2005 DODGE SPRINTER 2500

STEERING:COLUMN

SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the

INTERIOR LIGHTING

ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING

See attached document for complaint.

The contact owns a 2005 Dodge Sprinter 2500. The contact stated that the vehicle failed to start. The vehicle failed to restart. The check engine warning light was illuminated. The contact stated that he watched a YouTube video and changed the fuel pressure sensor, but the failure recurred. The contact checked the wire harness, which was fine and pristine. There was a perturbing section on the manifold, and the two wires were cut. The wire webbing was frayed due to rubbing. The local dealer was contacted, who informed him there were no recalls. The vehicle was not diagnosed or repaired. The manufacturer was contacted, who opened a case. The failure mileage was approximately 252,858.

Mileage: 252,858

TL* THE CONTACT OWNS A 2005 DODGE SPRINTER. THE CONTACT STATED THAT BOTH HEADLIGHT BULBS HAD FAILED UPON ACTIVATION. THE CONTACT HAD TAKEN THE VEHICLE TO AN INDEPENDENT MECHANIC WHO WAS ABLE TO REPLACE THE HEADLIGHTS. THE CONTACT STATED THAT SOON AFTER THE INITIAL REPLACEMENT, THE HEADLIGHTS FAILED YET AGAIN. THE CONTACT THEN DECIDED TO REPLACE THE HEADLIGHTS HIMSELF AND DISCOVERED BURNT WIRING IN BOTH HEADLIGHT MANIFOLDS WHICH HE LINKED TO THE REPEATED FAILURE. AFTER THE CONTACT REPLACED BOTH HEADLIGHTS, THE CONTACT STATED THAT THE PASSENGER HEADLIGHT HAD FAILED YET AGAIN. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE WHERE THEY INFORMED HIM THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.

Mileage: 200,000

TL* THE CONTACT OWNS A 2005 DODGE SPRINTER. THE CONTACT STATED THAT BOTH HEADLIGHT BULBS HAD FAILED UPON ACTIVATION. THE CONTACT HAD TAKEN THE VEHICLE TO AN INDEPENDENT MECHANIC WHO WAS ABLE TO REPLACE THE HEADLIGHTS. THE CONTACT STATED THAT SOON AFTER THE INITIAL REPLACEMENT, THE HEADLIGHTS FAILED YET AGAIN. THE CONTACT THEN DECIDED TO REPLACE THE HEADLIGHTS HIMSELF AND DISCOVERED BURNT WIRING IN BOTH HEADLIGHT MANIFOLDS WHICH HE LINKED TO THE REPEATED FAILURE. AFTER THE CONTACT REPLACED BOTH HEADLIGHTS, THE CONTACT STATED THAT THE PASSENGER HEADLIGHT HAD FAILED YET AGAIN. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE WHERE THEY INFORMED HIM THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.

Mileage: 200,000

TL* THE CONTACT OWNS A 2005 DODGE SPRINTER 2500. THE CONTACT STATED THAT THE FRONT PASSENGER'S SIDE DOOR WAS UNABLE TO BE OPENED FROM THE INSIDE OR OUTSIDE THE VEHICLE. THE DEALER, MERCEDES-BENZ OF MIAMI (1200 NW 167TH STREET, MIAMI, FL 33169, (305)707-0147) WAS CONTACTED HOWEVER, THE CONTACT HAD NOT YET RECEIVED A CALLBACK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT. THE FAILURE MILEAGE WAS 228,976. INVALID VIN.

Mileage: 228,976

WE LOOSE POWER WHILE DRIVING. THE CAUSE IS THE FAILING OF THE TURBO RESONATOR. MERCEDES RECOMMENDS A PLASTIC REPLACEMENT PART FOR THE TURBO RESONATOR. WE HAVE REPLACED THREE OF THESE. THE PART IS TWO-PIECE AND THE SEAM FAILS. IT IS LOCATED BETWEEN THE RADIATOR AND THE ENGINE. IT'S HOT THERE. THERE IS AN ALUMINUM PART AVAILABLE THAT SEEMS TO FUNCTION WITHOUT PROBLEMS. I'VE CALLED MB AND THEY CAN'T DO ANYTHING FOR ME UNLESS I TAKE IT BACK TO THE DEALERS. I'VE NOT HEARD GOOD NEWS ABOUT OUR LOCAL DEALERSHIP AND DO HAVE A GREAT MECHANIC. I'D LIKE MB TO AT LEAST CONFIRM MY PROBLEM AND MANY OTHERS AS I READ THAT THIS PLASTIC PART HAS CAUSED PROBLEMS IN THE 2004, 2005, 2006, & 2007'S. IF THE PART FAILS, WE LOOSE POWER AND COULD BE REAR ENDED. ALSOWHAT MATERIAL ARE THEY USING IN THE 2008'S?? WOULD YOU PLEASE CHECK THE INTERNET ABOUT THE "TURBO RESONATOR" AND THINK OF A RECALL BEFORE SOMEONE DIES?

