Total Complaints
1 filings
FORD F-350 SD · model year
2020 FORD F-350 SD
1 NHTSA complaints, and 16 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2020FORDF-350 SD carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2020 F-350 SD is power train with 1 filings. Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 16 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle, the full NHTSA campaign numbers are listed below.
NHTSA currently has 177 investigation files overlapping the 2020 F-350 SD, and 8 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page, a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| POWER TRAIN | 1 |
Recalls (16)
22V64400026/08/2022
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
20V57500023/09/2020
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or dist
20V36500023/06/2020
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in orde
24V95700020/12/2024
FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
25V62600019/09/2025
STEERING:COLUMN
Ford Motor Company (Ford) is recalling certain 2020-2021 F-250, F-350, and F-450 vehicles. The steering column upper shaft may detach from the steering column and result in a loss of steering control.
21V08700018/02/2021
EQUIPMENT:OTHER:LABELS
Ford Motor Company (Ford) is recalling certain 2020 F-Super Duty F350 vehicles equipped with a 6.7L diesel engine, single rear wheels (SRW), 4X4 Crew Cab, Long Box, and a 12k or 12.4k Gross Vehicle Weight Rating. These vehicles may display overstated payload capacity values on the Tire and Loading
21V09000018/02/2021
VISIBILITY:WINDSHIELD:CRITICAL FASTENERS
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requi
26V15800017/03/2026
FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the hi
22V08700016/02/2022
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
21V53600015/07/2021
POWER TRAIN:AXLE ASSEMBLY
Ford Motor Company (Ford) is recalling certain 2020-2021 F-350 Super Duty pickup trucks equipped with 6.7L diesel engines and Dana model 275 rear axles. The rear axle housing may not support the load of the pickup truck and deform, which could result in driveshaft separation.
22V25000014/04/2022
VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
22V25600014/04/2022
POWER TRAIN:AUTOMATIC TRANSMISSION
Ford Motor Company (Ford) is recalling certain 2020 Super Duty F-250, F-350, F-450, and F-550 vehicles equipped with 6.7L diesel engines. A washer within the vehicle's transmission can disintegrate, causing metallic debris to become lodged in the 'Park' mechanism.
25V68600010/10/2025
BACK OVER PREVENTION:SOFTWARE
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
21V15500010/03/2021
TIRES
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
20E09000009/12/2020
STEERING
Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, p
23V42000009/06/2023
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head re
Recent Complaints
20240630POWER TRAIN
Ford 10R140 Transmission Issues: Transmission has harsh engagement, clunks and slams into gear. Transmission gets stuck in between gears while in motion at all speeds while driving on city streets or on the freeway. Transmission LURCHES forward when shifting from park into drive even when applying the brake and when the parking brake is engaged. This transmission is UNSAFE and UNRELIABLE!!!!
Compare 2020FORDF-350 SD to Similar Vehicles
NHTSA Investigations 8 Open
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationOpen
Timing Belt Failure
DP25001Defect PetitionOpen
Underbody shields detachment
PE25007Preliminary EvaluationOpen
B-Pillar Trim Detachment
PE25002Preliminary EvaluationClosed
Unintended Transmission Downshift and Rear Wheel Lock-up
Frequently Asked Questions
How many complaints does the 2020 FORD F-350 SD have?▼
The 2020 FORD F-350 SD has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2020 FORD F-350 SD?▼
Yes, the 2020 FORD F-350 SD has 16 recall(s). The most common affected component is BACK OVER PREVENTION: SENSING SYSTEM: CAMERA. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2020 FORD F-350 SD?▼
The most-complained component for the 2020 FORD F-350 SD is POWER TRAIN with 1 complaints. Other frequently reported areas include various components.
Is the 2020 FORD F-350 SD safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology - how this data is sourced, computed, and verified.