Total Complaints
1 filings
Ford F-550 SD · model year
2009 Ford F-550 SD
1 NHTSA complaints, and 5 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
- Complaints
- 1
- Recalls
- 5
The verdict
The 2009 Ford F-550 SD posts top-1% complaint standing (fewest filings) among its own model-year siblings.
- Top 0%
- fewest complaints, own model years
- 5
- recall campaigns
The 2009FordF-550 SD carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2009 F-550 SD is fuel system, diesel with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 5 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 179 investigation files overlapping the 2009 F-550 SD, and 6 remain open. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
F
PlainCars Safety Score
0/100
2009 Ford F-550 SD
PlainCars' own composite of NHTSA NCAP crash-test ratings and rollover-risk assessment, each dimension normalized against the federal scale or the full national model-year corpus. Not an official NHTSA figure, and not a substitute for a specific vehicle's VIN-level recall check.
NHTSA Overall Rating N/A
Not rated
NHTSA New Car Assessment Program overall crash-test rating.
Front Crash N/A
Not rated
Frontal barrier crash-test rating.
Side Crash N/A
Not rated
Side barrier and pole crash-test rating.
Rollover Resistance N/A
Not rated
Static stability factor + dynamic rollover test rating.
Rollover Risk N/A
Not reported
NHTSA single-vehicle rollover probability, dynamic test.
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| FUEL SYSTEM, DIESEL | 1 |
Recalls (5)
14V36000023/06/2014
EQUIPMENT
Palfleet Truck Equipment Company, LLC (Palfleet) is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 super duty vehicles modified by Palfleet and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a
14V33600018/06/2014
EQUIPMENT
Dual-Tech, Inc. (Dual-Tech) is recalling certain model year 2009-2014 Ford F-550 Super Duty trucks modified by Dual-Tech, equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
14V32800013/06/2014
EQUIPMENT
Iowa Mold Tooling Co., Inc. will notify owners and dealers to inspect the Muncie PTO pressure switch to determine if it is from the range of defective switches and if required, remove the pressure switch assembly and put a plug in the port where the PTO switch had been installed. This switch was nev
14V32700012/06/2014
EQUIPMENT
Stahl is recalling certain model year 2009-2014 Ford F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty vehicles modified by Stahl and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket coverin
14V38200010/06/2014
EQUIPMENT
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil
Recent Complaints
20140724FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2009 FORD 550 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THERE WAS A LOUD RATTLING SOUND AS THEN THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED AND TAKEN TO THE DEALER WHERE THE MECHANIC DIAGNOSED THAT THE FUEL PUMP, FILTERS AND SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, WHO ADVISED THE CONTACT THAT THE PROBLEM WAS NOT COVERED UNDER THE WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 42,608. UPDATED 9/24/14*CN
Mileage: 42,608
Compare 2009FordF-550 SD to Similar Vehicles
NHTSA Investigations 6 Open
EA26004Engineering AnalysisOpen
Timing Belt Failure
DP26004Defect PetitionOpen
Anti-lock brake system (ABS) Malfunction Indicator Lamp (MIL) illuminated
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationClosed
Timing Belt Failure
DP25001Defect PetitionClosed
Underbody shields detachment
Vehicle Safety Guides
Frequently Asked Questions
How many complaints does the 2009 Ford F-550 SD have?▼
The 2009 Ford F-550 SD has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2009 Ford F-550 SD?▼
Yes, the 2009 Ford F-550 SD has 5 recall(s). The most common affected component is EQUIPMENT. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2009 Ford F-550 SD?▼
The most-complained component for the 2009 Ford F-550 SD is FUEL SYSTEM, DIESEL with 1 complaints. Other frequently reported areas include various components.
Is the 2009 Ford F-550 SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2009 Ford F-550 SD; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.