Mileage: 61,000

TL* THE CONTACT OWNS A 2005 DODGE SPRINTER 2500. THE CONTACT TOOK THE VEHICLE IN FOR AN OIL CHANGE WHERE IT WAS OBSERVED BY THE TECHNICIANS THAT THERE WAS EXCESSIVE CORROSION UNDER THE HOOD. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (HUNTINGTON BEACH CHRYSLER, DODGE, JEEP, RAM LOCATED ON 16701 BEACH BLVD, HUNTINGTON BEACH, CA) WHO INFORMED THE CONTACT TO REACH OUT TO THE MANUFACTURER TO FILE A CASE. THE VEHICLE WAS NOT REPAIRED FOR THE CORROSION. THE MANUFACTURER PROVIDED CASE NUMBER: 31763746 AND FORMS FOR THE CONTACT TO FILL OUT AND SUBMIT PICTURES. THE MANUFACTURER STATED THAT THEY WOULD GET BACK IN TOUCH WITH THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.

Mileage: 15,000

THE PASSENGER PULLED THE SEAT BELT ACROSS HER AND CLICKED INTO THE END MOUNT PIECE. THE END MOUNT PIECE CAME BACK WITH THE SEAT BELT EXPOSING 2 CABLE PIECES THAT HAD BROKEN OFF THE MOUNTING PLATE. THIS SHOWED THAT THE 2 CABLES MUST HAVE BROKEN FROM FATIGUE OVER SOME TIME AND WOULD HAVE BEEN DISASTROUS IN THE EVENT OF AN ACCIDENT. THE DRIVER?S SIDE MOUNT WAS INSPECTED AND SHOWED NO FATIGUE OR FRAYING OF THE CABLES. I BROUGHT THE BROKEN END MOUNT PIECE TO THE ST CLAIR SHORES MI MERCEDES DEALER PARTS DEPARTMENT AND THE MOUNT PIECE DID NOT MATCH THE FACTORY INFORMATION. THE BROKEN END MOUNT COULD NOT BE LOCATED IN THE UNITED STATES AND HAD TO BE ORDERED FROM GERMANY. THIS VAN WAS ORIGINALLY BUILT IN GERMANY AS A DODGE SPRINTER AND MODIFIED BY ROADTREK CANADA INTO AN RV. HOWEVER THERE WAS NO INDICATION OF ANY MODIFICATION TO THE FRONT 2 SEATS OR SEAT BELTS. THE FRONT SEAT BELT HAVE MERCEDES PART NUMBER MARKINGS ON THEM.

Mileage: 133,806

THE TURBO RESONATOR CAME APART AND COMPLETELY SHUT DOWN THE TURBO, RESULTING IN COMPLETE LOSS OF POWER ON THE FREEWAY. VERY UNSAFE AND HAVE FOUND THAT THIS IS A COMMON PROBLEM, BUT DODGE WILL NOT DO ANYTHING ABOUT IT. A GOOGLE SEARCH ONLINE WILL ATLEAST TO THIS FACT AND IT IS VERY DANGEROUS. I WAS ON THE FREEWAY WHEN THIS HAPPENED AND WHEN YOU LOOSE ALL POWER AT ONCE IT MAKES FOR A VERY UNSAFE SITUATION FOR EVERYONE AROUND AND BEHIND YOU AS THERE IS NO WAY TO ACCELERATE TO GET TO THE SIDE OF THE ROAD, ONLY ABLE TO COAST. PLEASE MAKE SURE THIS PROBLEM IS DOCUMENTED. *TR *JS

Mileage: 220,000

THE TURBO RESONATOR CAME APART AND COMPLETELY SHUT DOWN THE TURBO, RESULTING IN COMPLETE LOSS OF POWER ON THE FREEWAY. VERY UNSAFE AND HAVE FOUND THAT THIS IS A COMMON PROBLEM, BUT DODGE WILL NOT DO ANYTHING ABOUT IT. A GOOGLE SEARCH ONLINE WILL ATLEAST TO THIS FACT AND IT IS VERY DANGEROUS. I WAS ON THE FREEWAY WHEN THIS HAPPENED AND WHEN YOU LOOSE ALL POWER AT ONCE IT MAKES FOR A VERY UNSAFE SITUATION FOR EVERYONE AROUND AND BEHIND YOU AS THERE IS NO WAY TO ACCELERATE TO GET TO THE SIDE OF THE ROAD, ONLY ABLE TO COAST. PLEASE MAKE SURE THIS PROBLEM IS DOCUMENTED. *TR *JS

