2006 CHEVROLET SILVERADO 2500

STEERING

CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING FATIGUE CONDITION, RESULTING IN A TOTAL LOSS

265/75R16 9100 miles driven mostly on pavement with loads well within the vehicle capacity and never off road. Tires were rotated several months prior, about 100 miles ago and damage was not noted. Bubble appeared on sidewall which was noticed while parked; Tire shop dismounted the tire to inspect for possible causes and found nothing to explain damage (run flat, left deflated, road hazard damage). Secondary bubble slightly smaller on inside at same location. Smaller bubbles were felt inside tire and a longer, slight bubble follows the bead 1/3-1/2 of the diameter of the tire. Shop manager refused to remount tire due to risk to employees of catastrophic failure, indicating the tire poses significant safety risk if vehicle had been at highway speed and completed its deterioration. Mate to this tire on right rear shows same smaller bubble above the bead about 1/3 of tire diameter.

On 31 Dec 21, I drove the vehicle to the car wash, after the wash was completed, I drove the vehicle approx. 1/2 mile down the road. I pulled in to a fast food lane to order a meal. While I was stopped that speaker ordering the Air bags deployed. I was not moving or struck my another vehicle. If had happen when I was driving on the hi-way it may have caused injury to myself or damage to other vehicles. The vehicle is currently available for inspection. I will be taking the vehicle to the dealer for inspection on 3 Jan 22. There was no warning prior to the deployment of the airbags.

ANYTIME A TRAILER IS FIRST ATTACHED, THE TRUCK WILL RANDOMLY GO INTO REDUCED POWER MODE WHILE DRIVING. THIS IS VERY UNSAFE AS THE TRUCK CAN TO THIS AT HIGHWAY SPEED IN TRAFFIC. IT WILL DO THIS A FEW TIMES UNTIL THE PCM "LEARNS" THERE IS A TRAILER ATTACHED. GM IS AWARE OF THE ISSUE AND ISSUED SERVICE BULLETIN 06-06-04-042B TO ADDRESS THE ISSUE BY REPROGRAMMING THE PCM. BECAUSE OF THE SAFETY CONCERNS, THIS SHOULD BE ADDRESSED AS A RECALL. HOWEVER,I HAD TO TAKE THE TRUCK INTO THE DEALER FOR THE UPDATE AND WAS EXPECTED TO PAY FOR THEM FIXING A KNOWN SOFTWARE ISSUE. INSTEAD OF DOING THE UPDATE AT NO CHARGE, THEY MANAGED TO DAMAGE THE PCM WHILE PERFORMING THE UPDATE. THE PCM IS NO LONGER SERVICEABLE AND THE DEALER IS WANTING TO CHARGE ME FOR A REPLACEMENT EVEN THOUGH IT WAS DAMAGED DURING A CALLED FOR SERVICE BULLETIN UPDATE. THE VEHICLE WAS NOT ORIGINALLY EQUIPPED WITH A TRAILER HITCH SO THE PROBLEM DIDN'T ARISE UNTIL THE HITCH WAS INSTALLED AND A TRAILER WAS ATTACHED.

Mileage: 198,000

GOING DOWN A SNOWY GRAVEL ROAD AND LOST CONTROL. HIT A DITCH/SNOW BANK HEAD ON AT APPROX. 30MPH. AIR BAGS DID NOT DEPLOY. AS A RESULT DRIVER SUSTAINED HAND INJURY, A BROKEN JAW REQUIRING SURGERY, AND OTHER MINOR BODILY INJURIES. VEHICLE HAD 313,000 MILES

Mileage: 313,000

EXHAUST MANIFOLD BOLTS ARE BROKEN OFF ON BOTH SIDES OF THE 6.0 ENGINE, CAUSING EXHAUST FUMES IN THE PASSENGER COMPARTMENT WHEN I DRIVING THE VEHICLE. I HAVE OWNED THIS VEHICLE SINCE NEW AND HAVE NEVER HAD ANY ENGINE WORK DONE TO THIS VEHICLE.

