Total Complaints
2 filings
Ford E-450 · model year
2009 Ford E-450
2 NHTSA complaints, 1 crash report, and 10 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
- Complaints
- 2
- Recalls
- 10
The verdict
The 2009 Ford E-450 posts top-5% complaint standing among its own model-year siblings.
- Top 3%
- fewest complaints, own model years
- 10
- recall campaigns
The 2009FordE-450 carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 1 crash, 0 fires, 2 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2009 E-450 is engine with 1 filings, followed by air bags (1). Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 10 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 1 investigation file overlapping the 2009 E-450. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
2
Complaints
1
Crashes
0
Fires
2
Injuries
0
Deaths
F
PlainCars Safety Score
0/100
2009 Ford E-450
PlainCars' own composite of NHTSA NCAP crash-test ratings and rollover-risk assessment, each dimension normalized against the federal scale or the full national model-year corpus. Not an official NHTSA figure, and not a substitute for a specific vehicle's VIN-level recall check.
NHTSA Overall Rating N/A
Not rated
NHTSA New Car Assessment Program overall crash-test rating.
Front Crash N/A
Not rated
Frontal barrier crash-test rating.
Side Crash N/A
Not rated
Side barrier and pole crash-test rating.
Rollover Resistance N/A
Not rated
Static stability factor + dynamic rollover test rating.
Rollover Risk N/A
Not reported
NHTSA single-vehicle rollover probability, dynamic test.
Crashes Reported
1 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE | 1 |
| AIR BAGS | 1 |
Recalls (10)
11E03300031/08/2011
FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS USED FOR INSTALLATION ON THE FOLLOWING VEHICLES: MODEL YEAR 2007 AND 2008 FORD E-350 (DUEL REAR WHEEL), MY 2009-2011 FORD E- 150, E-250, AND E-350, AND MY 2009-2011 FORD E-450 CUTAWAYS. THE FUEL RAILS
19V40100029/05/2019
EQUIPMENT
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Elect
15V11200025/02/2015
EQUIPMENT ADAPTIVE/MOBILITY
Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
14V59500024/09/2014
EQUIPMENT ADAPTIVE/MOBILITY
Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate
09V23100023/06/2009
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FORD IS RECALLING 65 MY 2008-2009 E-350 AND MY 2009 E450 CUTAWAY VEHICLES EQUIPPED WITH SCHOOL BUS PREP PACKAGES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES MAY NOT HAVE BEEN ASSEMBLED WITH THE FUEL TANK PROTE
09V43400013/11/2009
EQUIPMENT:APPLIANCE:AIR CONDITIONER
E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHIC
12V58400012/12/2012
EQUIPMENT
Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.
09V11200007/04/2009
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
FORD MOTOR COMPANY IS RECALLING 429 MY 2009 FORD ECONOLINE E-350 AND E-450 CUTAWAY SCHOOL BUS PREP PACKAGE VEHICLES MANUFACTURED FROM APRIL 22, 2008 THROUGH MARCH 2, 2009, TO REPOSITION THE UPPER FUEL TANK PROTECTION BRACKET ON THE FRAME RAIL.
10V12800002/04/2010
EQUIPMENT ADAPTIVE/MOBILITY
ELKHART COACH HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN TRANSIT BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT I
10V13000002/04/2010
EQUIPMENT ADAPTIVE/MOBILITY
ELKHART COACH HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN TRANSIT BUSES EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVAT
Recent Complaints
20210619CrashAIR BAGS
Air bags failed to deploy in a off-center passenger side frontal collision. As a result, driver's hands remained on the wheel through collision, causing the L upper extremity to suddenly rotate approximately 210 degrees to the right causing a shoulder injury (severity at this point is uncertain). The vehicle was in for repair at Kendall Ford in Meridian, ID on 5/3/2021 for an air bag indicator light resulting in replacement of the restraint control module. It was returned to service on 5/6/2021. An insurance adjuster has inspected the vehicle, there has been no safety inspection of vehicle post-accident by qualified personnel in regards to the air bag not deploying. The vehicle is a total loss and is currently secured in our ambulance service lot. Additional pictures and drive camera video available on request.
20160803ENGINE
PLASTIC PART ATTACHED TO VALVE COVER INSIDE ENGINE BREAKS OFF CAUSING SUDDEN ENGINE FAILURE.
Mileage: 15,000
Compare 2009FordE-450 to Similar Vehicles
NHTSA Investigations
Vehicle Safety Guides
Frequently Asked Questions
How many complaints does the 2009 Ford E-450 have?▼
The 2009 Ford E-450 has 2 NHTSA complaints, 1 crashes, 0 fires, 2 injuries, and 0 deaths reported.
Are there any recalls for the 2009 Ford E-450?▼
Yes, the 2009 Ford E-450 has 10 recall(s). The most common affected component is FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2009 Ford E-450?▼
The most-complained component for the 2009 Ford E-450 is ENGINE with 1 complaints. Other frequently reported areas include AIR BAGS.
Is the 2009 Ford E-450 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2009 Ford E-450; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.