2001 FORD EXPLORER SPORT

STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES WITH STEEL HOODS AND CERTAIN PICKUP TRUCKS EQUIPPED WITH SHEET MOLDING COMPOUND HOODS. A WIRE FORMED HOOD STRIKER COULD BE SUSCEPTIBLE TO FATIGUE FRACTURES. IF THE HOOD STRIKER FRACTURES, THE HOOD COULD FLY OPEN WHILE THE VEHICLE IS BEING DRIVEN.

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D

TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN

SEATS:FRONT ASSEMBLY:RECLINER

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEA

VEHICLE SPEED CONTROL:CABLES

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.

SEATS:FRONT ASSEMBLY:RECLINER

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MA

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

CRUISE CONTROL ON AND SET DO NOT WORK ON ANY ROAD. VEHICLE MOVING ON ANY ROAD OR STANDSTILL.

Mileage: 160,000

PASSENGER SIDE DOOR HANDLE BROKE ONLY OPENS FROM INSIDE. PASSENGER REAR DOOR ONLY OPENS FROM OUTSIDE. DRIVERS SIDE REAR ONLY OPENS FROM OUTSIDE. 3 OUT OF 4 DOORS DO NOT WORK PROPERLY. THIS IS A SAFETY ISSUE. I HAVE SMALL CHILDREN WHO ARE IN REAR CAR SEATS AND CAN'T GET THEM OUT IF EMERGENCY!!! THIS SHOULD BE RECALL WITH THIS MANY COMPLAINTS ON SAME MODEL AND BECAUSE IT POSES SAFETY ISSUE

Mileage: 130,000

---- THIS VEHICLE DOES NOT HAVE A SEAT BELT FOR A PASSENGER RIDING IN THE MIDDLE OF THE REAR SEAT. THE REAR SEAT HAS AMPLE SPACE FOR THREE FULL-SIZED ADULTS, BUT THERE IS NO SEAT BELT FOR A MIDDLE PASSENGER. THE FORD ORIGINAL SHOP MANUAL INDICATES THAT THERE ARE NOT ANY SECURE ATTACHMENT POINTS TO INSTALL A 3RD-PARTY BELT BUILT INTO THE BODY. ---- THIS IS A SAFETY HAZARD AND MAY MAKE IT ILLEGAL TO CARRY A THIRD PASSENGER IN THE REAR SEAT. NHTSA SHOULD RECALL THESE VEHICLES AND DIRECT FORD TO PROVIDE SEAT BELTS FOR A CENTER PASSENGER IN THE REAR SEAT. THANK YOU FOR YOUR CONSIDERATION. *TR

Mileage: 110,000

DRIVER SEAT BOLT

DRIVER SEAT BOLT

DRIVER SEAT BOLT

IF STEERING WHEEL IS NOT IN THE VERY HIGH POSITION TURN SIGNALS BLINK VERY RAPIDLY AS IF THERE WAS A PROBLEM WITH ONE OF THEM.

Mileage: 155,000

AS MANY OTHER OWNERS OF THE FORD EXPLORER SPORT HAVE COMPLAINED ABOUT, THERE IS A VERY LOUD BANGING COMING FROM THE REAR END OF MY SUV WHENEVER I DRIVE OVER EVEN THE SLIGHTEST BUMP OR ROUGH ROAD. I HAVE REPLACED THE SHOCKS BUT IT DID NOT MAKE ANY DIFFERENCE TO THIS PROBLEM. IT STILL IS SO LOUD AND THE RIDE REMAINS VERY ROUGH. I NOW UNDERSTAND THAT THE BODY MOUNT BUSHINGS HAVE DETERIORATED AND WILL NEED TO BE REPLACED TO IMPROVE THE RIDE AND MAKE THE VEHICLE SAFE TO DRIVE AGAIN. *TR

