2000 FORD EXPEDITION

EXTERIOR LIGHTING

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIA

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER

VEHICLE SPEED CONTROL:CRUISE CONTROL

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE

EQUIPMENT:OTHER:LABELS

CERTAIN 4X2 SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR 4.2 VEHICLES.

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPL

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

STRUCTURE

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EX

TRAILER HITCHES

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES. THE TRAILER HITCH ASSEMBLY TO THE FRAME ATTACHING BOLTS COULD LOSE THE CLAMP LOAD.

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIV

while driving smoke came from under my hood by the time i opened it was a full blown fire on the passenger side near the fuel injectors and spark plugs. we called 911 police and fire department came a nearby business owner loaned a fire extinguisher and we got the fire out. the fire men say it was caused by a spark plug that had came out caught spark with oil or gas it damaged hoses electrical and not sure what else yet.

The contact owns a 2000 Ford Expedition. The contact stated while driving 30 MPH, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to prevent oversteering. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering shaft. The vehicle was repaired, but the failure reoccurred because the aftermarket replacement part was too short. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 315,000.

Mileage: 315,000

The contact owns a 2000 Ford Expedition. The contact stated that the vehicle would not start-up. The contact attempted to jump start the vehicle with assistance, but he was not successful. The check engine warning light was illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 300,000.

Mileage: 300,000

The contact owns a 2000 Ford Expedition. The contact stated that the vehicle would not start-up. The contact attempted to jump start the vehicle with assistance, but he was not successful. The check engine warning light was illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 300,000.

Mileage: 300,000

MY 2000 FORD EXPEDITION WAS PARKED AT MY JOB PARKING LOT FOR 3HRS, WHEN IT CAUGHT FIRE UNDERNEATH THE HOOD NEAR THE MASTER CYLINDER, DRIVERS SIDE, NEAR THE FIREWALL. I CONTACTED FORD MOTOR COMPANY, BBB, AND CONSUMER AFFAIRS, WHICH ALL ATTEMPTS WERE IGNORED.

Mileage: 10,000

MY 2000 FORD EXPEDITION WAS PARKED AT MY JOB PARKING LOT FOR 3HRS, WHEN IT CAUGHT FIRE UNDERNEATH THE HOOD NEAR THE MASTER CYLINDER, DRIVERS SIDE, NEAR THE FIREWALL. I CONTACTED FORD MOTOR COMPANY, BBB, AND CONSUMER AFFAIRS, WHICH ALL ATTEMPTS WERE IGNORED.

Mileage: 10,000

MY 2000 FORD EXPEDITION WAS PARKED AT MY JOB PARKING LOT FOR 3HRS, WHEN IT CAUGHT FIRE UNDERNEATH THE HOOD NEAR THE MASTER CYLINDER, DRIVERS SIDE, NEAR THE FIREWALL. I CONTACTED FORD MOTOR COMPANY, BBB, AND CONSUMER AFFAIRS, WHICH ALL ATTEMPTS WERE IGNORED.

Mileage: 10,000

MY CAR SHUTS OFF RANDOMLY AS I'M DRIVING. I'VE HAD MECHANICS LOOK AT IT AND SEE NOTHING WRONG. THERE ARE NO CODES COMING UP EITHER.

Mileage: 100,000

MY CAR SHUTS OFF RANDOMLY AS I'M DRIVING. I'VE HAD MECHANICS LOOK AT IT AND SEE NOTHING WRONG. THERE ARE NO CODES COMING UP EITHER.

Mileage: 100,000

MY CAR SHUTS OFF RANDOMLY AS I'M DRIVING. I'VE HAD MECHANICS LOOK AT IT AND SEE NOTHING WRONG. THERE ARE NO CODES COMING UP EITHER.

Mileage: 100,000

ODOMETER BLANKS OUT NO DIGITAL READ OUT FOR MILEAGE, SEATS ARE TORN BADLY DON'T USE OR DRIVE THAT OFTEN 1 OR TWICE A WEEK IT HAS ONLY 145K MILES. NOW, THE AIR LINE HAS BEEN REPLACED AND IT LOW IN REAR WITH COMPRESSOR CAN'T FIND LEAK AND BELIEVE THE AIR BAGS WILL NEED REPLACED TRYING TO FIND OUT WHERE ISSUE IS AND NO WARNING LIGHT THIS TIME ON DASH LIKE USUAL. *TR

Mileage: 145,000

ODOMETER BLANKS OUT NO DIGITAL READ OUT FOR MILEAGE, SEATS ARE TORN BADLY DON'T USE OR DRIVE THAT OFTEN 1 OR TWICE A WEEK IT HAS ONLY 145K MILES. NOW, THE AIR LINE HAS BEEN REPLACED AND IT LOW IN REAR WITH COMPRESSOR CAN'T FIND LEAK AND BELIEVE THE AIR BAGS WILL NEED REPLACED TRYING TO FIND OUT WHERE ISSUE IS AND NO WARNING LIGHT THIS TIME ON DASH LIKE USUAL. *TR

Mileage: 145,000

ODOMETER BLANKS OUT NO DIGITAL READ OUT FOR MILEAGE, SEATS ARE TORN BADLY DON'T USE OR DRIVE THAT OFTEN 1 OR TWICE A WEEK IT HAS ONLY 145K MILES. NOW, THE AIR LINE HAS BEEN REPLACED AND IT LOW IN REAR WITH COMPRESSOR CAN'T FIND LEAK AND BELIEVE THE AIR BAGS WILL NEED REPLACED TRYING TO FIND OUT WHERE ISSUE IS AND NO WARNING LIGHT THIS TIME ON DASH LIKE USUAL. *TR

