Total Complaints
3 filings
FORD F-650 · model year
2011 FORD F-650
3 NHTSA complaints, and 2 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2011FORDF-650 carries 3 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2011 F-650 is service brakes with 2 filings, followed by engine (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 2 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 177 investigation files overlapping the 2011 F-650, and 8 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
3
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES | 2 |
| ENGINE | 1 |
Recalls (2)
12V09700007/03/2012
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-650 AND F-750 TRUCKS, MANUFACTURED FROM DECEMBER 3, 2010, THROUGH DECEMBER 20, 2011, EQUIPPED WITH BENDIX ATR-6 ANTILOCK TRACTION RELAY VALVES. IN EXTREMELY COLD CONDITIONS, THE BENDIX RELAY VALVES MAY POTENTIALLY DEVELOP INTERNAL LEAKAGE. INTERNAL LEAKA
12V56200003/12/2012
EQUIPMENT:ELECTRICAL
Phenix Enterprises, Inc. (Phenix) is recalling certain model year 2009 and 2011 trucks manufactured from July 22, 2008, through December 16, 2011, equipped with a Sure Power battery separator, part number 16511893 (model 1314). Suspect vehicles, in their as-built configuration, had a Sure Power bat
Recent Complaints
20190322SERVICE BRAKES
TL* THE CONTACT OWNS A 2011 FORD F-650. WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE LOST POWER AND STALLED AND THE BRAKE AND CHECK ENGINE INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE ABS CONTROL MODULE AND MASTER CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS TOWED TO LEE SMITH FORD (2600 8TH AVE, CHATTANOOGA, TN 37407, (423) 622-4161) WHERE IT WAS DIAGNOSED THAT THE BRAKE CONTROL MODULE AND ENGINE KNOCK SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. CONSUMER STATED OVER THE COURSE OF 4 YEARS THERE HAS BEEN MANY RE-OCCURRENCES OF FAILURE. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBERS: 16982432 AND 16784821. THE FAILURE MILEAGE WAS 12,401. *BF *JB
Mileage: 12,401
20190322ENGINE
TL* THE CONTACT OWNS A 2011 FORD F-650. WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE LOST POWER AND STALLED AND THE BRAKE AND CHECK ENGINE INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE ABS CONTROL MODULE AND MASTER CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS TOWED TO LEE SMITH FORD (2600 8TH AVE, CHATTANOOGA, TN 37407, (423) 622-4161) WHERE IT WAS DIAGNOSED THAT THE BRAKE CONTROL MODULE AND ENGINE KNOCK SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. CONSUMER STATED OVER THE COURSE OF 4 YEARS THERE HAS BEEN MANY RE-OCCURRENCES OF FAILURE. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBERS: 16982432 AND 16784821. THE FAILURE MILEAGE WAS 12,401. *BF *JB
Mileage: 12,401
20170404SERVICE BRAKES
REPLACED HPB SYSTEM, CONFIGURED ABS MODUAL, AND BLED BRAKE SYSTEM ON MY 2011 F650 MEDIUM DUTY COMMERCIAL TRUCK. FORD REFUSES TO REIMBURSE THE COST ($4722.60) EVEN THOUGH THE REPAIRS WERE PERFORMED BY A FORD AUTHORIZED DEALERSHIP.
Compare 2011FORDF-650 to Similar Vehicles
NHTSA Investigations 8 Open
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationOpen
Timing Belt Failure
DP25001Defect PetitionOpen
Underbody shields detachment
PE25007Preliminary EvaluationOpen
B-Pillar Trim Detachment
PE25002Preliminary EvaluationClosed
Unintended Transmission Downshift and Rear Wheel Lock-up
Frequently Asked Questions
How many complaints does the 2011 FORD F-650 have?▼
The 2011 FORD F-650 has 3 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2011 FORD F-650?▼
Yes, the 2011 FORD F-650 has 2 recall(s). The most common affected component is SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2011 FORD F-650?▼
The most-complained component for the 2011 FORD F-650 is SERVICE BRAKES with 2 complaints. Other frequently reported areas include ENGINE.
Is the 2011 FORD F-650 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.