2005 CHEVROLET VENTURE

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

STEERING

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passenger’s side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assembly, brakes, rotors, struts, and tires. The failure persisted. The contact took the vehicle to another certified mechanic who performed a front-end alignment however, the failure persisted. The vehicle was taken to a third mechanic who identified that the noise seemed to be coming from the steering wheel; however, the mechanic could not verify the cause of the failure. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 236,000.

Mileage: 236,000

The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passenger’s side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assembly, brakes, rotors, struts, and tires. The failure persisted. The contact took the vehicle to another certified mechanic who performed a front-end alignment however, the failure persisted. The vehicle was taken to a third mechanic who identified that the noise seemed to be coming from the steering wheel; however, the mechanic could not verify the cause of the failure. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 236,000.

Mileage: 236,000

TL* THE CONTACT OWNED A 2005 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 35 MPH IN THE RAIN, THE VEHICLE HYDROPLANED TO THE LEFT AND THEN BACK TO ITS LANE. THE REAR TIRES ROLLED OFF THE ROAD AND CAUSED THE VEHICLE TO CRASH INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A BODY SHOP AND DEEMED DESTROYED BY THE INSURANCE COMPANY. THE FAILURE MILEAGE WAS 130,000.

Mileage: 130,000

MY WIFE HIT A OLD STYLE VAN THAT HAD STOPPED FOR A DOG CROSSING A THE ROAD. THE WHOLE FRONT END HAD TO BE REPLACED. HOOD, GRILL, LIGHTS, BOTH FENDER HAD TO BE REPAIRED, ALSO THE STEAL TUBE UNDER THE RADIATOR FRAME HAD TO BE CUT OUT AND REPLACED. ON 11/5/2010 I HIT A DEER GOING 30 MPH, AGAIN FRONT END DAMAGE. BOTH TIMES THE AIR BAGS DIDN'T DEPLOY, AND ON STAR DIDN'T RESPOND. I ASKED TWO DIFFERENT CHEVROLET DEALERS IF THE AIR BAG SENSOR COULD BE TESTED, ANSWER WAS NO.

Mileage: 49,357

MY WIFE HIT A OLD STYLE VAN THAT HAD STOPPED FOR A DOG CROSSING A THE ROAD. THE WHOLE FRONT END HAD TO BE REPLACED. HOOD, GRILL, LIGHTS, BOTH FENDER HAD TO BE REPAIRED, ALSO THE STEAL TUBE UNDER THE RADIATOR FRAME HAD TO BE CUT OUT AND REPLACED. ON 11/5/2010 I HIT A DEER GOING 30 MPH, AGAIN FRONT END DAMAGE. BOTH TIMES THE AIR BAGS DIDN'T DEPLOY, AND ON STAR DIDN'T RESPOND. I ASKED TWO DIFFERENT CHEVROLET DEALERS IF THE AIR BAG SENSOR COULD BE TESTED, ANSWER WAS NO.

Mileage: 49,357

WE HAVE BEEN SMELLING GASOLINE FUMES IN AND OUTSIDE OUR VAN. SOMETIMES IT IS VERY POTENT AND OTHER TIMES FAINT. WHEN WE WALK INTO OUR GARAGE, WE CAN SMELL IT ALSO. IT OCCURS OFTEN WHEN MAKING A LEFT-HAND TURN. WHEN WE INSPECT IT, WE CAN'T FIND ANY LEAK. WE SMELL THIS FROM A HALF TANK TO EMPTY. *TR

Mileage: 225,000

2005 CHEVROLET VENTURA. CONSUMER WRITES IN REGARDS TO NON-DEPLOYMENT OF AIR BAGS. *SMD THE CONSUMER STATED HIS FATHER AND STEP-MOTHER WERE INVOLVED IN AN ACCIDENT. HIS FATHER DIED FROM HIS INJURIES AND HIS STEP-MOTHER WAS INJURED. THE CONSUMER STATED HIS FATHER HIT A DIRT BANK HEAD-ON AND THE AIR BAGS FAILED TO DEPLOY. AS A RESULT, HIS FATHER HIT THE STEERING WHEEL WITH HIS CHEST CAUSING DAMAGE TO HIS LUNGS, SPLEEN, KIDNEYS AND RIBS. HIS STEP-MOTHER HIT THE DASH AND CENTER CONSOLE WITH HER HEAD, CUTTING HER ACROSS THE FOREHEAD. *JB

TL * THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT BUCKLE RELEASE MECHANISM FRACTURED. THE DEALER ORDERED A SEAT BELT MOUNTING KIT TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 10/24/2014*LJ UPDATED 7/14/2015*JS

Mileage: 90,000

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT SMELLED FUEL WITHIN THE CABIN OF THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FUEL ODOR. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