Mileage: 40,000

THE REAR BRAKES FAILED WITH LITTLE OR NO WARNING. THE BRAKES WENT FROM GOOD TO MUSHY WITHOUT WARNING LIGHT. I ADDED BRAKE FLUID TO TEST IN DRIVE WAY. PUMPED THE BRAKES AND THE WARNING LIGHT CAME ON. THE REAR LINE FAILED. I HAD THE TRUCK INSPECTED AT A GENERAL MOTORS DEALER IN JANUARY OF 2018 AND ALSO AT THE END OF FEBRUARY. THE SAID MY VEHICLE IS MAINTAINED IN EXCELLENT CONDITION. IF THIS COULD HAPPEN TO ME....ALL GM VEHICLES WITH THESE BRAKE LINES ARE AT RISK. I READ THEIR WAS A SAFETY BULLETIN 13-05-22-001. TODAY IS 4/12/2018...BECAUSE I TOW A BOAT TO FLORIDA I HAD THE TRUCK CHECKED 2 TIMES IN THE LAST 12 WEEKS....IF THE DEALERS CAN'T DETECT FAULTY LINES....A RECALL IS NEEDED.

Mileage: 110,000

UPON STARTING MY TRUCK, THE OIL PRESSURE GAUGE IMMEDIATELY GOES TO 80 WITH NO ACCELERATION. AT THIS POINT, THERE IS NO NOISE OR OTHER LIGHTS COMING ON TO WARN OF OTHER PROBLEMS. THIS PROBLEM STARTED A FEW DAYS AGO. WHEN TRUCK IS IN MOTION THE OIL PRESSURE GAUGE CONTINUES TO STAY ON 80. I KNOW THE 2006 CHEVY 2500 HEAVY DUTY 4X4 HAVE HAD RECALLS ON DIFFERENT THINGS, BUT NEED TO SEE IF THIS IS A PROBLEM FOR OTHER CHEVY TRUCKS AS WELL. I HAVE READ SEVERAL RECALLS ABOUT THESE TRUCKS AND A LOT OF THEM WE HAVE NEVER BEEN NOTIFIED TO TAKE IT TO A DEALER TO BE CHECKED. ANY HELP YOU CAN GIVE US WOULD BE DEEPLY APPRECIATED.

Mileage: 100,000

UPON STARTING MY TRUCK, THE OIL PRESSURE GAUGE IMMEDIATELY GOES TO 80 WITH NO ACCELERATION. AT THIS POINT, THERE IS NO NOISE OR OTHER LIGHTS COMING ON TO WARN OF OTHER PROBLEMS. THIS PROBLEM STARTED A FEW DAYS AGO. WHEN TRUCK IS IN MOTION THE OIL PRESSURE GAUGE CONTINUES TO STAY ON 80. I KNOW THE 2006 CHEVY 2500 HEAVY DUTY 4X4 HAVE HAD RECALLS ON DIFFERENT THINGS, BUT NEED TO SEE IF THIS IS A PROBLEM FOR OTHER CHEVY TRUCKS AS WELL. I HAVE READ SEVERAL RECALLS ABOUT THESE TRUCKS AND A LOT OF THEM WE HAVE NEVER BEEN NOTIFIED TO TAKE IT TO A DEALER TO BE CHECKED. ANY HELP YOU CAN GIVE US WOULD BE DEEPLY APPRECIATED.

Mileage: 100,000

UPON STARTING MY TRUCK, THE OIL PRESSURE GAUGE IMMEDIATELY GOES TO 80 WITH NO ACCELERATION. AT THIS POINT, THERE IS NO NOISE OR OTHER LIGHTS COMING ON TO WARN OF OTHER PROBLEMS. THIS PROBLEM STARTED A FEW DAYS AGO. WHEN TRUCK IS IN MOTION THE OIL PRESSURE GAUGE CONTINUES TO STAY ON 80. I KNOW THE 2006 CHEVY 2500 HEAVY DUTY 4X4 HAVE HAD RECALLS ON DIFFERENT THINGS, BUT NEED TO SEE IF THIS IS A PROBLEM FOR OTHER CHEVY TRUCKS AS WELL. I HAVE READ SEVERAL RECALLS ABOUT THESE TRUCKS AND A LOT OF THEM WE HAVE NEVER BEEN NOTIFIED TO TAKE IT TO A DEALER TO BE CHECKED. ANY HELP YOU CAN GIVE US WOULD BE DEEPLY APPRECIATED.

