2003 CHEVROLET SILVERADO

EXTERIOR LIGHTING

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIA

EQUIPMENT:ELECTRICAL

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

EQUIPMENT

AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.

VISIBILITY:WINDSHIELD

CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." SOME OF THESE VEHICLES LACK A CONTINUOUS URETHANE BONDING BEAD BETWEEN THE BODY SURFACE AND THE WINDSHIELD.

SEAT BELTS:REAR/OTHER

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT

PARKING BRAKE

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.

WHEELS:HUB

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO M

EXTERIOR LIGHTING

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED

STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF TH

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPME

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND A

SEAT BELTS:FRONT:ANCHORAGE

CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED

SERVICE BRAKES, HYDRAULIC

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

WHILE ROUTINELY DRIVING MY 03 CHEV SILVERADO TRUCK, THE BRAKES FAILED. WHEN I WAS ABLE TO SAFELY STOP AND MOVE TO A SAFE PLACE, I LOOKED UNDER THE VEHICLE AND SAW BRAKE FLUID LEAKING FROM ONE OF THE BRAKE LINES WHICH HAD FAILED DUE TO EXCESSIVE CORROSION. AS A RETIRED POLICE OFFICER, I HAVE EXCELLENT DRIVING SKILLS WHICH HELPED ME TO AVOID A COLLISION WITH ANOTHER VEHICLE WHEN THE BRAKES FAILED!

Mileage: 210,515

SIGNIFICANT CORROSION OF THE FUEL (GASOLINE) LINES CAUSING LEAK AND POSSIBLE SAFETY HAZARD (FIRE). SEVERAL FORUMS REPORT BRAKE AND FUEL LINE PREMATURE FAILURE DUE TO CORROSION. GM NOT ADDRESSING THIS KNOWN PROBLEM.

Mileage: 124,000

BRAKE LINES, GAS LINE, TRANSMISSION FLUID LINES ALL RUSTED/CORRODED BEGINNING AT UNDER 50,000 MILES. * HAD NEAR ACCIDENTS AS THE BRAKE LINES BLEW WHILE DRIVING ON A HIGHWAY AND WAS DECELERATING IN AN ATTEMPT TO COME TO A STOP..PEDAL WENT TO THE FLOOR, I CONTINUED ON (FOOT OFF THE GAS) UNTIL THE TRUCK SLOWED DOWN ENOUGH ON IT'S OWN, SHIFTED INTO LOW GEAR & WAS ABLE TO COME TO A STOP AND GET TOWED. * SHORTLY AFTER BRAKE LINE INCIDENT, THE SAME THING WITH THE GAS LINE, RUSTED/CORRODED AND LEAKED GASOLINE WHEN IGNITION WAS ON AND PUMP WAS RUNNING... TOWED * A FEW ,MONTHS LATER, I WAS PARKING THE TRUCK AND FLUID STARTED SPEWING FROM UNDER THE TRUCK - AFTER CLOSE EXAMINATION I DETERMINED IT WAS TRANSMISSION FLUID, THE LINES HAD RUSTED/CORRODED - AGAIN,TOWED. * REAR BUMPER ROTTED OUT COMPLETELY BEFORE HITTING 35,000 MILES- I HAD IT REPLACED, NOW THE WHEELS AND SIDE QUARTER PANELS AND EVERYTHING IN BETWEEN ARE ALSO ROTTING OUT. * CURRENTLY THE DASH LIGHTS/PANEL WILL INTERMITTEN

BRAKE LINES, GAS LINE, TRANSMISSION FLUID LINES ALL RUSTED/CORRODED BEGINNING AT UNDER 50,000 MILES. * HAD NEAR ACCIDENTS AS THE BRAKE LINES BLEW WHILE DRIVING ON A HIGHWAY AND WAS DECELERATING IN AN ATTEMPT TO COME TO A STOP..PEDAL WENT TO THE FLOOR, I CONTINUED ON (FOOT OFF THE GAS) UNTIL THE TRUCK SLOWED DOWN ENOUGH ON IT'S OWN, SHIFTED INTO LOW GEAR & WAS ABLE TO COME TO A STOP AND GET TOWED. * SHORTLY AFTER BRAKE LINE INCIDENT, THE SAME THING WITH THE GAS LINE, RUSTED/CORRODED AND LEAKED GASOLINE WHEN IGNITION WAS ON AND PUMP WAS RUNNING... TOWED * A FEW ,MONTHS LATER, I WAS PARKING THE TRUCK AND FLUID STARTED SPEWING FROM UNDER THE TRUCK - AFTER CLOSE EXAMINATION I DETERMINED IT WAS TRANSMISSION FLUID, THE LINES HAD RUSTED/CORRODED - AGAIN,TOWED. * REAR BUMPER ROTTED OUT COMPLETELY BEFORE HITTING 35,000 MILES- I HAD IT REPLACED, NOW THE WHEELS AND SIDE QUARTER PANELS AND EVERYTHING IN BETWEEN ARE ALSO ROTTING OUT. * CURRENTLY THE DASH LIGHTS/PANEL WILL INTERMITTEN