Mileage: 220,000

2005 DODGE SPRINTER (84857 MILES) HAD EMERGENCY BRAKE WORKED ON AT DEALER. APPROXIMATELY 187 MILES AND ROUGHLY 45-50 HOURS LATER THE REAR WHEEL ON THE DRIVER'S SIDE OF VEHICLE FELL OFF. FOUR OF FIVE LUG BOLTS WERE MISSING. THE FIFTH LUG NUT WAS STILL ATTACHED, BUT BADLY BENT. HEAD OF SERVICE DEPARTMENT SAID IT WAS COMMON KNOWLEDGE THAT ALUMINUM RIMS AND STEEL WHEELS WERE INCOMPATIBLE AND THIS WAS THE REASON FOR THE TIRE FALLING OFF. THE SPRINTER HAD BEEN MAINTAINED SOLELY BY THE DEALER FOR NINETY PERCENT OF IT'S HISTORY COVERING FOUR YEARS AND APPROXIMATELY 80,000 MILES. DEALER DENIED ANY RESPONSIBILITY FOR INFORMING ME OF THIS POTENTIAL PROBLEM AND REFUSED TO PAY FOR ANY OF THE DAMAGE CAUSED BY THE FAILURE OF THE WHEEL. I PAID TO HAVE STEEL RIMS REPLACE THE ALUMINUM ONES. THE ALUMINUM RIMS, AND REMAINING LUG BOLTS ARE IN MY POSSESSION. *TR

Mileage: 85,044

I HAVE OWNED THIS 2005 DODGE SPRINTER FOR OVER A YEAR AND HAVE HAD 4 FLAT TIRES DUE TO VALVE STEM FAILURES (IT IS SITTING IN MY PARKING LOT RIGHT NOW WITH A FLAT FRONT DRIVERS TIRE) THE VALVE STEM BULGES AND SPITS OUT AIR AS SOON AS I FILL IT. I CAN FEEL THE LEAK AND SEE THE STEM BULGE WHEN TRY TO PUT AIR IN THE TIRE . I HAVE SEEN OTHER SPRINTERS WITH THIS PROBLEM MERCEDES RECALLED 2004 SPRINTER FOR THIS PROBLEM BUT IT IS OBVIOUS THAT MORE VEHICLES ARE AFFECTED. THIS IS A VERY DANGEROUS SITUATION IF THEY WERE TO FAIL ON A LOADED VEHICLE AT HIGHWAY SPEEDS. *TR

Mileage: 28,000

I HAVE OWNED THIS 2005 DODGE SPRINTER FOR OVER A YEAR AND HAVE HAD 4 FLAT TIRES DUE TO VALVE STEM FAILURES (IT IS SITTING IN MY PARKING LOT RIGHT NOW WITH A FLAT FRONT DRIVERS TIRE) THE VALVE STEM BULGES AND SPITS OUT AIR AS SOON AS I FILL IT. I CAN FEEL THE LEAK AND SEE THE STEM BULGE WHEN TRY TO PUT AIR IN THE TIRE . I HAVE SEEN OTHER SPRINTERS WITH THIS PROBLEM MERCEDES RECALLED 2004 SPRINTER FOR THIS PROBLEM BUT IT IS OBVIOUS THAT MORE VEHICLES ARE AFFECTED. THIS IS A VERY DANGEROUS SITUATION IF THEY WERE TO FAIL ON A LOADED VEHICLE AT HIGHWAY SPEEDS. *TR

Mileage: 28,000

SPRINTER VAN STALLS DURING DECELERATION 2005 SPRINTER VAN WITH DUAL A/C STALLS WHEN BOTH A/C ARE ON AND DECELERATING. HAPPENS DURING SUMMER MONTHS DODGE HAS A FIX WITH A SERVICE BULLETIN BUT ONLY IF UNDER WARRANTY. *TR

Mileage: 45,000

TURBO RESONATOR CHAMBER FAILURE. RESULTING IN LOSS OF BOOST AND POWER. *TR

Mileage: 12,600

TL*THE CONTACT OWNS A 2005 DODGE SPRINTER. WHILE DRIVING APPROXIMATELY 61 MPH, THE CONTACT HEARD A LOUD RATTLING NOISE UNDERNEATH THE VEHICLE. UPON FURTHER INSPECTION, HE NOTICED THAT THE CRANKSHAFT HARMONIC BALANCED BOLT WAS FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE WARRANTY WAS EXPIRED; THEREFORE, THE CONTACT WOULD HAVE TO REPLACE THE BOLT AT HIS EXPENSE. THE CONTACT IS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. HE HAS PICTURES OF THE FAILED COMPONENT. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