Mileage: 156,000

2001 FORD EXPLORER SPORT. DURING NORMAL DRIVING, A REAR RATTLE/ BANGING NOISE WOULD OCCUR WHEN GOING OVER ROUGH ROAD OR OVER BUMPS. THIS HAS PROGRESSIVELY GOTTEN WORSE OVER TIME. INVESTIGATION AND INSPECTION OF THE VEHICLE HAD REVEALED THAT ALL THE BODY/FRAME MOUNT BUSHINGS HAVE DETERIORATED TO THE POINT THAT THEY WERE CRUMBLING, LEAVING NO SUPPORT/CUSHION BETWEEN BODY AND FRAME. THIS COULD POTENTIALLY MAKE THE VEHICLE UNSAFE AS THERE WOULD BE NO SUPPORT FOR THE BODY, CAUSE EXCESSIVE BODY MOVEMENT AND A SHIFT IN THE VEHICLE WEIGHT DYNAMICS. THIS ISSUE HAS ALREADY BEEN REPORTED IN SEVERAL VEHICLE SAFETY COMPLAINTS PRIOR TO MINE. *TR

Mileage: 74,500

2001 FORD EXPLORER SPORT. DURING NORMAL DRIVING, A REAR RATTLE/ BANGING NOISE WOULD OCCUR WHEN GOING OVER ROUGH ROAD OR OVER BUMPS. THIS HAS PROGRESSIVELY GOTTEN WORSE OVER TIME. INVESTIGATION AND INSPECTION OF THE VEHICLE HAD REVEALED THAT ALL THE BODY/FRAME MOUNT BUSHINGS HAVE DETERIORATED TO THE POINT THAT THEY WERE CRUMBLING, LEAVING NO SUPPORT/CUSHION BETWEEN BODY AND FRAME. THIS COULD POTENTIALLY MAKE THE VEHICLE UNSAFE AS THERE WOULD BE NO SUPPORT FOR THE BODY, CAUSE EXCESSIVE BODY MOVEMENT AND A SHIFT IN THE VEHICLE WEIGHT DYNAMICS. THIS ISSUE HAS ALREADY BEEN REPORTED IN SEVERAL VEHICLE SAFETY COMPLAINTS PRIOR TO MINE. *TR

Mileage: 74,500

A CLUNKING NOISE UNDER THE PASSENGER SEAT. IN LOOKING AT IT, IS SEEMS THERE IS A WORN BODY BUSHING. INVESTIGATION ON THE WEB SHOWS SEVERAL INCIDENCES OF SOMETHING LIKE THIS. THE NOISE HAS GOTTEN WORSE, THE VEHICLE NOW HAS 54000 MILES ON IT.I AM THE ORIGINAL OWNER. *TR

Mileage: 40,000

ALL BODY BUSHINGS WERE DEFECTIVE AND HAD TO BE REPLACED. THE BUSHINGS WERE DESICCATED AND HAD CRUMBLED AWAY. THIS MADE THE VEHICLE UNSAFE WHEN CORNERING AS THERE WAS NOTHING TO SUPPORT THE WEIGHT OF THE BODY BETWEEN IT AND THE FRAME CAUSING EXCESSIVE MOVEMENT AND COMPROMISE OF CENTER OF GRAVITY. ACCORDING TO THE MECHANIC WHO REPLACED MY BUSHINGS, HE HAD SEEN THIS DEFECT ON ALL THE VEHICLES OF THIS MAKE AND MODEL YEAR. HE SAID THAT IT WAS NOT A PROBLEM ON THE 1998 FORD EXPLORER SPORT. I WENT TO A LOCAL JUNK YARD AND LOOKED AT SEVERAL FORD EXPLORER SPORTS AND NOTICED THE SAME DEFECT ON ALL THE 2001 MODEL YEARS. THE 1998 MODEL YEAR HAD BUSHINGS THAT WERE STILL IN GOOD CONDITION. *JS

Mileage: 204,551

ALL BODY BUSHINGS WERE DEFECTIVE AND HAD TO BE REPLACED. THE BUSHINGS WERE DESICCATED AND HAD CRUMBLED AWAY. THIS MADE THE VEHICLE UNSAFE WHEN CORNERING AS THERE WAS NOTHING TO SUPPORT THE WEIGHT OF THE BODY BETWEEN IT AND THE FRAME CAUSING EXCESSIVE MOVEMENT AND COMPROMISE OF CENTER OF GRAVITY. ACCORDING TO THE MECHANIC WHO REPLACED MY BUSHINGS, HE HAD SEEN THIS DEFECT ON ALL THE VEHICLES OF THIS MAKE AND MODEL YEAR. HE SAID THAT IT WAS NOT A PROBLEM ON THE 1998 FORD EXPLORER SPORT. I WENT TO A LOCAL JUNK YARD AND LOOKED AT SEVERAL FORD EXPLORER SPORTS AND NOTICED THE SAME DEFECT ON ALL THE 2001 MODEL YEARS. THE 1998 MODEL YEAR HAD BUSHINGS THAT WERE STILL IN GOOD CONDITION. *JS