BRAKE LINES, GAS LINE, TRANSMISSION FLUID LINES ALL RUSTED/CORRODED BEGINNING AT UNDER 50,000 MILES. * HAD NEAR ACCIDENTS AS THE BRAKE LINES BLEW WHILE DRIVING ON A HIGHWAY AND WAS DECELERATING IN AN ATTEMPT TO COME TO A STOP..PEDAL WENT TO THE FLOOR, I CONTINUED ON (FOOT OFF THE GAS) UNTIL THE TRUCK SLOWED DOWN ENOUGH ON IT'S OWN, SHIFTED INTO LOW GEAR & WAS ABLE TO COME TO A STOP AND GET TOWED. * SHORTLY AFTER BRAKE LINE INCIDENT, THE SAME THING WITH THE GAS LINE, RUSTED/CORRODED AND LEAKED GASOLINE WHEN IGNITION WAS ON AND PUMP WAS RUNNING... TOWED * A FEW ,MONTHS LATER, I WAS PARKING THE TRUCK AND FLUID STARTED SPEWING FROM UNDER THE TRUCK - AFTER CLOSE EXAMINATION I DETERMINED IT WAS TRANSMISSION FLUID, THE LINES HAD RUSTED/CORRODED - AGAIN,TOWED. * REAR BUMPER ROTTED OUT COMPLETELY BEFORE HITTING 35,000 MILES- I HAD IT REPLACED, NOW THE WHEELS AND SIDE QUARTER PANELS AND EVERYTHING IN BETWEEN ARE ALSO ROTTING OUT. * CURRENTLY THE DASH LIGHTS/PANEL WILL INTERMITTEN

FRONT BRAKE LINES RUSTED THROUGH AND SPILLED BRAKE FLUID WHILE MOVING AT SLOW SPEED. HAD FRONT BRAKE LINES REPLACED. SIX MONTHS OR SO LATER, REAR BRAKE LINES RUSTED THROUGH AND SPILLED BRAKE FLUID WHILE MOVING AT SLOW SPEED. HAD REAR BRAKE LINES REPLACED. ABS IS NOW CONTAMINATED AND IS CAUSING STOP TIME DELAY, ESPECIALLY AT HIGH SPEED. ALMOST CRASHED ON SEVERAL OCCASIONS WHERE MY HEART DROPPED TO MY STOMACH. DECIDED NOT TO DRIVE TRUCK ANYMORE UNTIL I CAN REPLACE THE ENTIRE BRAKE SYSTEM WITH RUST FREE COMPONENTS.

Mileage: 129,000

WHILE DRIVING, THE HEATER BLOWER STOPPED WORKING AND I SMELLED BURNING PLASTIC OR INSULATION. I PULLED OVER AND FIGURED OUT IT WAS COMING FROM UNDER THE DASH. LOGICALLY I PULLED THE BOTTOM COVER OFF FROM BELOW THE BLOWER ASSY.(FORMER MECHANIC). SMELL WAS COMING FROM PLUG HARNESS AND RELAY. MELTED WIRE INSULATION AND MELTED PLASTIC FROM PLUG HARNESS(OBVIOUS SHORT). I WAS NEAR AN AUTO PARTS STORE AND CHECKED TO SEE IF THEY HAD THIS WIRING PLUG ASSY. AND THEY INFORMED ME THAT THEY DID AND THIS WAS AN ISSUE THAT GM HAD AND THERE HAD BEEN A SAFETY RECALL ON THIS. IT'S WINTER AND I NEEDED A DEFROSTER! ROADSIDE FIX, BUT THIS COULD HAVE BEEN MUCH WORSE. CONTACTED GM AND THEY INFORMED ME THAT THIS WAS NOT THEIR PROBLEM BECAUSE THE VIN NUMBER WASN'T PART OF THEIR RECALL. GM CASE # 8-174060432. NOT DROPPING THIS, THIS COULD HAVE GOTTEN WORSE.

Mileage: 126,000

BRAKE LINE RUPTURE.

Mileage: 191,830

THE FRONT TO REAR BRAKES CORRODED TO THE POINT WHERE THEY BLEW OUT WHEN THE BRAKES WERE APPLIED WHILE DRIVING ON THE HIGHWAY.

