2009 FORD E-150

FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM

ROUSH IS RECALLING CERTAIN MODEL YEAR 2009-2011 FORD E-150, E-250, AND E-350 5.4L ENGIN VANS/WAGONS/CUTAWAYS, AND MODEL YEAR 2010-2011 FORD E-450 6.8L ENGINE CUTAWAY VEHICLES ALTERED BY ROUCH TO OPERATE USING THE ROUSH BRANDED CLEANTECH PROPANE AUTOGAS FUEL SYSTEM. THE FUEL RAILS INCLUDED IN THE KI

FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM

ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS USED FOR INSTALLATION ON THE FOLLOWING VEHICLES: MODEL YEAR 2007 AND 2008 FORD E-350 (DUEL REAR WHEEL), MY 2009-2011 FORD E- 150, E-250, AND E-350, AND MY 2009-2011 FORD E-450 CUTAWAYS. THE FUEL RAILS

FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS PRODUCED BETWEEN DECEMBER 17, 2010, AND MAY 6, 2011, USED FOR INSTALLATION ON FLEET VEHICLES MODEL YEAR 2009 THROUGH 2011 FORD E-SERIES VANS/WAGONS/SHUTTLES/CUTAWAY (150, 250 AND 350) WITH 5.4L ENGINES (

EQUIPMENT ADAPTIVE/MOBILITY

National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform s

EQUIPMENT

Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned

EQUIPMENT ADAPTIVE/MOBILITY

COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LI

EQUIPMENT ADAPTIVE/MOBILITY

COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE T

EQUIPMENT ADAPTIVE/MOBILITY

MOBILITY WORKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS AFTER NOVEMBER 2007 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY

EQUIPMENT ADAPTIVE/MOBILITY

MOBILITY WORKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS AND CHEVROLET 2500 CHASSIS AFTER NOVEMBER 2007 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LI

EQUIPMENT ADAPTIVE/MOBILITY

Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped wi

EQUIPMENT ADAPTIVE/MOBILITY

MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with fold

EQUIPMENT ADAPTIVE/MOBILITY

MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM M

EQUIPMENT ADAPTIVE/MOBILITY

MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE T

BRAKE SYSTEM CAME ON MY TRUCK DID WANT TO STOP ON CITY STREET THE BRAKE SYSTEMCAME ON MY SKID WILL COME ON

SPARK PLUG BLOW OUT

Mileage: 182,205

TL* THE CONTACT OWNS A 2009 FORD E-150. WHILE DRIVING 25 MPH, THE NUMBER SEVEN DRIVER SIDE SPARK PLUG FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TREAD ON THE CYLINDER HEAD WAS STRIPPED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 134,000.

Mileage: 134,000

TL* THE CONTACT OWNS A 2009 FORD E-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE FRONT OF THE VEHICLE SHOOK VIOLENTLY OUT OF CONTROL. THE VEHICLE WAS TAKEN TO A DEALER, WHO WAS UNABLE TO REMEDY THE FAILURE. THE FAILURE RECURRED SEVERAL TIMES. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS WHERE THE TIRES AND THE STEERING DAMPER WERE REPLACED. IN ADDITION, AN ALIGNMENT WAS PERFORMED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.

Mileage: 83,000

ADULT MALE DRIVER, I'VE RAN A TRUCK SALES SINCE 1971, DRIVING ALL BRANDS AN THIS IS A FIRST AND THE MOST DANGEROUS 2 OR 3 MINUTES OF MY LIFE..... DRIVING A 2009 FORD F150 61,62 MPH ON CRUISE, COMING INTO LEARY GEORGIA AN APPROACHING 2 VEHICLES AHEAD OF ME, I TOUCHED THE BRAKE PETAL TO RELEASE THE CRUISE CONTROL. THIS IS THE START OF A NITE MARE. THE THROTTLE WENT WIDE OPEN, FROM 60 I GO TO 75 -80 I HAD TO PASS THE 2 CARS AHEAD IN TOWN OR REAR END THEM. I HAD BOTH FEET ON THE BRAKE AN THE TRANSMISSION KEPT DOWNSHIFTING GIVING IT MORE POWER. I TURNED THE IGNITION OFF AND THEN NO BRAKES, NO STEERING, NO LIGHTS. I WAS PREPARED TO HIT WOODS OR BUILDING TO DODGE THE CARS ON STREET, HAD A FULL 90 DEGREE RT TURN TO MAKE AN CROSS A RR TRACK, NEEDING BRAKES AND LIGHTS I TURNED IGNITION ON , FULL THROTTLE AGAIN, TURNED IGNITION BACK OFF AND STEERED UNDER A SERVICE STATIONS CANOPY AND BACK OUT ON THE STREET AND ACROSS JUMPED THE CURB AND INTO A GOD SENT VACANT LO

