2000 CHEVROLET VENTURE

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SI

STEERING

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND A

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE

SEAT BELTS

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHI

In January 2022, I noticed white smoke coming from the engine and a mechanic said it was the water pump that needed to be replaced, so I have it replaced. Recently, I noticed the same white smoke coming from the engine and took it back to the same mechanic who installed the water pump. The mechanic said it was the intake manifold that caused the white smoke. I decided to take it to another mechanic to see if the first diagnosis was correct and that mechanic confirmed the first mechanic's diagnosis and my previous experience with another GM vehicle (1997 Vhevy Lumina) that had the exact same problem: water pump went out and intake manifold also started to fail until the Lumina's engine was fried.

In January 2022, I noticed white smoke coming from the engine and a mechanic said it was the water pump that needed to be replaced, so I have it replaced. Recently, I noticed the same white smoke coming from the engine and took it back to the same mechanic who installed the water pump. The mechanic said it was the intake manifold that caused the white smoke. I decided to take it to another mechanic to see if the first diagnosis was correct and that mechanic confirmed the first mechanic's diagnosis and my previous experience with another GM vehicle (1997 Vhevy Lumina) that had the exact same problem: water pump went out and intake manifold also started to fail until the Lumina's engine was fried.

Car is losing coolant quickly, even though I have replaced the water pump about a month ago. Due to GM Manufactuing, they only allow Dex Cool coolant for their vehicles but not everyone carries Dex Cool. Also, the oxygen sensor code need to be read oxygen sensor only and not with 4 or 5 other codes.

Car is losing coolant quickly, even though I have replaced the water pump about a month ago. Due to GM Manufactuing, they only allow Dex Cool coolant for their vehicles but not everyone carries Dex Cool. Also, the oxygen sensor code need to be read oxygen sensor only and not with 4 or 5 other codes.

AIR BAG LIGHT WILL NOT TURN OFF, THERE IS NO WAY TO FIX IT AS THEY DON'T MAKE THE PARTS ANYMORE, NOT SURE IF AIRBAG WILL DEPLOY IF EVER NEEDED.

Mileage: 105,000

WAS DRIVING FORWARD COMING UP TO AN INTERSECTION AND APPROACHING A RED LIGHT WHEN THE BRAKES WENT OUT .WHEN TRYING TO STOP AND PUSH THE BRAKE DOWN IT STARTED SHAKING AND THE BRAKE CAME UP AND THEN WHEN PUSHED IT BACK DOWN IT WENT TO THE FLOOR AND THE BRAKES WERE COMPLETELY OUT. THEM GOING OUT CAUSED US TO ROLL THROUGH THE INTERSECTION CAUSING US TO GET HIT BY A VEHICLE COMING THROUGH THE LIGHT, SPINNING US AROUND AND GOT HIT MORE THAN ONCE. HIT US ON BOTH SIDES OF VEHICLE AND WINDOWS WERE SHATTERED OUT BUT NOT ONE AIR BAG WENT OFF/DEPLOYED AT ALL AND THE VEHICLE WAS TOTALLED.THERE WERE 3 BABIES IN THE VEHICLE WHEN THE AIR BAGS DID NOT DEPLOY.

Mileage: 137,000

WAS DRIVING FORWARD COMING UP TO AN INTERSECTION AND APPROACHING A RED LIGHT WHEN THE BRAKES WENT OUT .WHEN TRYING TO STOP AND PUSH THE BRAKE DOWN IT STARTED SHAKING AND THE BRAKE CAME UP AND THEN WHEN PUSHED IT BACK DOWN IT WENT TO THE FLOOR AND THE BRAKES WERE COMPLETELY OUT. THEM GOING OUT CAUSED US TO ROLL THROUGH THE INTERSECTION CAUSING US TO GET HIT BY A VEHICLE COMING THROUGH THE LIGHT, SPINNING US AROUND AND GOT HIT MORE THAN ONCE. HIT US ON BOTH SIDES OF VEHICLE AND WINDOWS WERE SHATTERED OUT BUT NOT ONE AIR BAG WENT OFF/DEPLOYED AT ALL AND THE VEHICLE WAS TOTALLED.THERE WERE 3 BABIES IN THE VEHICLE WHEN THE AIR BAGS DID NOT DEPLOY.