Mileage: 100,000

THE RIGHT FRONT BRAKE LINE ON MY TRUCK RUSTED THROUGH. I LOST BRAKING WHEN LOADING MY 10 FT CAMPER IN THE DRIVEWAY. I TOOK THE TRUCK TO DEALERSHIP AND IT WAS FOUND THAT ALL THE BRAKE LINES ARE RUSTED AND IN DANGER OF FAILURE AT ANY TIME. ALL OF THE BRAKE LINES ON THE TRUCK ARE BARE METAL AND PRONE TO RUST. NEW BRAKE LINES ARE PAINTED TO PREVENT THIS FROM HAPPENING. HAD TO BUY COMPLETE BRAKE LINE KIT TO GET RIGHT FRONT LINE FOR REPLACEMENT BY DEALERSHIP FOR $452.85 . THEY RECOMMEND THAT I REPLACE ALL OF THE LINES. I CALLED CHEVROLET CUSTOMER SERVICE, COMPLAINT # 8-3176545196. I HAVE GOTTEN NO COOPERATION, THEY HAVE TOLD ME THERE IS NOTHING THAT THEY CAN DO. BECAUSE OF THIS POTENTIALLY CAUSING A CATASTROPHIC FATAL ACCIDENT DUE TO COMPLETE OR PARTIAL LOSS OF BRAKING POWER - IT GIVES NO WARNING UNTIL FAILURE OCCURS. I TOLD THEM THEY NEEDED TO PUT OUT AN ALERT TO OTHER DRIVERS AND THEY DECLINED STATING THAT THEY DID NOT HAVE ENOUGH COMPLAINTS. THIS TRUCK ONLY HAS 99546 MILES

Mileage: 99,456

APPEARS GM'S FAULTY BLOWER MOTOR RESISTOR HAS CLAIMED MY 2ND TRUCK. FIRE STARTED WHILE PARKED IN PARKING LOT. FIRE OCCURS ON PASSENGER SIDE AROUND GLOVE BOX AND GROWS. THIS TRUCK GAVE NO INDICATION OF "MELTING WIRES" THERE WAS NO SMELL OR SMOKE WHEN PARKED. THIS PART OF A SPECIAL COVERAGE #10240

Mileage: 399,000

SUDDEN FAILURE OF BRAKES DURING LOW SPEED STOP, BRAKE LINE FAILED NEAR FRAME UNDERSIDE IN DRIVER SEAT AREA. WAS ABLE TO QUICKLY STOP VEHICLE WITH EMERGENCY BRAKE JUST SHORT OF GOING INTO HEAVY TRAFFIC. THIS TRUCK IS METICULOUSLY MAINTAINED INCLUDING UNDERSIDE WASHES, NO BODY RUST ANYWHERE AND WAS UNDERCOAT PROTECTED FROM NEW. SHOCKED A LEVEL OF RUST ON WHAT ARE APPARENTLY HIGH CARBON STEEL LINES, THESE SHOULD BE STAINLESS STEEL.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 EQUIPPED WITH COOPER TIRES, DOT NUMBER: UTV6C8E4808, TIRE LINE: COOPER DISCOVERER ATR, TIRE SIZE: 265/75/R16. THE CONTACT STATED THAT WHILE DRIVING AT 63 MPH, THE CONTACT STATED THAT THERE WAS AN ABNORMAL VIBRATION FROM THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE TREAD SEPARATED FROM THE TIRE WHICH CAUSED DAMAGE TO THE BED OF THE VEHICLE. THE FAILURE OCCURRED ON THE REAR DRIVER SIDE TIRE. THE CONTACT STATED THAT THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS UNKNOWN. THE FAILURE MILEAGE ON THE VEHICLE WAS 114,900.

Mileage: 114,900

WHEN NORMAL STOPPING ABS ACTIVATES AND KEEPS ACTIVATING UNTIL PEDAL GOES TO FLOOR AND BRAKES DO NO FUNCTION, THERE ARE NO WARNING LITES AND NO INDICATION OF A PROBLEM.I WAS UNDER THE IMPRESSION THAT ANY ABS FAILURE WOULD REVERT SYSTEM TO REGULAR BRAKE SYSTEM. THIS IS VERY DANGEROUS.