Mileage: 204,551

ALL BODY BUSHINGS WERE DEFECTIVE AND HAD TO BE REPLACED. THE BUSHINGS WERE DESICCATED AND HAD CRUMBLED AWAY. THIS MADE THE VEHICLE UNSAFE WHEN CORNERING AS THERE WAS NOTHING TO SUPPORT THE WEIGHT OF THE BODY BETWEEN IT AND THE FRAME CAUSING EXCESSIVE MOVEMENT AND COMPROMISE OF CENTER OF GRAVITY. ACCORDING TO THE MECHANIC WHO REPLACED MY BUSHINGS, HE HAD SEEN THIS DEFECT ON ALL THE VEHICLES OF THIS MAKE AND MODEL YEAR. HE SAID THAT IT WAS NOT A PROBLEM ON THE 1998 FORD EXPLORER SPORT. I WENT TO A LOCAL JUNK YARD AND LOOKED AT SEVERAL FORD EXPLORER SPORTS AND NOTICED THE SAME DEFECT ON ALL THE 2001 MODEL YEARS. THE 1998 MODEL YEAR HAD BUSHINGS THAT WERE STILL IN GOOD CONDITION. *JS

Mileage: 204,551

2001 FORD EXPLORER SPORT. CONSUMER WRITES IN REGARDS TO BUSHING PROBLEMS. *SMD THE CONSUMER STATED THE BUSHINGS DISINTEGRATED. THE COST TO REPLACE THEM, WAS $2000. *JB

MY WIFE WAS DRIVING ON A RESIDENTIAL ROAD AROUND 30 MPH WHEN SHE ATTEMPTED TO BRAKE. SHE WAS UNABLE TO STOP THE VEHICLE BY BRAKING. SHE SAID THE TRUCK WAS BUCKING WILDLY AS THOUGH IT WAS ATTEMPTING TO MAINTAIN IT'S 30 MPH SPEED. SHE PUT IT IN NEUTRAL AND PULLED OVER YET THE TRUCK CONTINUED TO IDLE AS THOUGH IT WERE DRIVING 30 MILES PER HOUR. SHE TURNED THE VEHICLE OFF. I ARRIVED 15 MINUTES LATER AND WITHOUT TOUCHING THE GAS PEDAL TURNED THE VEHICLE ON AND IT IMMEDIATELY REV'D AS SHE DESCRIBED SO I SHUT IT OFF. I THEN PUMPED THE GAS PEDAL (WITH THE TRUCK IN THE OFF POSITION) ASSUMING IT MAY BE STUCK THEN RESTARTED THE VEHICLE. IT STARTED AND SUBSEQUENTLY DROVE NORMALLY. I TOOK IT TO MY MECHANIC AND HE DISCOVERED NOTHING. NOTHING IN THE COMPUTER HISTORY AND NOTHING WRONG WITH THE SPEED SYSTEM (PEDAL, CABLE, THROTTLE, THROTTLE BODY...) I DID SOME RESEARCH ON-LINE AND DISCOVERED AN NHTSA REPORT (NHTSA ACTION NUMBER : PE05037) OF A POSSIBLE BAD SPEED CONTROL CABLE FOR THIS VEHICLE WHERE THE