Mileage: 120,000

TL*THE CONTACT OWNS A 2005 DODGE SPRINTER 3500. WHILE DRIVING APPROXIMATELY 70 MPH THE TURBO RESONATOR CAUSED THE VEHICLE TO DECELERATE. THERE WERE NO PRIOR WARNING SIGNS WHICH AS A CONSEQUENCE INCREASED THE RISK OF A SERIOUS CRASH AND INJURY. THE DEALER REPLACED THE TURBO RESONATOR FOUR TIMES. ALL ATTEMPTS TO REPAIR THE FAILURE HAVE BEEN UNSUCCESSFUL. A TECHNICIAN SPECULATED THT POOR QUALITY AND EXCESSIVE HEAT EXPOSURE CAUSED THE COMPONENT TO FAIL. THE FAILURE MILEAGE WAS 2,336 AND THE CURRENT MILEAGE WAS 25,000.UPDATED 5/6/09 *CN UPDATED 05/08/09.*JB

Mileage: 2,336

TL*THE CONTACT OWNS A 2005 DODGE SPRINTER 3500 SC. THE CONTACT NOTICED ISSUES WITH THE TURN SIGNALS ON HIS VEHICLE. THE MULTI-FUNCTION SWITCH ON THE STEERING COLUMN THAT CONTROLLED THE EXTERIOR LIGHTING WAS THE CAUSE OF THE FAILURE. THE OTHER EXTERIOR LIGHTING FUNCTIONED CORRECTLY, BUT THE TURN SIGNALS BECAME INOPERATIVE. HE TOOK THE VEHICLE TO THE DEALER FOUR TIMES FOR THE ISSUE. THE FIRST TIME THE SWITCH WAS REPLACED, BUT THE FAILURE REMAINED. THE SECOND TIME, IN NOVEMBER OF 2006, THE DEALER COULD NOT REPAIR THE ISSUE. THE MOST RECENT VISIT, IN APRIL OF 2007, AN OUTSIDE SOURCE BOUGHT AND REPLACED THE SWITCH. THE CONTACT PROVIDED THE DEALER WITH THE RECEIPT AND THEY PROVIDED REIMBURSEMENT. IN NOVEMBER OF 2007, THE SWITCH FAILED AGAIN. THE PART WAS ON BACKORDER AND THE CONTACT WAITED MORE THAN 11 MONTHS FOR IT TO BECOME AVAILABLE. THE DEALER STATED THAT THE PART WOULD COST $204. THE MANUFACTURER STATED THAT THE VEHICLE WAS OUTSIDE OF THE WARRANTY; THEREFORE, THEY COULD NOT

Mileage: 12,000

TL*THE CONTACT OWNS A 2005 DODGE SPRINTER 2500. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED EXCESSIVE SMOKE INSIDE THE CARGO COMPARTMENT. UPON FURTHER INSPECTION, HE NOTICED THAT THE REAR DRIVER'S SIDE INTERIOR LIGHTING WAS THE SOURCE OF THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER AND IS IN THE PROCESS OF BEING INSPECTED. IT HAS NOT YET BEEN DETERMINED IF THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V299000 (INTERIOR LIGHTING). THE FAILURE AND CURRENT MILEAGES WERE 15,000.UPDATE 10/01/08 *CW THE CONSUMER STATED THE FIRE WAS ELECTRICAL. THE SWITCH MECHANISM USED IN THE REAR LIGHTS WAS POORLY DESIGNED. THE CONSUMER WAS ABLE TO PUT THE FIRE OUT. UPDATED 10/03/08. *JB

Mileage: 15,000

TL*- THE CONTACT OWNS A 2005 DODGE SPRINTER. THE CONTACT SMELLED AN ODOR COMING FROM THE HEATING AND COOLING SYSTEM. THE DEALER STATED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE INJECTOR WASHERS WERE LEAKING EXHAUST GASSES. THE CONTACT INSTALLED NEW WASHERS. THE CONTACT STATED THE FUMES IN THE VEHICLE CAUSED THE PASSENGERS IN THE VEHICLE TO EXPERIENCE BREATHING PROBLEMS, WATERING OF THE EYES AND HEADACHES. THE CONTACT STATED WHEN THE BRAKE PEDALWAS DEPRESSED IT WENT DOWN TO THE FLOORBOARD WHEN GOING DOWNHILL. THE DEALER STATED THISWAS NORMAL FOR THIS VEHICLE. THE VEHICLE CURRENTLY HAD 120000 MILES. *AK

Mileage: 120,000