Total Complaints
4 filings
FORD E-550 · model year
2005 FORD E-550
4 NHTSA complaints, and 1 recall campaign listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2005FORDE-550 carries 4 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2005 E-550 is engine and engine cooling with 1 filings, followed by electrical system:ignition (1) and fuel system, diesel (1). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 1 NHTSA recall campaign listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 179 investigation files overlapping the 2005 E-550, and 6 remain open. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING | 1 |
| ELECTRICAL SYSTEM:IGNITION | 1 |
| FUEL SYSTEM, DIESEL | 1 |
| FUEL/PROPULSION SYSTEM | 1 |
Recalls (1)
06E05600013/06/2006
FUEL SYSTEM, GASOLINE
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE
Recent Complaints
20150501FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD E-550. WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE, THE FUEL TANK WAS DISCOVERED TO BE CORRODED CAUSING THE FUEL PUMP TO FAIL. THE DEALER ADVISED THAT THE FUEL TANK AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 23,000.
Mileage: 23,000
20100802FUEL SYSTEM, DIESEL
FORD 650 TRUCK, YEAR 2005, TOTAL MILES 15,000. PROBLEM; RUSTING FUEL TANK CLOGGING FILTERS AND FUEL INJECTORS. *TR
Mileage: 15,000
20061215ELECTRICAL SYSTEM:IGNITION
I PURCHASED MY 2005 FORD ESCAPE JANUARY 15, 2005. IN APRIL THAT SAME YEAR WAS THE FIRST TIME I ATTEMPTED TO START MY BRAND NEW TRUCK AND IT WOULD NOT START. THE VEHICLE WILL CRANK BUT THE ENGINE WILL NOT TURN OVER. THIS HAPPENS ABOUT EVERY 3-4 MONTHS. I HAVE TAKEN IT TO MY LOCAL DEALER REGARDING THIS PROBLEM ABOUT 4 OR 5 TIMES AND EACH TIE THEY TELL ME THEY CAN'T FIND ANY REASON THAT IT WOULD BE DOING THIS. THE LAST TWO TIMES IT HAPPENED I RECALL THAT IT HAD BEEN RAINING IN MY AREA SO I DON'T KNOW IF THAT IS A FACTOR OR NOT BUT THE LAST TIME IT HAPPENED WAS JUST BEFORE THANKSGIVING 2006. *NM
Mileage: 1,500
20061002ENGINE AND ENGINE COOLING
DT*: THE CONTACT STATED THE ENGINE CONTINUED TO STALL. THE DEALER REPLACED 4 FUEL INJECTORS, 2 OIL LINES, AND 2 OIL PUMPS. THE SERVICE DEALER WAS UNSURE HOW TO RECTIFY THE ISSUE. THE VEHICLE STALLED WHILE IN GEAR, WHETHER ACCELERATING OR NOT.
Mileage: 36,000
Compare 2005FORDE-550 to Similar Vehicles
NHTSA Investigations 6 Open
EA26004Engineering AnalysisOpen
Timing Belt Failure
DP26004Defect PetitionOpen
Anti-lock brake system (ABS) Malfunction Indicator Lamp (MIL) illuminated
EA26001Engineering AnalysisOpen
Unintended Transmission Downshift and Rear Wheel Lock-up
PE25020Preliminary EvaluationClosed
Timing Belt Failure
DP25001Defect PetitionClosed
Underbody shields detachment
Frequently Asked Questions
How many complaints does the 2005 FORD E-550 have?▼
The 2005 FORD E-550 has 4 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2005 FORD E-550?▼
Yes, the 2005 FORD E-550 has 1 recall(s). The most common affected component is FUEL SYSTEM, GASOLINE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2005 FORD E-550?▼
The most-complained component for the 2005 FORD E-550 is ENGINE AND ENGINE COOLING with 1 complaints. Other frequently reported areas include ELECTRICAL SYSTEM:IGNITION and FUEL SYSTEM, DIESEL.
Is the 2005 FORD E-550 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2005 FORD E-550; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.