Mileage: 145,000

MY TRUCK HAS BEEN RUNNING FINE WITH NEW PARTS ON IT. I WENT TO MY FRIEND'S HOUSE WENT IN TO SWITCH MY LAUNDRY, LOOKED OUT HER WINDOW AND MY WAS ON FIRE!! TRUCK OFF AND KEYS WERE NOT IN IGNITION AND IT WAS PARKED IN A DRIVEWAY UNDER A CARPORT. IT POSED NO PROBLEMS ON THE WAY OVER THERE, NO SMELLS, NO SOUNDS, NO NOTHING. AND THEN BAM! HOOD SHOOTING OUT FLAMES.

Mileage: 195,000

MY TRUCK HAS BEEN RUNNING FINE WITH NEW PARTS ON IT. I WENT TO MY FRIEND'S HOUSE WENT IN TO SWITCH MY LAUNDRY, LOOKED OUT HER WINDOW AND MY WAS ON FIRE!! TRUCK OFF AND KEYS WERE NOT IN IGNITION AND IT WAS PARKED IN A DRIVEWAY UNDER A CARPORT. IT POSED NO PROBLEMS ON THE WAY OVER THERE, NO SMELLS, NO SOUNDS, NO NOTHING. AND THEN BAM! HOOD SHOOTING OUT FLAMES.

Mileage: 195,000

MY TRUCK HAS BEEN RUNNING FINE WITH NEW PARTS ON IT. I WENT TO MY FRIEND'S HOUSE WENT IN TO SWITCH MY LAUNDRY, LOOKED OUT HER WINDOW AND MY WAS ON FIRE!! TRUCK OFF AND KEYS WERE NOT IN IGNITION AND IT WAS PARKED IN A DRIVEWAY UNDER A CARPORT. IT POSED NO PROBLEMS ON THE WAY OVER THERE, NO SMELLS, NO SOUNDS, NO NOTHING. AND THEN BAM! HOOD SHOOTING OUT FLAMES.

Mileage: 195,000

MY EXPEDITION CAUGHT ON FIRE PARKED IN MY DRIVEWAY AT LEAST 30 MINUTES AFTER DRIVING IT. I WAS ABLE TO PUT THE FIRE OUT WITH A FIRE EXTINGUISHER AND A WATER HOSE, BUT THE PLASTIC PARTS WERE WERE MELTED ON THE DRIVER SIDE. THE BATTERY WAS DISCONNECTED AND I WAS TOLD BY A MECHANIC THAT IT WAS THE CRUISE CONTROL RELAY.

Mileage: 258,000

I WAS DRIVING THE DOWN THE STREET GOING TO WAL-MART ON PENDLETON PIKE IN INDIANAPOLIS INDIANA THE CAR SHIFTED FROM DRIVE TO NEUTRAL ON ITS OWN. I SHIFTED IT BACK IN GEAR DROVE ON TO WAL-MART THEN TO WENT TO ALDIS. WHEN I CAME OUT OF ALDIS ALSO ON PENDLETON PIKE THE CAR WOULDN'T COME OUT OF PARK WITHOUT KEY BEING IN ACC POSITION FOOT ON BRAKE AND PLAYING WITH GEARSHIT FOR APPROX 15 MINS IT WAS LOCKED. THEN THE POWER WINDOWS ALSO WENT OUT IN THE SAME TIME THAT THIS ALL HAPPENED. NOW MY CAR WILL NOT GO INTO GEAR WITHOUT MESSING WITH GEARSHIFT FOR SEVERAL MINUTES AND MESSING WITH IGNITION SWITCH MUTIPLE TIMES BEFORE I CAN GET CAR INTO MOTION.

Mileage: 286,000

I WAS DRIVING THE DOWN THE STREET GOING TO WAL-MART ON PENDLETON PIKE IN INDIANAPOLIS INDIANA THE CAR SHIFTED FROM DRIVE TO NEUTRAL ON ITS OWN. I SHIFTED IT BACK IN GEAR DROVE ON TO WAL-MART THEN TO WENT TO ALDIS. WHEN I CAME OUT OF ALDIS ALSO ON PENDLETON PIKE THE CAR WOULDN'T COME OUT OF PARK WITHOUT KEY BEING IN ACC POSITION FOOT ON BRAKE AND PLAYING WITH GEARSHIT FOR APPROX 15 MINS IT WAS LOCKED. THEN THE POWER WINDOWS ALSO WENT OUT IN THE SAME TIME THAT THIS ALL HAPPENED. NOW MY CAR WILL NOT GO INTO GEAR WITHOUT MESSING WITH GEARSHIFT FOR SEVERAL MINUTES AND MESSING WITH IGNITION SWITCH MUTIPLE TIMES BEFORE I CAN GET CAR INTO MOTION.

Mileage: 286,000

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE CRUISE CONTROL SWITCH UNDERNEATH THE HOOD THAT WAS CONNECTED TO THE BRAKE MASTER CYLINDER CAUGHT ON FIRE. THE CONTACT STATED THAT THE IGNITION WAS OFF AT THE TIME. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS NOT FILED. THE CONTACT, A CERTIFIED MECHANIC, STATED THAT THERE WAS BRAKE FLUID COMING OUT OF THE CRUISE CONTROL SWITCH. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 201,000.

Mileage: 201,000