Mileage: 137,000

BOUGHT 4 NEW GOODYEAR VIVA 2 TIRES AT WALMART IN APPROXIMATELY 2014 SOMETIME. ACCORDING TO LOCAL TIRE SHOP THEY HAVE 2014 DATE CODES. VAN STARTED DEVELOPING A LOW SPEED WOBBLE WHEN DRIVING. FRONT L TIRE WAS LOW ON PRESSURE SO TOOK TO A LOCA SHOP TO HAVE IT CHECKED THINKING I JUST NEEDED A PATCH. WRONG! THE SHOP DISCOVERED A TREAD SEPARATION ON THE INSIDE SIDEWALL! LUCKILY I WAS NOT DRIVING ON THE HIGHWAY. AFTER COMING HERE AND READING ALL THE OTHER ALMOST IDENTICAL COMPLAINTS TO ME IT LOOKS LIKE THERE IS A TREND OF BULGING/POOR RIDE QUALITY/BLOWOUTS AND TREAD SEPARATION FROM THESE WALMART GOODYEARS. LUCKILY I ONLY MADE A 2 MILE ROUND TRIP FROM HOME TO A FRIENDS AND I WAS ABLE TO CATCH THIS BEFORE I HAD A BLOWOUT.

Mileage: 150,000

TL* THE CONTACT OWNED A 2000 CHEVROLET VENTURE. AFTER BEING PARKED FOR TWO DAYS, THE VEHICLE SUDDENLY CAUGHT FIRE. THE CONTACT MENTIONED THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT AND CAUSED A GARAGE LOCATED NEXT TO THE VEHICLE TO CATCH FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

TL* THE CONTACT OWNED A 2000 CHEVROLET VENTURE. AFTER BEING PARKED FOR TWO DAYS, THE VEHICLE SUDDENLY CAUGHT FIRE. THE CONTACT MENTIONED THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT AND CAUSED A GARAGE LOCATED NEXT TO THE VEHICLE TO CATCH FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

PLEASE INVESTIGATE INCIDENTS OF FAILURE OF THE GM PASSKEY/PASSLOCK/VATS SECURITY SYSTEM. SECURITY LIGHT WOULD FLASH AND VEHICLE EXPERIENCED A TOTAL LOSS OF POWER. PROBLEM OCCURRED INTERMITTENTLY FOR THE NEXT SEVERAL MONTHS, AT VARIOUS SPEEDS. NO ACCIDENTS INVOLVED, BUT SEVERAL NEAR MISSES. PROBLEM OCCURRED VERY FREQUENTLY IN THE PAST WEEK, AND NOW VEHICLE WILL NOT START DUE TO SECURITY FEATURE. I AM USING FACTORY ORIGINAL KEYS, NOT REPLACEMENTS. PROBLEM AFFECTS THIS PARTICULAR MAKE AND MODEL, BUT IT IS SO SYSTEMIC TO GM, AN ENTIRE AFTERMARKET INDUSTRY HAS ARISEN TO BYPASS THIS SECURITY "FEATURE." *TR

Mileage: 130,000

PLEASE INVESTIGATE INCIDENTS OF FAILURE OF THE GM PASSKEY/PASSLOCK/VATS SECURITY SYSTEM. SECURITY LIGHT WOULD FLASH AND VEHICLE EXPERIENCED A TOTAL LOSS OF POWER. PROBLEM OCCURRED INTERMITTENTLY FOR THE NEXT SEVERAL MONTHS, AT VARIOUS SPEEDS. NO ACCIDENTS INVOLVED, BUT SEVERAL NEAR MISSES. PROBLEM OCCURRED VERY FREQUENTLY IN THE PAST WEEK, AND NOW VEHICLE WILL NOT START DUE TO SECURITY FEATURE. I AM USING FACTORY ORIGINAL KEYS, NOT REPLACEMENTS. PROBLEM AFFECTS THIS PARTICULAR MAKE AND MODEL, BUT IT IS SO SYSTEMIC TO GM, AN ENTIRE AFTERMARKET INDUSTRY HAS ARISEN TO BYPASS THIS SECURITY "FEATURE." *TR

Mileage: 130,000

TL* THE CONTACT OWNS A 2000 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE SEAT BELT WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 00V228003 (SEAT BELT). THE APPROXIMATE FAILURE MILEAGE WAS 186,000.

Mileage: 186,000

I WAS SITTING IN TRAFFIC AT A DEAD STOP,THEN WHEN THE TRAFFIC LIGHT CHANGED TO GREEN I PUT MY FOOT ON THE GAS PEDAL. AS SOON AS I DID THE ACCELERATOR PEDAL STUCK,WENT ALL THE WAY TO THE FLOOR AND CAUSED ME TO HIT THE VEHICLE IN FRONT OF ME. ALSO MY GAS GAUGE DIDN'T WORK AND WOULD RANDOMLY MOVE BACK AND FORTH,EVEN IF I HAD A FULL TANK OF GAS. THEN,THE DRIVER SIDE BRAKE LIGHT CONTINUED TO GO OUT DUE TO THE MELTING OF THE PART OF THE BULB,NOT THE BULB ITSELF. MY ELECTRIC SLIDING DOOR ON PASSENGER SIDE CAME OFF THE TRACK DUE TO THE CORD AND PULLEY/MOTOR IN THE DOOR. I COULD NEVER GET THE DOOR TO WORK OTHER THAN BY MANUALLY OPENING AND CLOSING THE DOOR AFTER THAT. *TR

