIPPED WITH A MERITOR MFS08 FRONT STEER AXLE. THE BOLTS ATTACHING THE STEERING ARM TO THE STEERING KNUCKLE WERE NOT PROPERLY TIGHTENED. THIS CONDITION CAN RESULT IN THE STEE
11V26400003/05/2011
SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-650 AND F-750 TRUCKS, EQUIPPED WITH AIR BRAKES AND A TRAILER PACKAGE OR TRACTOR PACKAGE, FOR AN INCORRECTLY PROGRAMMED ABS MODULE. AS SUCH, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SY
Recent Complaints
20120806ELECTRICAL SYSTEM
WHILE THE VEHICLE WAS BEING OPERATED IN THE NORMAL COURSE OF BUSINESS A FAULTY ELECTRIC AIR CONTROL MODULE (PART NUMBER 4C4Z-5K862-AA) OVER HEATED, MELTED AND BURNED. THIS CAUSED THE CAB OF THE VEHICLE TO FILL WITH SMOKE AND THE AIR BRAKES AND OTHER AIR DEVICES TO MALFUNCTION.
Mileage: 11,000
Compare 2011FORDF-650 SD to Similar Vehicles
NHTSA Investigations 8 Open
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationOpen
Timing Belt Failure
DP25001Defect PetitionOpen
Underbody shields detachment
PE25007Preliminary EvaluationOpen
B-Pillar Trim Detachment
PE25002Preliminary EvaluationClosed
Unintended Transmission Downshift and Rear Wheel Lock-up
Frequently Asked Questions
How many complaints does the 2011 FORD F-650 SD have?▼
The 2011 FORD F-650 SD has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2011 FORD F-650 SD?▼
Yes, the 2011 FORD F-650 SD has 3 recall(s). The most common affected component is SEAT BELTS:FRONT:ANCHORAGE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2011 FORD F-650 SD?▼
The most-complained component for the 2011 FORD F-650 SD is ELECTRICAL SYSTEM with 1 complaints. Other frequently reported areas include various components.
Is the 2011 FORD F-650 SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.