THE VAN FILLS WITH FUEL FUMES. THE FUMES CAN BE SMELLED INSIDE AND OUTSIDE THE VEHICLE. GM HAS RECALLED CHEVY VENTURE 2001-2004 FOR SPECIFIC VIN#'S BUT NO 2005'S AND MY SPECIFIC VIN# IS NOT INCLUDED. I HAVE TALKED WITH GM BUT THEIR RESPONSE IS JUST YOUR VIN# IS NOT INCLUDED. YOU CAN GO TO THE DEALERSHIP AND PAY FOR IT TO GET FIXED. THIS IS A SPECIFIC FIRE HAZARD ACCORDING TO THEIR REPORTS. I HAVE HAD TO PARK MY VEHICLE FOR SAFETY REASONS. I CAN NOT ALLOW MY CHILDREN TO BE SUBJECTED TO THE FUEL FUMES OR THE POTENTIAL OF A FIRE. I AM NOT IN A POSITION AT THIS TIME TO PAY FOR THE WORK OR TRADE DUE TO THE ECONOMY. IF GM KNOWS THAT HAVE THIS PROBLEM THEN WHY WOULD THEY LET A POTENTIAL HAZARD TO LOYAL CUSTOMERS CONTINUE. REGARDLESS OF THE VIN# IF THE PROBLEM IS PRESENT THEN GM SHOULD BE RESPONSIBLE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 85,000

THE DRIVER WAS SLOWING OR STOPPED WHEN SHE WAS REAR ENDED. THE FRONT DRIVER SEAT AIRBAG DEPLOYED. IT IS UNCLEAR WHETHER THE AIRBAG DEPLOYED PREMATURELY OR WHETHER IT DEPLOYED AFTER THE VEHICLE WAS REAR ENDED. *TR

THE DRIVER WAS SLOWING OR STOPPED WHEN SHE WAS REAR ENDED. THE FRONT DRIVER SEAT AIRBAG DEPLOYED. IT IS UNCLEAR WHETHER THE AIRBAG DEPLOYED PREMATURELY OR WHETHER IT DEPLOYED AFTER THE VEHICLE WAS REAR ENDED. *TR

ROUGH SHIFTING FROM BEGINNING NOW 2ND GEAR OUT AFTER LIGHTS WERE LEFT ON BY ACCIDENT AND DRAINED BATTERY. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE REFUELING, FUEL SPRAYED FROM THE FILLER NECK VALVE. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC, WHO STATED THAT THE FUEL TANK HAD FAILED. THE CONTACT WAS ALSO INFORMED BY THE DEALER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07E021000 (FUEL SYSTEM, OTHER). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 70,000. UPDATED 10/17/13*CN

Mileage: 70,000

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE REFUELING, FUEL SPRAYED FROM THE FILLER NECK VALVE. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC, WHO STATED THAT THE FUEL TANK HAD FAILED. THE CONTACT WAS ALSO INFORMED BY THE DEALER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07E021000 (FUEL SYSTEM, OTHER). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 70,000. UPDATED 10/17/13*CN

Mileage: 70,000

THE ABS LIGHT CAME ON AS WE WERE BRAKING. THE BRAKES THEN STARTED FEELING LIKE THEY WERE WORKING INTERMITTENTLY. THIS CAUSED THE CAR TO FEEL LIKE IT WAS NOT GOING TO STOP. WE WERE NOT EVEN GOING THAT FAST. WE OWNED A PREVIOUS 2005 CHEVROLET VENTURE AND IT HAD THE SAME PROBLEM. *TR

Mileage: 130,000

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE PASSENGER SIDE POWER DOOR WOULD NOT LOCK. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THE SLIDING DOOR LOCK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 145,000.

Mileage: 145,000

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE ATTEMPTED TO SLOW DOWN AND THE VEHICLE BEGAN TO PULL TOWARD THE RIGHT. THE BEARING ON THE BRAKING SYSTEM ALSO BEGAN TO GRIND. THE CONTACT STATED THAT THE BEARINGS NEEDED TO BE REPLACED AND HE REPAIRED THE VEHICLE HIMSELF. THE FAILURE RECURRED ONCE MORE AND THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP FOR REPAIR. THE FAILURE CONTINUED TO RECUR. THE CONTACT HAD NOT NOTIFIED THE MANUFACTURER. THE FAILURE MILEAGE WAS 50,000.

Mileage: 50,000

I HAVE A 2005 CHEVROLET VENTURE MINI VAN THAT HAS DEVELOPED A FUEL LEAK AROUND THE AREA WHERE THE FILLER TUBE CONNECTS TO THE FUEL TANK. HAVING RESEARCHED THIS, IT IS APPARENT THAT THIS HAS BEEN A PROBLEM FOR THESE VEHICLES AS EARLY AS 2003. THIS THE THIRD TIME THIS HAS HAPPENED ON MY VAN. I HAVE ATTEMPTED TO REPAIR IT TWICE, USING AN EPOXY SEALER,BUT THE LEAK REDEVELOPS AFTER A FEW DAYS. I MIGHT HAVE TO REPLACE THE FUEL TANK AND FILLER TUBE, IF I CAN FIND ONE THAT I CAN AFFORD. GM SAYS THAT THIS IS NOT DEFECT AND WILL NOT ISSUE A RECALL, BUT IT SEEMS THAT JUST THE IDEA OF FIRE HAZARD WOULD BE ENOUGH REASON FOR GM TO FIX THE PROBLEM. I DO NOT SEE HOW GM CAN NOT SAY THAT THIS IS NOT A DEFECT IN THE DESIGN, SINCE THIS HAS OCCURRED A NUMBER OF TIME. IT'S A PLASTIC SIDE MOUNTED TANK WITH NO PROTECTION SURROUNDING IT AND A FILLER TUBE THAT JOINS IT IN A VERY VULNERABLE AREA. *TR

Mileage: 145,000

SPEEDOMETER NEVER DROPS BELOW 55 MPH WHEN VEHICLE IS STANDING STILL AND HAS INCREASED TO 95 MPH AT TIMES. *TR

Mileage: 98,600