Mileage: 174,000

ON OCTOBER 22,2015 WHILE DRIVEING ON INTERSTATE 75 THE FUEL PUMP STOPPED FUNCTIONING AND RESULTING IN A NEAR DISASTEROUS SITUATION.RESULTS $751.81 REPAIR COST PLUS TOW. THEN ONE WEEK LATER,OCTOBER 29 2015 AT WILMINGTON PIKE AND INERTSTATE 675 RED LIGHT MY BRAKE LINES BURST AND I NARROWLY AVOIDED A WRECK. REPAIR COST $870.17 .I WAS NOT NOTEAFIDE OF ANY RECALL. SO BE FAIR WARNING IF I HAD KNOWN OR BEEN I WOULD HAVE FIXED IT

Mileage: 154,457

ON OCTOBER 22,2015 WHILE DRIVEING ON INTERSTATE 75 THE FUEL PUMP STOPPED FUNCTIONING AND RESULTING IN A NEAR DISASTEROUS SITUATION.RESULTS $751.81 REPAIR COST PLUS TOW. THEN ONE WEEK LATER,OCTOBER 29 2015 AT WILMINGTON PIKE AND INERTSTATE 675 RED LIGHT MY BRAKE LINES BURST AND I NARROWLY AVOIDED A WRECK. REPAIR COST $870.17 .I WAS NOT NOTEAFIDE OF ANY RECALL. SO BE FAIR WARNING IF I HAD KNOWN OR BEEN I WOULD HAVE FIXED IT

Mileage: 154,457

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER AND FAILED TO ACCELERATE. THE ABS, CHECK ENGINE, AND PASSENGER SIDE AIR BAG LIGHTS REMAINED ILLUMINATED. IN ADDITION, THE POWER STEERING FAILED. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT A FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER AND FAILED TO ACCELERATE. THE ABS, CHECK ENGINE, AND PASSENGER SIDE AIR BAG LIGHTS REMAINED ILLUMINATED. IN ADDITION, THE POWER STEERING FAILED. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT A FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER AND FAILED TO ACCELERATE. THE ABS, CHECK ENGINE, AND PASSENGER SIDE AIR BAG LIGHTS REMAINED ILLUMINATED. IN ADDITION, THE POWER STEERING FAILED. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT A FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

THIS IS THE SECOND OF THREE FATAL COLLISIONS INVESTIGATED THIS YEAR BY MY OFFICE INVOLVING CHEVROLET PICKUPS THAT CAUGHT FIRE AFTER BEING INVOLVED IN FRONTAL COLLISIONS. THIS WAS AN OFF SET HEAD ON, PASSENGER SIDE TO PASSENGER SIDE. PASSENGER IN PICKUP WAS PINNED IN VEHICLE DUE TO CRUSH AND CONSUMED BY FIRE.

THIS IS THE SECOND OF THREE FATAL COLLISIONS INVESTIGATED THIS YEAR BY MY OFFICE INVOLVING CHEVROLET PICKUPS THAT CAUGHT FIRE AFTER BEING INVOLVED IN FRONTAL COLLISIONS. THIS WAS AN OFF SET HEAD ON, PASSENGER SIDE TO PASSENGER SIDE. PASSENGER IN PICKUP WAS PINNED IN VEHICLE DUE TO CRUSH AND CONSUMED BY FIRE.

THIS IS THE SECOND OF THREE FATAL COLLISIONS INVESTIGATED THIS YEAR BY MY OFFICE INVOLVING CHEVROLET PICKUPS THAT CAUGHT FIRE AFTER BEING INVOLVED IN FRONTAL COLLISIONS. THIS WAS AN OFF SET HEAD ON, PASSENGER SIDE TO PASSENGER SIDE. PASSENGER IN PICKUP WAS PINNED IN VEHICLE DUE TO CRUSH AND CONSUMED BY FIRE.

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 35 MPH AND ATTEMPTING TO ENGAGE THE BRAKES, THE VEHICLE FAILED TO STOP. THE EMERGENCY BRAKE WAS USED TO STOP THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT BRAKE FLUID WAS LEAKING ABOVE THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE BRAKE LINE OVER THE FUEL TANK RUPTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

Mileage: 82,000

CONTACT OWN A 2003 CHEVROLET SILVERADO, WHILEDRIVING ATAPPROXIMATED 55 MPH, THE BRAKE PEDALWAS DEPRESSED IN A PANIC SIITUATION AND THE PEDALWENT STRAIGHT TO THE FLOOR BOARD. 8BF

CONTACT OWNS A 2003 CHEVROLET SILVERADO. CONTACTED STATED WHILE DRIVING AT APPROXIMATELY 55 MPH, THE BRAKE PEDAL WAS DEPRESSED IN A PANIC SITUATION AND THE PEDAL WENT STRAIGHT TO THE FLOOR BOARD. *BF