Total Complaints
2 filings
FORD F-450 SD · model year
2015 FORD F-450 SD
2 NHTSA complaints, and 4 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2015FORDF-450 SD carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2015 F-450 SD is engine with 1 filings, followed by fuel/propulsion system (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 4 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.
NHTSA currently has 177 investigation files overlapping the 2015 F-450 SD, and 8 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE | 1 |
| FUEL/PROPULSION SYSTEM | 1 |
Recalls (4)
15V17500025/03/2015
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Ford Motor Company (Ford) is recalling certain model year 2011-2015 Ford F-350, F-450, and F-550 trucks manufactured February 22, 2010, to January 30, 2015, and equipped with ambulance or fire engine preparation packages. The affected vehicles may detect an incorrect Exhaust Gas Temperature Sensor
15V02400022/01/2015
SUSPENSION
Life Line Emergency Vehicles (Life Line) is recalling certain model year 2014-2015 Life Line-modified Ford F-Series emergency vehicles that are equipped with Liquid Spring-brand aftermarket suspension kits. The mounting bracket that attaches the suspension fluid tank to the frame may fail allowing t
14V20400017/04/2014
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Ford Motor Company (Ford) is recalling certain model year 2015 F-250, F-350, F-450, and F-550 Super Duty trucks manufactured September 13, 2013, through March 28, 2014, and equipped with 6.2L gasoline or 6.7L diesel engines and 6R140 transmissions. An error with the transmission control software ma
25V57200004/09/2025
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distort
Recent Complaints
20141002ENGINE
TL* THE CONTACT OWNS A 2015 FORD F-450 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP AND MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 650.
Mileage: 650
20141002FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2015 FORD F-450 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP AND MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 650.
Mileage: 650
Compare 2015FORDF-450 SD to Similar Vehicles
NHTSA Investigations 8 Open
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationOpen
Timing Belt Failure
DP25001Defect PetitionOpen
Underbody shields detachment
PE25007Preliminary EvaluationOpen
B-Pillar Trim Detachment
PE25002Preliminary EvaluationClosed
Unintended Transmission Downshift and Rear Wheel Lock-up
Frequently Asked Questions
How many complaints does the 2015 FORD F-450 SD have?▼
The 2015 FORD F-450 SD has 2 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2015 FORD F-450 SD?▼
Yes, the 2015 FORD F-450 SD has 4 recall(s). The most common affected component is POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2015 FORD F-450 SD?▼
The most-complained component for the 2015 FORD F-450 SD is ENGINE with 1 complaints. Other frequently reported areas include FUEL/PROPULSION SYSTEM.
Is the 2015 FORD F-450 SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology - how this data is sourced, computed, and verified.