Total Complaints
1 filings
FORD F-650 SD · model year
2009 FORD F-650 SD
1 NHTSA complaints, and 3 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2009FORDF-650 SD carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2009 F-650 SD is service brakes with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 3 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 179 investigation files overlapping the 2009 F-650 SD, and 6 remain open. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES | 1 |
Recalls (3)
08V42800025/08/2008
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.
09V47600015/12/2009
EXTERIOR LIGHTING
FORD IS RECALLING MODEL YEARS 2009 F-650 AND F-750 TRUCKS. THE CHASSIS WIRE HARNESS MAY HAVE BEEN ASSEMBLED WITHOUT A CONNECTOR SEAL IF THIS SEAL IS MISSING, THE CONNECTOR TERMINALS MAY CORRODE AFFECTING THE PROPER ILLUMINATION OF THE VEHICLE'S REAR BRAKE LAMPS, TAIL LAMPS, TURN SIGNAL LAMPS OR TR
10V39800009/09/2010
ENGINE AND ENGINE COOLING
FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.
Recent Complaints
20170209SERVICE BRAKES
TL* THE CONTACT OWNS A 2009 FORD F-650 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKES FAILED TO RESPOND. THE CONTACT HAD TO MAKE A SHARP LEFT TURN TO AVOID CRASHING INTO A VEHICLE. THE EMERGENCY BRAKE WAS ACTIVATED AND SHIFTED THE GEAR SHIFTER INTO SLOW RANGE TO BE ABLE TO CONTINUE DRIVING THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT A CONTROL UNIT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000. UPDATED 05/19/17*LJ *CN
Mileage: 17,000
Compare 2009FORDF-650 SD to Similar Vehicles
NHTSA Investigations 6 Open
EA26004Engineering AnalysisOpen
Timing Belt Failure
DP26004Defect PetitionOpen
Anti-lock brake system (ABS) Malfunction Indicator Lamp (MIL) illuminated
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationClosed
Timing Belt Failure
DP25001Defect PetitionClosed
Underbody shields detachment
Frequently Asked Questions
How many complaints does the 2009 FORD F-650 SD have?▼
The 2009 FORD F-650 SD has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2009 FORD F-650 SD?▼
Yes, the 2009 FORD F-650 SD has 3 recall(s). The most common affected component is ENGINE AND ENGINE COOLING:ENGINE:DIESEL. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2009 FORD F-650 SD?▼
The most-complained component for the 2009 FORD F-650 SD is SERVICE BRAKES with 1 complaints. Other frequently reported areas include various components.
Is the 2009 FORD F-650 SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2009 FORD F-650 SD; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.