Mileage: 65,000

MY PURCHASED NEW $30,000 2001 FORD 2 DOOR EXPLORER SPORT DIES OFTEN CAUSING NO BRAKES OR STEERING. IN 2001, IT DIED AND ROLLED OVER WITH NO STEERING OR BRAKES WHEN MY WIFE WAS DRIVING HOME, LEAVING HER STRANDED UPSIDE DOWN. FORD WOULD NOT RESPOND AND LOCAL DEALERS WOULD NOT OR COULD NOT SOLVE THE PROBLEM. IT STILL DIES AND ALL RECALLS WERE PRESUMABLY DONE, INCLUDING THE FIRESTONE TIRES WHICH WERE THE BEST PART OF THE VEHICLE. NUMEROUS LETTERS TO FORD WERE NEVER ACKNOWLEDGED. I WOULD LIKE TO HAVE A REFUND ON THIS VEHICLE. CAN YOU HELP ME? *TR

Mileage: 1,500

MY PURCHASED NEW $30,000 2001 FORD 2 DOOR EXPLORER SPORT DIES OFTEN CAUSING NO BRAKES OR STEERING. IN 2001, IT DIED AND ROLLED OVER WITH NO STEERING OR BRAKES WHEN MY WIFE WAS DRIVING HOME, LEAVING HER STRANDED UPSIDE DOWN. FORD WOULD NOT RESPOND AND LOCAL DEALERS WOULD NOT OR COULD NOT SOLVE THE PROBLEM. IT STILL DIES AND ALL RECALLS WERE PRESUMABLY DONE, INCLUDING THE FIRESTONE TIRES WHICH WERE THE BEST PART OF THE VEHICLE. NUMEROUS LETTERS TO FORD WERE NEVER ACKNOWLEDGED. I WOULD LIKE TO HAVE A REFUND ON THIS VEHICLE. CAN YOU HELP ME? *TR

Mileage: 1,500

THIS HAS OCCURRED MULTIPLE TIMES SINCE I'VE HAD THE VEHICLE. I KNOW ENOUGH ABOUT VEHICLES TO KNOW THIS IS NOT NORMAL IN THE EARLY YEARS OF 125,000 MILES AND ROUTINE MAINTENANCE. WHEN I ACCELERATE FROM A STOPPED POSITION THE RPM'S GO UP TO ABOUT 3,000 OR SO BUT THE VEHICLE DOES NOT ACCELERATE. THE O/D LIGHT WILL FLASH AND THE VEHICLE, WHEN IT DOES ACCELERATE, IS "SLUGGISH". WHEN I PULL OVER AND TURN OFF THE VEHICLE, THEN TURN IT BACK ON, IT SEEMS TO RESET THE LIGHT SO THAT IT IS NO LONGER ILLUMINATED BUT EVENTUALLY THE ISSUE WITH THE LACK OF ACCELERATION COMES BACK WITHIN THE NEXT FEW MILES AND USUALLY IS A PROBLEM BETWEEN 1ST AND 2ND GEAR. IT HAPPENS LIKE CLOCK WORK WHEN I LEAVE A DRIVEWAY AND ENTER TRAFFIC WHICH PUTS ME IN FEAR OF BEING HIT BY AN ONCOMING VEHICLE. THIS IS DEFINITELY A POTENTIAL HAZARD AND IN AN ATTEMPT TO DIAGNOSE THE PROBLEM I HAVE COME ACROSS MULTIPLE ENTRIES ON "BLOGS" WITH SIMILAR SYMPTOMS THAT USUALLY BEGIN AROUND 120,000-150,000 MILES. IN MY OP

Mileage: 125,000

WHEN I STARTED FROM A STOP LIGHT IT TOOK OFF FINE BUT SHIFTING FROM 1ST TO 2ND AND THEN INTO 3RD THE ENGINE RACED BUT WOULD NOT ACCELERATE. I PUSHED THE O/D OFF AND IT SEEMED TO FIX THE PROBLEM. THEN OVER THE NEXT FEW DAYS IT BECAME MORE FREQUENT TO THE POINT THAT I AM AFRAID TO PULL OUT INTO TRAFFIC. I WORRY THAT I WILL BE HIT BY NOT GAINING SPEED TO GET GOING. ALSO MERGING ON THE FREEWAY IS FRUSTRATING AND UNSAFE. THE O/D LIGHT FLASHES ON AND OFF ALL OF THE TIME NOW. THIS HAS HAPPENED OVER THE COARSE OF A WEEK. THIS IS AN AUTOMATIC TRANSMISSION 2WD. *TR

Mileage: 146,444