Total Complaints
10 filings
CHEVROLET SONIC · model year
2019 CHEVROLET SONIC
10 NHTSA complaints for this specific cohort.
NHTSA overall rating
5 / 5 ★
New Car Assessment Program
The 2019CHEVROLETSONIC carries 10 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. For crash performance, NHTSA's New Car Assessment Program gave this cohort an overall 5/5 rating, with 5/5 front crash, 5/5 side crash, and 4/5 rollover scores derived from standardized barrier and dynamic tests.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2019 SONIC is unknown or other with 3 filings, followed by fuel/propulsion system (2) and engine (2). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability.
NHTSA currently has 57 investigation files overlapping the 2019 SONIC, and 2 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
10
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
- Front Crash 5.0 ★
- Side Crash 5.0 ★
- Rollover 4.0 ★
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
NHTSA NCAP overall: 5/5 — Top NCAP rating
· Front: 5/5
· Side: 5/5
· Rollover: 4/5
Complaints by Component
| Component | Count |
|---|---|
| UNKNOWN OR OTHER | 3 |
| FUEL/PROPULSION SYSTEM | 2 |
| ENGINE | 2 |
| ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER | 1 |
| ENGINE AND ENGINE COOLING | 1 |
| ELECTRICAL SYSTEM | 1 |
Recent Complaints
20241113FUEL/PROPULSION SYSTEM
The thermostat housing and water pump keeps failing and leaking.The seat heaters dont work. The car started leaking antifreeze real bad which cause it to overheat and lock up. Yes it has been confirm by a dealer that alot of the chevys been coming for new thermostat housing and water pumps. No vehicle was only inspected by a dealer. The overheating like came on and then 10 seconds later the car locked up
20241113ENGINE
The thermostat housing and water pump keeps failing and leaking.The seat heaters dont work. The car started leaking antifreeze real bad which cause it to overheat and lock up. Yes it has been confirm by a dealer that alot of the chevys been coming for new thermostat housing and water pumps. No vehicle was only inspected by a dealer. The overheating like came on and then 10 seconds later the car locked up
20241113ELECTRICAL SYSTEM
The thermostat housing and water pump keeps failing and leaking.The seat heaters dont work. The car started leaking antifreeze real bad which cause it to overheat and lock up. Yes it has been confirm by a dealer that alot of the chevys been coming for new thermostat housing and water pumps. No vehicle was only inspected by a dealer. The overheating like came on and then 10 seconds later the car locked up
20240729ENGINE AND ENGINE COOLING
The contact owns a 2019 Chevrolet Sonic. The contact stated while pulling into the garage, the high engine temp warning light illuminated, and the engine was overheating. The contact immediately turned off the vehicle. The contact stated there was coolant underneath the front of the vehicle. The contact had learned that the water pump failure was common for the vehicle and believed that the water pump had failed. The contact was able to identify an extended warranty for the failure. The vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure when it was confirmed that the VIN was not covered under warranty or recall. The manufacturer had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 81,400.
Mileage: 81,400
20240524ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
The contact owns a 2019 Chevrolet Sonic. The contact stated the RPMs rose abnormally high. The contact stated that the check engine warning light had illuminated. The vehicle was taken to an AutoZone where it was scanned and diagnosed that the turbo charger had failed and needed to be replaced. The diagnostic scan retrieved DTC code: P0299. The manufacturer was made aware of the failure. The failure mileage was approximately 47,600.
Mileage: 47,600
20240424ENGINE
There is no temperature indicator and the car overheats. This caused the hose to the coolant to leak. I had the housing unit replaced but then the car still ran hot. I had the get the whole thermostat replaced. No forum could assist with the replacement of the 2019 as if this year model doesnât exist and the part needed doesnât fit properly making my car inoperable.
20240205UNKNOWN OR OTHER
Cooling Issues with 2019
20240205FUEL/PROPULSION SYSTEM
cooling ISSUES - the WATER PUMPLE , cooling TANK . the WHOLE COOLING . my CARE HAS BEEN SHOP 5 TIMES AT JBA for cooling system
20240115UNKNOWN OR OTHER
the CAR WAS BOUGHT IN May 24 of 2019. Since the car has been in the shop 4 times at JBA in Glen Burnie MD were I bought car From . Car been in Shop at JBA 01/29/2020 -Coolant Leaking , Was back in Shop 07/25/2022 - Water Pump Leaking , Car was Leaking Coolant, Back in shop October 2023 - For Over heating , Cooling System, Here we are January of 2024 car going back in shop at JBA or Cooling Issues
20190716UNKNOWN OR OTHER
VEHICLE IS MAKING A LOUD 'HOWLING' NOISE. I BROUGHT IT TO THE DEALERSHIP, AND THEY SAID THAT THERE IS NO FIX TO IT.
Mileage: 25
Compare 2019CHEVROLETSONIC to Similar Vehicles
NHTSA Investigations 2 Open
EA25007Engineering AnalysisOpen
Loss of motive power due to engine failure
PE23022Preliminary EvaluationClosed
Loss of Motive Power due to the Battery Energy Control Module
PE20016Preliminary EvaluationClosed
Electric Vehicle Battery Fires
EA20002Engineering AnalysisClosed
Outboard Front Seat Belt Anchor Cable Failure
PE20011Preliminary EvaluationClosed
Fuel Line Leak
Frequently Asked Questions
How many complaints does the 2019 CHEVROLET SONIC have?▼
The 2019 CHEVROLET SONIC has 10 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
What is the safety rating for the 2019 CHEVROLET SONIC?▼
The 2019 CHEVROLET SONIC received an overall NHTSA safety rating of 5/5, front crash rating of 5/5, side crash rating of 5/5, and rollover rating of 4/5.
What are the most common problems with the 2019 CHEVROLET SONIC?▼
The most-complained component for the 2019 CHEVROLET SONIC is UNKNOWN OR OTHER with 3 complaints. Other frequently reported areas include FUEL/PROPULSION SYSTEM and ENGINE.
Is the 2019 CHEVROLET SONIC safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. The 2019 CHEVROLET SONIC has an NHTSA safety rating of 5/5. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.