ADULT MALE DRIVER, I'VE RAN A TRUCK SALES SINCE 1971, DRIVING ALL BRANDS AN THIS IS A FIRST AND THE MOST DANGEROUS 2 OR 3 MINUTES OF MY LIFE..... DRIVING A 2009 FORD F150 61,62 MPH ON CRUISE, COMING INTO LEARY GEORGIA AN APPROACHING 2 VEHICLES AHEAD OF ME, I TOUCHED THE BRAKE PETAL TO RELEASE THE CRUISE CONTROL. THIS IS THE START OF A NITE MARE. THE THROTTLE WENT WIDE OPEN, FROM 60 I GO TO 75 -80 I HAD TO PASS THE 2 CARS AHEAD IN TOWN OR REAR END THEM. I HAD BOTH FEET ON THE BRAKE AN THE TRANSMISSION KEPT DOWNSHIFTING GIVING IT MORE POWER. I TURNED THE IGNITION OFF AND THEN NO BRAKES, NO STEERING, NO LIGHTS. I WAS PREPARED TO HIT WOODS OR BUILDING TO DODGE THE CARS ON STREET, HAD A FULL 90 DEGREE RT TURN TO MAKE AN CROSS A RR TRACK, NEEDING BRAKES AND LIGHTS I TURNED IGNITION ON , FULL THROTTLE AGAIN, TURNED IGNITION BACK OFF AND STEERED UNDER A SERVICE STATIONS CANOPY AND BACK OUT ON THE STREET AND ACROSS JUMPED THE CURB AND INTO A GOD SENT VACANT LO

ON APPROXIMATELY 8/25/2010, WHILE DRIVING ON THE HIGHWAY THE VEHICLE SUDDENLY SHUT DOWN ELECTRICALLY. IT COULDN'T BE STARTED BY AAA. IT WAS TOWED TO A LOCAL REPAIR SHOP AND THEY FOUND A BURNED WIRE THAT WENT FROM THE FUSE BOX TO A JUNCTION BOX. HE TOLD ME THAT THIS IS AN ENGINEERING DEFECT IN THE VEHICLE AS THE WIRE IS TOO CLOSE TO THE BRAKES AND WHEN IT GETS HOT THE WIRE BURNS OUT. HE ALSO SAID THAT THE VEHICLE CAN EVENTUALLY GO ON FIRE. IT WAS REPAIRED AND THEN ON 9/25/2011 THE SAME THING OCCURRED. I HAD THE VEHICLE TOWED TO AMERICAN FORD ON RT 17 SOUTH IN PARAMUS NEW JERSEY. THEY FOUND AGAIN A BURNED WIRE FROM THE FUSE BOX. I ASKED THEM NOT TO REPAIR THE VEHICLE UNTIL SOMEONE FROM THE NATIONAL SAFETY BOARD INVESTIGATES THIS VEHICLE. *TR

Mileage: 36,100

(DEFECTIVE LOCK/HANDLE) THIS INCIDENT OCCURRED WHEN THE DOOR WAS IN A LOCK POSITION AND A PASSENGER TRIED TO OPEN THE DOOR. SOMETHING SNAPPED. THEN THE DOOR WAS UNABLE TO OPEN EVEN AFTER THE DOOR IS UNLOCKED. AFTER MY FRIEND DID ME A FAVOR TO FIX IT, THE SAME THING HAPPENED ON THE PASSENGER DOOR. THE DOOR WAS LOCKED THEN MY COWORKER TRIED TO OPEN THE DOOR BEFORE I UNLOCKED IT FROM THE CAR ALARM, THEN A COMPONENT ON THE HANDLE SNAPPED. SO NOW I HAVE TO OPEN THE DOOR FROM THE BACK OR SIDE DOOR. *KB

Mileage: 30,000

(DEFECTIVE LOCK/HANDLE) THIS INCIDENT OCCURRED WHEN THE DOOR WAS IN A LOCK POSITION AND A PASSENGER TRIED TO OPEN THE DOOR. SOMETHING SNAPPED. THEN THE DOOR WAS UNABLE TO OPEN EVEN AFTER THE DOOR IS UNLOCKED. AFTER MY FRIEND DID ME A FAVOR TO FIX IT, THE SAME THING HAPPENED ON THE PASSENGER DOOR. THE DOOR WAS LOCKED THEN MY COWORKER TRIED TO OPEN THE DOOR BEFORE I UNLOCKED IT FROM THE CAR ALARM, THEN A COMPONENT ON THE HANDLE SNAPPED. SO NOW I HAVE TO OPEN THE DOOR FROM THE BACK OR SIDE DOOR. *KB

Mileage: 30,000

(DEFECTIVE LOCK/HANDLE) THIS INCIDENT OCCURRED WHEN THE DOOR WAS IN A LOCK POSITION AND A PASSENGER TRIED TO OPEN THE DOOR. SOMETHING SNAPPED. THEN THE DOOR WAS UNABLE TO OPEN EVEN AFTER THE DOOR IS UNLOCKED. AFTER MY FRIEND DID ME A FAVOR TO FIX IT, THE SAME THING HAPPENED ON THE PASSENGER DOOR. THE DOOR WAS LOCKED THEN MY COWORKER TRIED TO OPEN THE DOOR BEFORE I UNLOCKED IT FROM THE CAR ALARM, THEN A COMPONENT ON THE HANDLE SNAPPED. SO NOW I HAVE TO OPEN THE DOOR FROM THE BACK OR SIDE DOOR. *KB

Mileage: 30,000