Total Complaints
4 filings
Ford F-450 SD · model year
2010 Ford F-450 SD
4 NHTSA complaints, and 6 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
- Complaints
- 4
- Recalls
- 6
The verdict
The 2010 Ford F-450 SD posts below-average complaint volume among its own model-year siblings.
- Top 32%
- fewest complaints, own model years
- 6
- recall campaigns
The 2010FordF-450 SD carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2010 F-450 SD is engine and engine cooling:exhaust system with 1 filings, followed by fuel system, diesel (1) and engine and engine cooling:engine:diesel (1). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 6 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 179 investigation files overlapping the 2010 F-450 SD, and 6 remain open. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
F
PlainCars Safety Score
0/100
2010 Ford F-450 SD
PlainCars' own composite of NHTSA NCAP crash-test ratings and rollover-risk assessment, each dimension normalized against the federal scale or the full national model-year corpus. Not an official NHTSA figure, and not a substitute for a specific vehicle's VIN-level recall check.
NHTSA Overall Rating N/A
Not rated
NHTSA New Car Assessment Program overall crash-test rating.
Front Crash N/A
Not rated
Frontal barrier crash-test rating.
Side Crash N/A
Not rated
Side barrier and pole crash-test rating.
Rollover Resistance N/A
Not rated
Static stability factor + dynamic rollover test rating.
Rollover Risk N/A
Not reported
NHTSA single-vehicle rollover probability, dynamic test.
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 1 |
| FUEL SYSTEM, DIESEL | 1 |
| ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 1 |
| TIRES:TREAD/BELT | 1 |
Recalls (6)
14V45300024/07/2014
EQUIPMENT
Godwin Manufacturing Company, Inc. (Godwin) is recalling certain model year 2010 Ford F-450; 2011 Ford F-550; 2012 Ford F-350 and 2013 F-350 Super Duty trucks modified by Godwin and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO press
14V36000023/06/2014
EQUIPMENT
Palfleet Truck Equipment Company, LLC (Palfleet) is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 super duty vehicles modified by Palfleet and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a
14V32800013/06/2014
EQUIPMENT
Iowa Mold Tooling Co., Inc. will notify owners and dealers to inspect the Muncie PTO pressure switch to determine if it is from the range of defective switches and if required, remove the pressure switch assembly and put a plug in the port where the PTO switch had been installed. This switch was nev
14V32700012/06/2014
EQUIPMENT
Stahl is recalling certain model year 2009-2014 Ford F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty vehicles modified by Stahl and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket coverin
14V37900010/06/2014
EQUIPMENT
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-55
14V38200010/06/2014
EQUIPMENT
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil
Recent Complaints
20231211TIRES:TREAD/BELT
LT275/70R18 E While driving west on I10 near Thermal California, the rear driver side tire lost 100% of its thread at a 65 MPH speed. When the thread separated from the tire it damaged fender area of the truck extensively and caused a violent throw and shake of the rear of the truck. The interesting fact is that even after losing 100% of the thread he tire steel belts exposed the tire stayed inflated at 80PSI. This fact is know because I was actively monitoring TPMS tire pressure while safely pulling over. The tries were inspected and pressure levels were checked prior taking off for the trip to Thermal CA to pick up the family 5th wheel camper. These tires supposed to have a thread life of 60,000 miles, mine had reached 32000 miles. At this point there is a huge concern and low confidence in Goodyear brand tire and this may happen to the other tires on my truck and may happen under the load of the 35 foot family RV. No one was injured, and no one reproduced this problem and the manuf
20121018FUEL SYSTEM, DIESEL
2010 FORD F-450. CONSUMER WRITES IN REGARDS TO DIESEL FUEL GETTING INTO OIL DUE TO OPEN INJECTORS. *TGW THE CONSUMER ALSO STATED ENGINE LIGHT ILLUMINATED AND THE EXHAUST WAS EMITTING SMOKE.
Mileage: 10,000
20121018ENGINE AND ENGINE COOLING:ENGINE:DIESEL
2010 FORD F-450. CONSUMER WRITES IN REGARDS TO DIESEL FUEL GETTING INTO OIL DUE TO OPEN INJECTORS. *TGW THE CONSUMER ALSO STATED ENGINE LIGHT ILLUMINATED AND THE EXHAUST WAS EMITTING SMOKE.
Mileage: 10,000
20100926ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
2010 FORD F-350 6.4 DIESEL GOES INTO "CLEANING EXHAUST FILTER" MODE AND ENGINE BEGINS SKIPPING AT HIGHWAYS SPEEDS. WHEN AT A STOPLIGHT/SIGN, IT WILL ALMOST SHUT DOWN. WHEN ACCELERATE FROM LIGHT/SIGN, GREY/BLUE SMOKE STREAMS FROM VEHICLE. DEALER STATES THEY HAVE NOT HAD ANY REPORTED PROBLEMS AND CAN NOT IDENTIFY ANY ISSUES BECAUSE THEY CAN NOT RE-CREATE THE REPORTED PROBLEM. VEHICLE NOW HAS 14000 MILES. *TR
Mileage: 12,000
Compare 2010FordF-450 SD to Similar Vehicles
NHTSA Investigations 6 Open
EA26004Engineering AnalysisOpen
Timing Belt Failure
DP26004Defect PetitionOpen
Anti-lock brake system (ABS) Malfunction Indicator Lamp (MIL) illuminated
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationClosed
Timing Belt Failure
DP25001Defect PetitionClosed
Underbody shields detachment
Vehicle Safety Guides
Frequently Asked Questions
How many complaints does the 2010 Ford F-450 SD have?▼
The 2010 Ford F-450 SD has 4 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2010 Ford F-450 SD?▼
Yes, the 2010 Ford F-450 SD has 6 recall(s). The most common affected component is EQUIPMENT. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2010 Ford F-450 SD?▼
The most-complained component for the 2010 Ford F-450 SD is ENGINE AND ENGINE COOLING:EXHAUST SYSTEM with 1 complaints. Other frequently reported areas include FUEL SYSTEM, DIESEL and ENGINE AND ENGINE COOLING:ENGINE:DIESEL.
Is the 2010 Ford F-450 SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2010 Ford F-450 SD; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.