Mileage: 130,287

I WAS SITTING IN TRAFFIC AT A DEAD STOP,THEN WHEN THE TRAFFIC LIGHT CHANGED TO GREEN I PUT MY FOOT ON THE GAS PEDAL. AS SOON AS I DID THE ACCELERATOR PEDAL STUCK,WENT ALL THE WAY TO THE FLOOR AND CAUSED ME TO HIT THE VEHICLE IN FRONT OF ME. ALSO MY GAS GAUGE DIDN'T WORK AND WOULD RANDOMLY MOVE BACK AND FORTH,EVEN IF I HAD A FULL TANK OF GAS. THEN,THE DRIVER SIDE BRAKE LIGHT CONTINUED TO GO OUT DUE TO THE MELTING OF THE PART OF THE BULB,NOT THE BULB ITSELF. MY ELECTRIC SLIDING DOOR ON PASSENGER SIDE CAME OFF THE TRACK DUE TO THE CORD AND PULLEY/MOTOR IN THE DOOR. I COULD NEVER GET THE DOOR TO WORK OTHER THAN BY MANUALLY OPENING AND CLOSING THE DOOR AFTER THAT. *TR

Mileage: 130,287

I WAS SITTING IN TRAFFIC AT A DEAD STOP,THEN WHEN THE TRAFFIC LIGHT CHANGED TO GREEN I PUT MY FOOT ON THE GAS PEDAL. AS SOON AS I DID THE ACCELERATOR PEDAL STUCK,WENT ALL THE WAY TO THE FLOOR AND CAUSED ME TO HIT THE VEHICLE IN FRONT OF ME. ALSO MY GAS GAUGE DIDN'T WORK AND WOULD RANDOMLY MOVE BACK AND FORTH,EVEN IF I HAD A FULL TANK OF GAS. THEN,THE DRIVER SIDE BRAKE LIGHT CONTINUED TO GO OUT DUE TO THE MELTING OF THE PART OF THE BULB,NOT THE BULB ITSELF. MY ELECTRIC SLIDING DOOR ON PASSENGER SIDE CAME OFF THE TRACK DUE TO THE CORD AND PULLEY/MOTOR IN THE DOOR. I COULD NEVER GET THE DOOR TO WORK OTHER THAN BY MANUALLY OPENING AND CLOSING THE DOOR AFTER THAT. *TR

Mileage: 130,287

TL* THE CONTACT OWNS A 2000 CHEVROLET VENTURA. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN ANOTHER VEHICLE CRASHED INTO THE PASSENGER'S SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT AND THE DRIVER OF THE SECOND VEHICLE WERE INJURED AND REQUIRED MEDICAL ASSISTANCE. THE CONTACT ALSO SUSTAINED BRUISING FROM THE SEAT BELT RESTRAINING UPON IMPACT. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 174,699.

Mileage: 174,699

FUEL LINES CORRODED, DANGEROUS. GASOLINE LEAKS. SENT TO DEALERSHIP FOR REPAIRS. NOTIFIED THAT THE PARTS ARE DISCONTINUED. THIS VEHICLE HAS BEEN RECALLED FOR OTHER FUEL ISSUES. CHEVY DEALER NOT ABLE TO REPAIR VEHICLE THAT THEY BUILT IN 2000. IF YOU HAVE A 2000 CHEVY VENTURE YOU SHOULD HAVE THE CAR FUEL LINES NEAR THE ENGINE INSPECTED AND REPAIRED AND YOU SHOULD CONTACT CHEVROLET & GM TO INSIST THAT THE BUILD THE REPLACEMENT PARTS TO REPAIR THE CAR SO THAT PEOPLE ARE NOT INJURED. *TR

Mileage: 1,001,357

THE VAN WOULD SHUT DOWN WHILE I WAS DRIVING. IT WOULD NOT RESTART. I WOULD HAVE IT TOWED TO DEALER. DEALER NEVER FOUND PROBLEM. THEY BLAMED IT ON ELECTRICAL SYSTEM. HAPPENED AT LEAST 3 TIMES. DEALER WOULD HAVE RECORDS. I WOULD LOSE CONTROL OF STEERING. BREAKING WAS VERY DIFFICULT. *TR

Mileage: 2,000

FOR 6-7 YEARS WE HAVE EXPERIENCED VARIOUS LIGHTING PROBLEMS WITH OUR CHEVY VENTURE (2000). THE LEFT REAR CIRCUIT BOARD HAS BURNED OUT TWICE. I RECENTLY PUT A NEW ONE ON AND NOW JUST ABOUT 12 WEEKS LATER, I AM HAVING BREAK AND BLINKER ISSUES AGAIN. ACTUALLY, THE BLINKER STARTED HAVING ISSUES WITHIN DAYS. *TR