Mileage: 49,952

BLOWER MOTOR FOR THE HVAC STARTED ALL BY ITS SELF AND RAN FULL BLAST. THE CONTROL PANEL HAD NO EFFECT ON THE SYSTEM . I COULD NOT CONTROL OR SHUT OFF THE BLOWER. EVEN WHEN THE TRUCK WAS PARKED, IN PARK AND SHUT DOWN AND THE KEYS REMOVED THE BLOWER CONTINUED TO RUN AT FULL BLAST. HAD TO DISCONNECT THE BATTERY. LATER AFTER HAVING TO DRIVE THE TRUCK TO WORK I FOLLOWED THE FUSE SCHEMATIC AND REMOVED THE GREEN I BELIEVE FUSE BREAKER FROM THE UNDER HOOD FUSE BOX. I HAVE LEFT THIS FUSE REMOVED SO THE BATTERY DOESN'T RUN DOWN.

Mileage: 97,000

I WAS DRIVING MY TRUCK ON 3/30/16 ANOTHER VEHICLE PULLED OUT IN FRONT OF ME. I SLAMMED ON MY BRAKES TO AVOID A WRECK. AT THE NEXT RED LIGHT I NOTICED MY BRAKES WERE SOFT. I PULLED OVER TO CHECK MY FLUID. IT WAS DOWN ABOUT AN INCH. I DECIDED TO TRY TO MAKE IT HOME. THEN A SERVICE BRAKE LIGHT CAME ON. I DID MAKE IT HOME. I CRAWLED UNDER THE TRUCK AND BRAKE FLUID WAS FROM THE FRONT TO THE BACK OF THE TRUCK. I NOTICED TWO COMPROMISED METAL BRAKE LINES ON THE DRIVER SIDE FRAME RAIL THAT WERE RUSTED THROUGH. I TOUCHED THE LINES AND THEY WERE FALLING APART AND FLAKING OFF METAL AT THE TOUCH. I CONTACTED CHEVROLET AND IT WAS TOWED TO THE DEALER. THEY QUOTED ME $1,100 TO REPAIR THE PROBLEM. MY TRUCK IS A 2006 I BOUGHT IT BRAND NEW IT HAS 59,500 MILES ON IT AND I PAID RIGHT AT $50,000 FOR MY TRUCK. IT IS UNACCEPTABLE FOR THIS TO HAPPEN IN LESS THAN 10 YEARS OF OWNERSHIP. THIS IS A HUGE SAFETY ISSUE SINCE CHEVROLET USED INFERIOR AND CHEAP PRODUCTS IN THEIR TRUCKS. THERE SHOULD BE A RECALL ON THIS

Mileage: 59,500

BREAK LINES ARE COMPLETELY RUSTED AND I AM AFRAID THEY WILL GO OUT WITHOUT WARNING. TRUCK ONLY HAS 67,000 MILES ON IT.

AIR BAG WARNING LIGHT COMING ON, HAVE NEVER HAD AN ACCIDENT IN THIS TRUCK.

Mileage: 141,000

BRAKE LINE FAILURE DUE TO EXCESSIVE CORROSION AS THE LINES LAY ON THE FRAME. LUCKILY, THE BREAK WAS AT HOME AND I WAS ABLE TO GET IT INTO THE SHOP FOR REPAIR. LESS THAN A MONTH LATER, ANOTHER LINE BROKE AS I WAS PULLING INTO MY DRIVE.

Mileage: 138,000

LOST BRAKES WHILE DRIVING IN RESIDENTIAL NEIGHBORHOOD DUE TO RUSTED BRAKE LINE. HAD IT TOWED TO MY MECHANIC WHO DID AN INSPECTION AND SAID ALL THE BRAKE LINES WERE RUSTED AT THE BRACKETS HOLDING THE LINES. MY MECHANIC IS IN THE PROCESS OF REPLACING THE BRAKE LINES. I TALKED TO SEVERAL OTHER PEOPLE WITH THE SAME YEAR TRUCK AND BOTH HAD ALSO EXPERIENCED BRAKE LINE FAILURE FROM RUST. TRUCK HAS ONLY 20K MILES AND HAS ONLY BEEN IN THE SALT TWICE AS I HAD AN OLDER VEHICLE I USED WHEN IT SNOWED. GM NEEDS TO CORRECT THIS SAFETY DEFECT.

Mileage: 20,000