Total Complaints
1 filings
FORD F-450 SD · model year
2016 FORD F-450 SD
1 NHTSA complaints, and 3 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2016FORDF-450 SD carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2016 F-450 SD is service brakes with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 3 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.
NHTSA currently has 177 investigation files overlapping the 2016 F-450 SD, and 8 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| SERVICE BRAKES | 1 |
Recalls (3)
16V24600026/04/2016
TIRES:SIDEWALL
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air
22V33700013/05/2022
AIR BAGS:FRONTAL:DRIVER CLOCKSPRING/SPIRAL CASSETTE
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
25V57200004/09/2025
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distort
Recent Complaints
20180516SERVICE BRAKES
WHILE DRIVING AT HIGHWAY SPEEDS WITH A TRAILER AND A LOAD CONNECTED TO THE TRUCK THE CHECK BRAKE SYSTEM MESSAGE SUDDENLY APPEARED WITHIN THE MESSAGE DISPLAY, AS WELL AS THE ABS LIGHT, TRACTION CONTROL LIGHT, AND THE PARKING BRAKE LIGHT. IMMEDIATELY WE ATTEMPTED TO SLOW DOWN AND PULL OFF TO THE SIDE OF THE ROAD. FORTUNATELY TRAFFIC WAS NOT TOO CONGESTED AROUND US AND WE WERE DRIVING ON A RELATIVELY FLAT ROAD AT THE TIME. THE VEHICLE HAD LOST VIRTUALLY ALL BRAKING POWER AND THE WE BASICALLY HAD TO COAST TO A COMPLETE STOP. THE VEHICLE IS A 2016 FORD F-450 SUPER DUTY CREW CAB TOWING A 25' GOOSENECK TRAILER WITH ONLY 71,000 MILES ON THE TRUCK. THIS COULD HAVE BEEN AN ABSOLUTE CATASTROPHE HAD WE BEEN HAULING A HEAVIER LOAD AND DRIVING DOWN A DOWNHILL GRADE! THIS SHOULD NOT HAPPEN WITHOUT ANY KIND OF WARNING WHATSOEVER! FORD NEEDS TO FIX THIS ISSUE BEFORE IT RESULTS IN DEATH OR SERIOUS INJURY! *DT*JB
Mileage: 71,000
Compare 2016FORDF-450 SD to Similar Vehicles
NHTSA Investigations 8 Open
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationOpen
Timing Belt Failure
DP25001Defect PetitionOpen
Underbody shields detachment
PE25007Preliminary EvaluationOpen
B-Pillar Trim Detachment
PE25002Preliminary EvaluationClosed
Unintended Transmission Downshift and Rear Wheel Lock-up
Frequently Asked Questions
How many complaints does the 2016 FORD F-450 SD have?▼
The 2016 FORD F-450 SD has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2016 FORD F-450 SD?▼
Yes, the 2016 FORD F-450 SD has 3 recall(s). The most common affected component is TIRES:SIDEWALL. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2016 FORD F-450 SD?▼
The most-complained component for the 2016 FORD F-450 SD is SERVICE BRAKES with 1 complaints. Other frequently reported areas include various components.
Is the 2016 FORD F-450 SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology - how this data is sourced, computed, and verified.